4WD YAMAHA GRIZZLY 700 2019 User Guide

8-42
8
EBU29704Adjusting the throttle lever free playPeriodically check the throttle lever free play and
adjust if necessary.1. Slide the rubber cover back.
2. Loosen the locknut. 3. To increase the throttle lever free play, turn
the throttle lever free play adjusting bolt in di-
rection (a). To decrease the throttle lever free
play, turn the adjusting bolt in direction (b).
4. Tighten the locknut.
5. Slide the rubber cover to its original position.
EBU24061Valve clearanceThe valve clearance changes with use, resulting in
improper air-fuel mixture and/or engine noise. To
prevent this from occurring, the valve clearance
must be adjusted by a Yamaha dealer at the inter-
vals specified in the periodic maintenance and lu-
brication chart.EBU29602BrakesReplacement of brake components requires pro-
fessional knowledge. Brake service should be
performed by a Yamaha dealer.
WARNING
EWB02572Operating with improperly serviced or adjust-
ed brakes could lead to a loss in braking ability
and an accident.
1. Rubber cover
2. Throttle lever free play adjusting bolt
3. Locknut
4. Throttle lever free playThrottle lever free play: 3.0–5.0 mm (0.12–0.20 in)
2WD
4WD
3
2
1
4
(b)
(a)
UB4F60E0.book Page 42 Wednesday, April 25, 2018 11:52 AM

8-44
8
EBU29844Checking the brake fluid levelBefore riding, check that the brake fluid is above
the minimum level mark. Replenish the brake fluid
if necessary.TIPStraighten the handlebars for an accurate reading. Front brakeRear brake
NOTICEECB01161Brake fluid may damage painted surfaces or
plastic parts. Always clean up spilled fluid im-
mediately. As the brake pads wear, it is normal for the brake
fluid level to gradually go down. A low brake fluid
level may indicate worn brake pads or brake sys-
tem leakage. Therefore, be sure to check the
1. Minimum level mark
2WD
4WD
1
1. Minimum level markSpecified brake fluid:
DOT 4
UB4F60E0.book Page 44 Wednesday, April 25, 2018 11:52 AM

12-1
12
INDEX
AAccessories and loading ................................................ 6-5
Accessories, DC jack ................................................... 4-27
Air filter element, cleaning ........................................... 8-37
Axle boots .................................................................... 8-48BBattery ......................................................................... 8-52
Battery voltage warning light ......................................... 4-3
Brake fluid, changing ................................................... 8-45
Brake fluid level, checking ........................................... 8-44
Brake lever, front ......................................................... 4-16
Brake levers, checking and lubricating ........................ 8-49
Brake pads, checking the front and rear ..................... 8-43
Brake pedal and rear brake lever ................................. 4-16
Brake pedal, checking and lubricating ........................ 8-50
Brake pedal free play, adjusting .................................. 8-47
Brakes .......................................................................... 8-42
Brakes, front and rear .................................................... 5-3
Brake/tail light .............................................................. 8-61CCables, checking and lubricating ................................ 8-49
Carrier, front ................................................................. 4-25
Carrier, rear .................................................................. 4-25
Chassis fasteners .......................................................... 5-8
Cleaning ......................................................................... 9-1
Coolant .................................................................5-3, 8-29
Coolant temperature warning light ................................ 4-3DDifferential gear oil ................................................5-3, 8-27Drive select lever ......................................................... 4-17
Drive select lever and driving in reverse ........................ 6-2
EEngine break-in .............................................................. 6-4
Engine oil ....................................................................... 5-3
Engine oil and oil filter cartridge .................................. 8-20
Engine stop switch ...................................................... 4-11
Engine trouble warning light .......................................... 4-3
EPS warning light .......................................................... 4-4FFinal gear oil ......................................................... 5-3, 8-25
Four-wheel drive/differential gear lock icon .................. 4-4
Four-wheel drive switch (On-Command 4WD) ............ 4-12
Front and rear brake lever free play, checking ............ 8-46
Fuel ....................................................................... 4-19, 5-3
Fuel tank cap ............................................................... 4-18
Fuses, replacing .......................................................... 8-56HHandlebar switches ..................................................... 4-10
Headlight beam, adjusting ........................................... 8-60
Headlight bulb, replacing ............................................. 8-58
High beam indicator light ............................................... 4-2
High-range indicator light .............................................. 4-2
Horn switch .................................................................. 4-11IIdentification numbers ................................................. 11-1
Indicator lights and warning lights ................................. 4-2
Instruments, lights and switches ................................... 5-8
UB4F60E0.book Page 1 Wednesday, April 25, 2018 11:52 AM

12-2
12
LLabel locations ............................................................... 1-1
Light switch .................................................................. 4-11
Low-range indicator light ............................................... 4-2MMain switch .................................................................... 4-1
Maintenance and lubrication chart ................................8-5
Maintenance chart, emission control system ................ 8-3
Model label ................................................................... 11-1
Multi-function display .....................................................4-5NNeutral indicator light .....................................................4-2OOn-Command drive switch “4WD/LOCK” ................... 4-13
Override switch ............................................................ 4-12
Owner’s Manual and tool kit .......................................... 8-2PPanels, removing and installing ................................... 8-10
Park indicator light ......................................................... 4-2
Parking ........................................................................... 6-4
Parking on a slope ......................................................... 6-5
Part locations ................................................................. 3-1RRear knuckle pivots, lubricating ................................... 8-51
Reverse indicator light ................................................... 4-2
Riding your ATV ............................................................. 7-1SSafety information .......................................................... 2-1
Seat .............................................................................. 4-20
Shock absorber assemblies, adjusting the front and rear ............................................................................. 4-25 Spark arrester, cleaning ............................................... 8-40
Spark plug, checking ................................................... 8-18
Specifications .............................................................. 10-1
Speed limiter ................................................................ 4-15
Stabilizer bushes, checking ......................................... 8-51
Starting the engine ......................................................... 6-1
Start switch .................................................................. 4-11
Steering shaft, lubricating ............................................ 8-52
Storage .......................................................................... 9-2
Storage compartments ................................................ 4-21
TThrottle lever ........................................................ 4-15, 5-4
Throttle lever free play, adjusting ................................. 8-42
Tires ............................................................................... 5-4
Trailer hitch .................................................................. 4-26
Troubleshooting ........................................................... 8-63
Troubleshooting charts ................................................ 8-64VValve clearance ............................................................ 8-42
V-belt case drain plug .................................................. 8-41
Vehicle identification number ....................................... 11-1WWheel hub bearings, checking ..................................... 8-51
Wheel, installing ........................................................... 8-62
Wheel, removing .......................................................... 8-61
UB4F60E0.book Page 2 Wednesday, April 25, 2018 11:52 AM