recommended oil YAMAHA T105 1998 Owners Manual

EAE40104*Engine oil
Make sure the engine oil is at the specified
level. Fill with oil as necessary (see page 41
for details).
25
1Oil level gauge2Upper level3Lower level
Recommended oil:
Yamalube 4 (20W40) or equivalent
SAE 20W40 type SE motor oil
Oil quantity:
Total amount:
1.0 L
Periodic oil change:
0.8 L
T105(E) O/M-2 9/11/01 11:17 AM Page 25 (1,1)

*: It is recommended that these items be serviced by a Yamaha dealer.
**: Medium weight wheel bearing grease. (bearing type)
***: Lithium soap base grease. (bush type)
40
Check bearing assembly for looseness.
* Steering bearingCorrect if necessary. Moderately repack every228,000 km. **
* Front forksCheck operation/oil leakage. Repair if necessary.22* Rear shock absorberCheck operation/oil leakage. Repair if necessary.22
Drive chainCheck chain slack/alignment. Adjust if necessary.
EVERY 500 km
Clean and lube.
*
Fittings/FastenersCheck all chassis fitting and fasterners.
2222Correct if necessary.
* Centerstand and
Check operation. Repair if necessary.2222
sidestand
* BatteryCheck specific gravity. Check that the breather
22
pipe is working properly. Correct if necessary
INITIAL EVERY
ITEM REMARKS
500 km 2,000 km 4,000 km 8,000 km
T105(E) O/M-2 9/11/01 11:17 AM Page 40 (1,1)

e. Fill engine with oil through the oil
level gauge hole.EUU47700cC9Do not put in any chemical additives or
use oils with a grade of “CD (for Diesel
engine)” or higher. Also, be sure not to
use oils labeled “ENERGY CONSERVING
II” or higher. Engine oil also lubricates
the clutch and additives could cause
clutch slippage.
9Be sure no foreign material enters the
crankcase.f. Start the engine and warm up for a
few minutes. While warming up check
for oil leakage. If oil leakage is found,
stop the engine immediately, and ask
a Yamaha dealer to check the cause.
43
Recommended oil:
See page 25
Oil quantity:
Total amount:
1.0 L
Periodic oil change:
0.8 L
T105(E) O/M-2 9/11/01 11:17 AM Page 43 (1,1)

4. Apply recommended oil to the entire
surface of the filter and squeeze out
the excess oil. The element should be
wet but not dripping.
5. Install the element in its case.cC9If oil is not applied to the element, the
engine damage may occur.
9Make sure the element is properly seat-
ed in the filter case.
9The engine should never be run without
the air filter element installed; excessive
piston and/or cylinder wear may result.
45
Recommended oil:
Yamalube 2 (2 stroke engine oil) or
Yamalube 4 (20W40)
T105(E) O/M-2 9/11/01 11:17 AM Page 45 (1,1)

EAI30601Brake lever and pedal
Lubricate the pivoting parts.EAI30801Center and sidestand
Lubricate the pivoting parts. Check to see
that the center and sidestand move up and
down smoothly.
57
Recommended lubricant:
Yamalube 4 or SAE 20W40 motor oilRecommended lubricant:
Yamalube 4 or SAE 20W40 motor oil
T105(E) O/M-3 9/11/01 11:17 AM Page 57 (1,1)