brake light YAMAHA TT600RE 2004 User Guide

SIGNAL SYSTEM
7-52
ELEC
The diagram shows the signal system circuit inside the electric system of the motorcycle. NOTE:
For the colour codes and complete legend, see page 7-2.
(3) Battery
(6) Fuse
(7) Main switch
(11) Diode
(14) Neutral switch
(15) Diode
(18) Left handlebar switch
(19) Horn switch (23) Flasher switch
(24) Horn
(25) Flasher relay
(27) Flasher light
(29) Front brake switch
(30) Rear brake switch
(31) Tail/stop light
(32) Meter
&
(
'
&
$)
$
$
$%
*$
'*
(+
&
&
ProCarManuals.com

ELECSIGNAL SYSTEM
7-53
DIAGNOSTICS
•THE FLASHER LIGHTS, BRAKE LIGHT AND/OR WARNING LIGHTS FAIL TO TURN ON.
•THE HORN FAILS TO SOUND.
Procedure
Check:
1. Fuse
2. Battery
3. Main switch
4. Harness connections (entire system of con- nections)
NOTE:
•Before starting inspections, remove the following parts:
1. Seat
2. Rear cowling
3. Cowling (headlight)
4. Tail light cover
•To check for operating faults use the following special tools.
Pocket tester: P/N. 90890-03112
1. Fuse
•Check the fuse for continuity.
Refer to “CHECKING THE FUSES” in
Chapter 3.
•Is the fuse OK?
YES
2. Battery.
•Check the condition of the battery.
Refer to “CHECKING AND CHARGING
THE BATTERY” in Chapter 3.
Min. open-circuit voltage:
12.8 V or more at 20°C (68°F)
•Is the battery OK?
NO
Replace the fuse.
NO
•Clean the battery terminals.
•Recharge or replace the battery.
YES
*
ProCarManuals.com

ELECSIGNAL SYSTEM
7-57
CONTINUITY
DISCONTINUITY Replace the bulb and/or bulbholder.1. Bulb and bulbholder.
•Check the continuity of the bulb and bulb-
holder.
Refer to “BULB INSPECTION” section.
2. The rear stop light fails to turn on.
2. Brake switch.
•Disconnect the brake switch cables and
the connector from the wire harness.
•Connect the pocket tester ( Ωx 1) to the
brake switch terminals.
•Check the switch component for conti-
nuity between “Green/Yellow (1)” and
“Brown (2)”, or “Black (3)” and “Black (4)”. Refer to “SWITCH CHECK” section.
[A] Front brake switch
[B] Rear brake switch
INCORRECT
The brake switch is defective. Replace.
*
ON (Step down)
OFF (Free) BB
BB
G/Y Br
34
2
G/Y RW
1
ON (Pull in) OFF (Free)
G/Y
Br
A
B
Br
ProCarManuals.com

SIGNAL SYSTEM
7-58
ELEC
3. Voltage.
•Connect the pocket tester (DC 20V) to the
bulbholder connector.
Tester terminal (+) ➔Green/Yellow cable (1)
Tester terminal (–) ➔Black terminal (2)
•Turn the main switch to ON.
•The brake lever is pulled or the brake
pedal is pressed.
•Check the voltage (12V) on the
“Green/Yellow” cable of the bulbholder
connector.
OUT OF SPECIFICATION
The circuit from the main switch to the bulbhol-
der connector is defective. Repair.
IN COMPLIANCE WITH
SPECIFICATIONS (12V)
*
The circuit is efficient.
CONTINUITY
DISCONTINUITY
Replace the bulb and/or bulbholder.
3. The direction indicator light and/or the direc- tion indicator light fail to flash.
1. Bulb and bulbholder.
•Check the continuity of the bulb and bulb-
holder.
Refer to “BULB INSPECTION” section.
2. Direction indicator switch.
•Disconnect the left handlebar switch con-
nector from the wire harness.
•Connect the pocket tester ( Ωx 1) to the
left handlebar switch cables.
ProCarManuals.com

