steering YAMAHA FX HO CRUISER 2019 User Guide

Operation
76
(idle) position. (See page 29 for shift system
operation procedures.)
EJU43422Turning the watercraft
WARNING
EWJ01782
Do not release the throttle lever when
trying to steer away from objects—you
need throttle to steer. A collision could
result in severe injury or death.
When operating at higher speeds, make
gradual turns or slow down before turn-
ing. Sharp high-speed turns may cause
the watercraft to slide sideways or spin,
throwing the operator and passenger(s)
overboard, which could cause an injury.
Take early action to avoid collisions. The
RiDE system is not a braking device for
avoiding dangerous situations.
Steering control depends on the combination
of handlebar position and the amount of
throttle.
Water sucked in through the intake grate is
pressurized by the impeller in the jet pump.
As the pressurized water is expelled from the
pump through the jet thrust nozzle, it creates
thrust to move and steer the watercraft. The
higher the engine speed, the more thrust pro-
duced.
The amount of jet thrust, in addition to the po-
sition of the handlebars, determines how
sharply you turn.
A. More throttle produces higher thrust, so
the watercraft will turn more sharply.
B. Less throttle produces lower thrust, so
the watercraft will turn more gradually.
C. Releasing the throttle lever completely
produces only minimum thrust. If you are
traveling at speeds above trolling, you
will have rapidly decreasing ability to
1“F” (Forward position)
0
F13.6Vx100
RPM
100%
MPH
1
UF3V70E0.book Page 76 Tuesday, August 28, 2018 10:16 AM

Operation
77
steer without throttle. You may still have
some turning ability immediately after re-
leasing the throttle lever, but once the
engine slows down, the watercraft will no
longer respond to handlebar input until
you apply throttle again or you reach
trolling speed.
At trolling speed, the watercraft can be
turned gradually by handlebar position
alone using just the amount of thrust
available at idle.
D. If the engine is stopped while riding,
there is no thrust. The watercraft will go
straight even though the handlebars are
turned.
You need throttle to steer.
E. If the RiDE lever is squeezed and the
handlebars are turned when the water-
craft is cruising at planing speed, the wa-tercraft will turn gradually while slowing
down.
This model is equipped with the Yamaha En-
gine Management System (YEMS) that in-
cludes an off-throttle steering (OTS) system.
It will activate at planing speeds should you
attempt to steer the watercraft after releasing
the throttle lever (see condition C above).
The OTS system assists in turning by con-
tinuing to supply some thrust while the water-
craft is decelerating, but you can turn more
sharply if you apply throttle while turning the
handlebars. The OTS system does not func-
tion below planing speeds or when the en-
gine is off. Once the engine slows down, the
watercraft will no longer turn in response to
handlebar input until you apply throttle again
or you reach trolling speed.
EJU43252Stopping the watercraft
The watercraft is not equipped with a sepa-
rate braking system. The watercraft slows
down by water resistance or, when operating
in reverse, by the water jet. The watercraft
slows down as soon as the throttle lever is re-
leased, but will coast for a distance before
fully stopping. If you are not sure you can
stop in time before hitting an obstacle, apply
throttle and turn in another direction.
From full speed, the watercraft comes to a
complete stop due to water resistance in ap-
1Reverse gate
E
1
UF3V70E0.book Page 77 Tuesday, August 28, 2018 10:16 AM

Care and storage
89
EJU33493
Long-term storage
WARNING
EWJ00331
Always place the watercraft upright in a
horizontal position when storing it, other-
wise fuel could leak out into the engine or
engine compartment, which could create
a fire hazard.
Storage for long periods of time, such as win-
ter storage, requires preventive maintenance
to ensure against deterioration. It is advisable
to have the watercraft serviced by a Yamaha
dealer prior to storage.
However, the following procedures can be
performed easily by the owner.
EJU40763Cleaning
(1) Flush the cooling water passages. (See
page 85 for information on flushing the
cooling water passages.)
TIP:
If you will be storing the watercraft for a pro-
longed period, such as winter storage, top off
the fuel tank with fresh gasoline and add fuel
stabilizer and conditioner to the fuel tank ac-
cording to the manufacturer’s instruction be-
fore starting the engine.
(2) Clean the watercraft. (See page 86 for in-
formation on cleaning the watercraft.)
Wax the hull with a non-abrasive wax.
EJU44741Lubrication
To keep moving parts sliding or rotating
smoothly, lubricate them with water-resistant
grease.
Steering cable (jet thrust nozzle end), elec-
tric trim rod (jet thrust nozzle end), and ball
joint
TIP:
Disconnect the electric trim rod from the ball
joint before lubricating.
Shift rod (reverse gate end) and ball joint
TIP:
Disconnect the shift rod from the ball joint be-
fore lubricating.
EJU40812Rustproofing
Spray metallic parts of the hull, deck, and en-
gine with a rust inhibitor.
Have a Yamaha dealer rustproof the internal
engine components.
Recommended water-resistant grease:
YAMALUBE MARINE GREASE /
Ya m a h a G r e a s e A
UF3V70E0.book Page 89 Tuesday, August 28, 2018 10:16 AM

