service VOLVO XC70 2007 Service Manual

2007 Volvo XC70
Volvo recommends .
Depending on your driving habits, premium or synthetic oils may provide \
superior fuel economy and
engine protection. Consult your Volvo retailer for recommendations on pr\
emium or synthetic oils.
Oil additives must not be used.
NOTE: Synthetic oil is not used when the oil is changed at the normal mainten\
ance services. This oil is
only used at customer request, at additional charge. Please consult your\
Volvo retailer.
Oil viscosity (stable ambient temperatures)
Operation in hot climates
When temperatures exceed 86° F (30° C) in your area, Volvo recom\
mends, for the protection of your
engine, that you use a heavier weight oil, such as such as SAE 5W- 40 or\
0W-40. See the viscosity chart.
Operation in temperate climates
Incorrect viscosity oil can shorten engine life. Under normal use when t\
emperatures do not exceed 86° F
(30° C), SAE 5W-30 will provide good fuel economy and engine protec\
tion. See the viscosity chart.
Extreme engine operation
Synthetic oils meeting SAE 0W-30 or 0W-40 and complying with oil quality\
requirements are
recommended for driving in areas of sustained temperature extremes (hot\
or cold), when towing a trailer
over long distances, and for prolonged driving in mountainous areas.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (9 of 38)12/30/2006\
5:51:43 PM

2007 Volvo XC70
American Petroleum Institute (API) symbol
The API Service Symbol "donut" is divided into three parts:
l The upper section describes the oil's performance level.
l The center identifies the oil's viscosity.
l The lower section indicates whether the oil has demonstrated energy-cons\
erving properties in a
standard test in comparison to a reference oil.
pg. 191 Maintenance and servicing
Engine oil
Changing engine oil and oil filter
See the previous page for oil specifications and
page 217 for oil volumes. Refer to the Warranty and
Service Records Information booklet for information on the oil change in\
tervals.
NOTE:
l Volvo does not recommend the use of oil additives.
l Synthetic oil is not used when the oil is changed at the normal maintena\
nce intervals except at owner
request and at additional charge. Please consult your Volvo retailer.
Checking and adding oil
The oil level should be checked every time the vehicle is refueled. This\
is especially important during
the period up to the first scheduled maintenance service.
l The vehicle should be parked on a level surface when the oil is checked.\

l If the engine is warm, wait for at least 10-15 minutes after the engine has been switched off\
before
checking the oil.
Checking the oil
- Pull out the dipstick and wipe it with a lint-free rag.
- Reinsert the dipstick, pull it out, and check the oil level.
- Add oil if necessary. If the level is close to the MIN mark, add appro\
ximately 1 US quart (1 liter) of oil.
- Run the engine until it reaches normal operating temperature.
- Switch off the engine and wait for at least 10-15 minutes and recheck \
the oil level. If necessary, add oil
until the level is near the mark.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (10 of 38)12/30/200\
6 5:51:43 PM

2007 Volvo XC70
Battery maintenance
The battery in your vehicle is located under the floor of the trunk.
Driving habits and conditions, climate, the number of starts, etc. all a\
ffect the service life and function of
the battery. In order for your battery to perform satisfactorily, keep t\
he following in mind:
l Check the fluid level in each cell in the battery every 24 months or eve\
ry 15,0001 miles (24,000 km),
whichever is sooner. The fluid should be at the level shown in the illus\
trations (A)
2. Do not overfill.
l Use a screw driver to open the caps or cover and a flashlight to inspect\
the level.
l If necessary, add distilled water. The level should never be above the i\
ndicator (A).
l The fluid level should be checked if the battery has been recharged.
l After inspection, be sure the cap over each battery cell or the cover is\
securely in place.
l Check that the battery cables are correctly connected and properly tight\
ened. Route ventilation hose
through opening in floor (see
page 197)
l Never disconnect the battery when the engine is running, for example whe\
n changing the battery.
l The battery should be disconnected from the vehicle when a battery charg\
er is used directly on the
battery.
l However, if the battery is being charged via the connecting points in th\
e engine compartment (see
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (16 of 38)12/30/200\
6 5:51:43 PM

2007 Volvo XC70
pg. 198 Maintenance and servicing
Replacing bulbs
When replacing bulbs, keep the following points in mind:
l Never touch the glass of bulbs with your fingers. Grease and oils from y\
our fingers vaporize in the
heat and will leave a deposit on the reflector, which will damage it.
l The optional Active Bi-Xenon headlight bulbs contain trace amounts of me\
rcury. These bulbs should
always be disposed of by an authorized Volvo retailer.
l The following bulbs should only be replaced by an authorized Volvo servi\
ce technician:
- Active Bi-Xenon headlights,
- Courtesy (dome) lighting,
- Reading lights,
- Glove compartment lights
- Turn signals and courtesy lights in the side door mirrors
- High-mounted brake lights
- Diodes in the rear tail lights
Replacing bulbs at the front of the vehicle
All front bulbs (except the optional front fog lights) are replaced fr\
om the engine compartment.
WARNING!
Active Bi-Xenon headlights (option) - due to the high voltage used by \
these headlights, these bulbs
should only be replaced by an authorized Volvo service technician.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (20 of 38)12/30/200\
6 5:51:43 PM

2007 Volvo XC70
Fluids and cooling system
Fluids
Transmission
1

Different types of oil should never be mixed.
Power steering
Grade: Volvo synthetic power steering fluid (Pentosin CHF 11S) P/N 1161529 o\
r equivalent.
Brake fluid
Fluid type: DOT 4+ boiling point >536 °F (280 °C).
Cooling system