Maintenance
92
EJU43101Periodic maintenance chart
The periodic maintenance chart gives general guidelines for periodic maintenance. Have a
Yamaha dealer perform the checks in the following chart. However, maintenance may need
to be performed more frequently depending on your operating conditions. If you have any
questions, consult a Yamaha dealer.
This “√” mark indicates items to be checked and serviced by a Yamaha dealer.
Item OperationInitial Thereafter every
Page
10 hours50 hours
or 12
months
*1100
hours or
12
months
*1200
hours or
24
months
*1
Fuel lineCheck fuel hoses and
clamps√—
Fuel filler cap/Wa-
ter separatorCheck O-rings for cracks
and deformation√—
Fuel tankCheck installation and
straps√—
Water inlet strainerCheck for clogs and dam-
age√—
Cooling water hos-
esCheck for damage and
leakage, and check
clamps√—
Engine oilReplace√√94
Oil filterReplace√94
Intermediate hous-
ingLubricate√—
Spark plugsCheck√√—
BatteryCheck state of charge,
terminals, bands, and
breather hose√—
Battery leadsCheck terminals√—
Steering masterCheck operation and for
looseness√√—
Steering cableCheck exterior and con-
nections, and lubricate√—
Electric trim rodCheck exterior and con-
nections, and lubricate√—
Shift rod and re-
verse gate Check exterior and con-
nections, and lubricate√—
Air filter elementCheck for damage and
dirt√—
Air intake hosesCheck for damage, and
check clamps√
—
Throttle bodyLubricate throttle valve√—
UF3V70E0.book Page 92 Tuesday, August 28, 2018 10:16 AM

105
Index
A
Adjustable tilt steering system ................. 27
Adjustable tilt steering system checks .... 68
After removing the watercraft from the
water ..................................................... 84
B
Battery care.............................................. 86
Battery checks ......................................... 66
Battery, jumping ..................................... 100
Beaching and docking the watercraft ...... 83
Beverage holder ....................................... 53
Bilge water check..................................... 66
Bilge water, draining ................................ 59
Bilge water, draining on land ................... 59
Bilge water, draining on water ................. 60
Boarding alone ......................................... 79
Boarding and starting off from a dock ..... 82
Boarding the watercraft ........................... 79
Boarding with passenger(s) ..................... 80
Bow eye ................................................... 50
Bow storage compartment ...................... 51
Builder’s plate ............................................ 2
C
Capsized watercraft ................................. 82
Cleaning ................................................... 89
Cleaning the watercraft ............................ 86
Cleat ......................................................... 50
Cooling water pilot outlet ......................... 28
Cooling water pilot outlet check .............. 72
Craft Identification Number (CIN)............... 1
Cruise assist............................................. 37
Cruising limitations................................... 10
D
Drive control mode................................... 35
Drive control mode screen ....................... 43
E
Electric trim system.................................. 31
Electric trim system check ....................... 69
Emergency procedures ............................ 99
Engine break-in ........................................ 62
Engine compartment check ..................... 65
Engine cover, removing and installing ..... 90
Engine idling speed check ....................... 72
Engine lock screen ................................... 45
Engine oil ................................................. 58Engine oil and oil filter .............................. 94
Engine oil level check ............................... 66
Engine oil requirements ........................... 58
Engine serial number ................................. 1
Engine shut-off cord (lanyard) check ....... 69
Engine shut-off switch ............................. 25
Engine stop switch ................................... 25
Engine unit check ..................................... 66
Enjoy your watercraft responsibly ............ 18
Equipment ................................................ 48
F
Fire extinguisher check ............................ 70
Fire extinguisher holder and cover........... 54
Fire extinguisher holder, cover, and
band checks ......................................... 70
Flushing the cooling water passages....... 85
Fuel .......................................................... 56
Fuel level check........................................ 65
Fuel requirements .................................... 56
Fuel system checks ................................. 65
Fuses, replacing ..................................... 101
G
Getting to know your watercraft .............. 73
Glossary, watercraft ................................. 19
Glove compartment ................................. 52
H
Handgrip .................................................. 49
Hazard information................................... 14
Home screen ............................................ 41
Hood check .............................................. 71
Hull and deck check ................................ 70
I
Identification numbers ............................... 1
Information screen ................................... 42
J
Jet intake and impeller, cleaning.............. 99
Jet intake checks ..................................... 70
Jet thrust nozzle and reverse gate
check .................................................... 70
Jumper cables, connecting .................... 100
L
Labels, important ....................................... 4
Labels, other .............................................. 8
Labels, warning .......................................... 5
Launching the watercraft ......................... 74
UF3V70E0.book Page 105 Tuesday, August 28, 2018 10:16 AM