The thermostat begins to open at 194 °F (90 °C).
1. The transmission oil does not normally need to be changed during the \
service life of the vehicle. However, it
may be necessary to replace the oil if the vehicle is often driven in ar\
eas of sustained temperature extremes (hot
or cold), when towing a trailer over long distances, for prolonged driv\
ing in mountainous areas, or if the vehicle
is often driven short distances in temperatures under 40°F (5°C)\
.
pg. 219 Specifications
Three way catalytic converter
Three-way catalytic converter cautions
l Keep your engine properly tuned. Certain engine malfunctions, particular\
ly involving the electrical,
fuel or distributor ignition systems, may cause unusually high three-way\
catalytic converter
temperatures. Do not continue to operate your vehicle if you detect engi\
ne misfire, noticeable loss of
file:///K|/ownersdocs/2007/2007_XC70/07xc70_10.htm (7 of 11)12/30/2006\
5:51:45 PM

2007 Volvo XC70

WARNING!
Active Bi-Xenon headlights (option) - due to the high voltage used by \
these headlights, these bulbs
should only be replaced by an authorized Volvo service technician.
pg. 222 Specifications
Electrical system
12-volt system with voltage controlled generator. Single wire system in \
which the chassis and engine
block are used as conductors, grounded on the chassis.
Battery
Voltage: 12 V
Cold start capacity (CCA): 600 A
Reserve capacity (RC): 115 min
Capacity (Ah): 70
If you must replace your battery, be sure to replace it with a battery o\
f the same cold start capacity and
file:///K|/ownersdocs/2007/2007_XC70/07xc70_10.htm (9 of 11)12/30/2006\
5:51:45 PM

2007 Volvo XC70
pg. 224 Specifications
Volvo programs
Volvo On Call Roadside Assistance
Your new Volvo comes with a four year ON CALL roadside assistance. Addit\
ional information,
features, and benefits are described in a separate information package i\
n your glove compartment.
If you have misplaced your package, dial:
In the U.S.A.:
1-800-638-6586 (1-800-63-VOLVO)
In Canada:
1-800-263-0475
Technician certification
In addition to Volvo factory training, Volvo supports certification by t\
he National Institute for
Automotive Service Excellence (A.S.E.). Certified technicians have dem\
onstrated a high degree of
competence in specific areas. Besides passing exams, each technician mus\
t also have worked in the field
for two or more years before a certificate is issued. These professional\
technicians are best able to
analyze vehicle problems and perform the necessary service procedures to\
keep your Volvo at peak
operating condition.



Contents | Top of Page
file:///K|/ownersdocs/2007/2007_XC70/07xc70_10.htm (11 of 11)12/30/200\
6 5:51:45 PM

2007 Volvo XC70
Defroster 77
Detachable trailer hitch
147
Door mirror defroster
60
Driver distraction
6
DSTC
52
Dynamic Stability and Traction Control (DSTC)
52
E
Economical driving
127
Electric socket
52
Electrically operated moonroof
70
Emission inspection
186
Engine - starting
125
Engine compartment
189
Engine oil
190, 217
Engine specifications
223
F
Federal Clean Air Act
184
FIX NEXT SERVICE
51
Fluids
218
Fog light
48
Front fog light, changing
202
Front park assist
153
Front seat - backrest
85
Front seats
86
Front suspension
220
Fuel
120
Fuel filler cap
2, 124
Fuel filler door
2, 123
Fuel gauge
46
Fuel tank, capacity
216
Fuses
205
G
file:///K|/ownersdocs/2007/2007_XC70/07xc70_12.htm (3 of 9)12/30/2006 \
5:51:48 PM

2007 Volvo XC70
K
Keylock
2, 125
Kickdown
131
L
Label information
213
Load carriers
148 -150
Locking steering wheel
126
Locking the car
114
Long distance trips
152
Low beam bulb, changing
199
Low beam headlights
57
M
Maintenance services
184
Maintenance, periodic
185
Malfunction indicator light
48
Manual transmission
129
Moonroof
70
Multifilter with air quality sensor
79
O
Occupant Weight Sensor
18
Octane rating
121
Odometer
46
Oil pressure
48
Oil quality
190
Owner maintenance
185
P
P Park
130, 132
Paint - color code
182
Park assist
153
Parking brake
48, 64
Parking light bulb, changing
200
Periodic owner-performed maintenance
185
file:///K|/ownersdocs/2007/2007_XC70/07xc70_12.htm (5 of 9)12/30/2006 \
5:51:48 PM

2007 Volvo XC70
Service 184
Service key
110
Service reminder
47
SERVICE REQUIRED
51
SERVICE URGENT
51
Shiftlock
2, 125
Side marker light, changing
202
Snow chains
170
Snow tires
170
Speedometer
46
Sport mode
133
Stability systems
139
Stability Traction Control (STC)
139
Start inhibitor (immobilizer)
110
Starting the car
125
STC
52, 139
Steel grid
104
Steering wheel lock
126
Stone chips, touching up
182
STOP ENGINE
51
Studded tires
170
Subwoofer
removing from cargo area
173
volume control
229
Subwoofer, removing
173
Sun visor
71
Supplemental Restraint System (SRS) - warning
light
47
Suspension
220
T
Tachometer
46
Temperature control
77
file:///K|/ownersdocs/2007/2007_XC70/07xc70_12.htm (7 of 9)12/30/2006 \
5:51:48 PM