Index
106
Learning to operate your watercraft ........ 73
Leaving the watercraft ............................. 75
Limitations on who may operate the
watercraft................................................ 9
Long-term storage ................................... 89
Lubrication ............................................... 89
M
Main components, location of ................. 20
Maintenance ............................................ 90
Manufactured date label ............................ 2
Model information ...................................... 2
Multifunction information center .............. 39
Multifunction information center check ... 72
N
No-wake mode ........................................ 34
O
Operating in weeded areas ...................... 83
Operating the watercraft .......................... 75
Operating the watercraft in reverse or
neutral ................................................... 78
Operating your watercraft ........................ 73
Operation buttons .................................... 40
Operation requirements ........................... 11
Optional part mounting bracket ............... 55
P
Periodic maintenance chart ..................... 92
Post-launch checks ................................. 71
Post-operation care ................................. 85
Pre-launch checks ................................... 65
Pre-operation check points ..................... 65
Pre-operation checklist ............................ 63
Primary Identification (PRI-ID) number ...... 1
Pull-up cleats (FX Cruiser HO) ................. 51
R
Raising the reverse gate ........................ 100
Reboarding grip ....................................... 49
Reboarding step ...................................... 49
Recommended equipment ...................... 13
Removable watertight storage
compartment ........................................ 53
Reverse assist .......................................... 33
RiDE lever................................................. 26
RiDE lever checks .................................... 68
Riding position ......................................... 74
Rustproofing ............................................ 89S
Safe boating rules .................................... 17
Safety equipment check .......................... 70
Seats ........................................................ 48
Setting menu screen ................................ 43
Shift system ............................................. 29
Shift system check ................................... 72
Start switch .............................................. 25
Starting off ............................................... 81
Starting off from a trailer .......................... 82
Starting the engine on water .................... 74
Status area ............................................... 41
Steering system ....................................... 26
Steering system checks ........................... 67
Stern drain plug checks ........................... 71
Stern eyes ................................................ 50
Stern storage compartment ..................... 52
Stopping the engine ................................. 75
Stopping the watercraft ........................... 77
Storage compartment checks.................. 70
Storage compartments ............................ 51
Submerged watercraft ........................... 103
Switch checks .......................................... 69
T
T.D.E. (thrust directional enhancer) .......... 33
Throttle lever ............................................ 26
Throttle lever checks ................................ 68
Tool kit ..................................................... 90
Touch screen ........................................... 40
Towing the watercraft ............................ 103
Transporting on a trailer ........................... 61
Troubleshooting ....................................... 96
Troubleshooting chart .............................. 96
Turning the watercraft .............................. 76
W
Wakeboarding and water-skiing .............. 16
Warning function ...................................... 45
Water separator ....................................... 28
Water separator check ............................. 66
Watercraft characteristics ........................ 14
Watercraft control functions..................... 24
Watercraft operation functions ................ 29
Watercraft operation modes .................... 33
Y
Yamaha Security System ......................... 24
UF3V70E0.book Page 106 Tuesday, August 28, 2018 10:16 AM