TRBL
SHTG
?
CHAPTER 8°
TROUBLESHOOTING
FAILURE TO START/DIFFICULTIES IN STARTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1
FUEL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1
ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
POOR ENGINE COMPRESSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
POOR PERFORMANCE AT IDLE SPEED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
UNSATISFACTORY PERFORMANCE AT MEDIUM-HIGH SPEED . . . . . . . . . . . . . . . . . 8-3
DIFFICULTIES IN SHIFTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
SHIFTING IMPOSSIBLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
THE SHIFT PEDAL FAILS TO MOVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
DISENGAGING GEARS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
CLUTCH SLIDES OR FAILS TO RELEASE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
CLUTCH SLIDES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
CLUTCH FAILS TO RELEASE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
DEFECTIVE BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
POOR BRAKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
OIL LEAKS OR MALFUNCTIONING OF FRONT FORK . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
OIL LEAKS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
MALFUNCTIONING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
UNSTABLE STEERING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-7
DEFECTIVE FUNCTIONING OF LIGHTS AND INDICATORS . . . . . . . . . . . . . . . . . . . . . 8-8
POOR HEADLIGHT ILLUMINATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
FREQUENT BURNING OF BULB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
DIRECTION INDICATORS FAIL TO TURN ON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
DIRECTION INDICATORS FAIL TO TURN OFF . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
DELAYED TURNING ON OF INDICATORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
EXCESSIVE INDICATOR INTERMITTENCE FREQUENCY . . . . . . . . . . . . . . . . . . . 8-9
THE HORN FAILS TO WORK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
OVERHEATING OF ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
ProCarManuals.com

DEFECTIVE FUNCTIONING OF LIGHTS AND INDICATORS/ OVERHEATING OF ENGINE
8-9
TRBL
SHTG
?
PROBABLE CAUSES
•Indicator lamp relay defective
•Insufficient battery capacity
(battery almost flat)
•Incorrect bulb
•Main switch or direction indicator switch defec-
tive
DELAYED TURNING ON OF INDICATORS
PROBABLE CAUSES
•Battery flat
•Main switch or horn switch defective
•Horn wrongly set
•Defective horn
•Harness cut off
THE HORN FAILS TO WORK
OVERHEATING OF ENGINE
PROBABLE CAUSES
•Incorrect bulb
•Indicator lamp relay defective
EXCESSIVE INDICATOR
INTERMITTENCE FREQUENCY
Ignition system
Fuel feed system PROBABLE CAUSES
•Incorrect electrode gap of spark plug
•Spark plug thermal gradation wrong
•Ignition unit defective
•Incorrect carburetor main jet (incorrect setting)
•Incorrect fuel level
•Air filter element obstructed
Engine compression
•Excess of carbon deposits
Engine oil
•Incorrect oil level
•Incorrect oil viscosity
•Incorrect oil gradation
Brake
•Pads fail to return freely (remains blocked)
ProCarManuals.com

TT600RE WIRING DIAGRAM
467C4B5CAMP403D494A4856 172320-2
GWLY
BB
B
BBLWRB
R
B
B
B
RLBOrRBLYGW
Or
B
LW
MAIN HARNESSB
B
B
Y Y
LBG
LGRBLYGWLWLBOrRB
LW
GY
GY
RBBr
Br
187
GB
12V10W
BL12V5WB
Y G
12V60/55WBGYA
A
12V10W
A
GB
BrBBrB
B
GBB
GBB
GBB
BrB
12V10WB
B
BrL
GB
12V10WB
B
187
BY
B
R
B
BrL
WWB
OFF
BrL
W
B
W
BB
B
B
BLB
BBrB
G
B
BrB
Br
OFF
B
EXT. CORD
Br
GY
BL
G Y
GYB
B
L
GB
BrB
LR
LR SbB
RW
-
LR
L
BrL
GBSbB
BrB
YBrBrB
YBrGB
B
Ch
DgBrY
BrB
HIGH
TURN
NEU.ILL.
B
BrL
BrL
LB
BY
LY
LB
LYGW
B
RBOr
205
B
RBLBrL
Br
PARKOFFON
ON
ON
Sb
L
GB
GY G
Y
RBLYBY
LYBY
RUN
LW
B
B
LY
BY
LBrRR
LWRB
GB
R
B
GW
BrBrW
WB
Br
LY
WB
Sb
B
GWLY
(BLUE)B
B
LYB
OFF
BrRB
LWRB
Y
P
G
GB BBrWBrL
BrB
W
WW
GYBr
GY
Y
P
G
GB BBrWBrL
BrB
Y
N
RL
LOWHIGH
BrW BrWBr
PPBr
LY
B
GWLY
Or
RBBr
LW
BY
BY
START
OFF
R
B
GWLY
W
W
W
W
W
W
WRW
W
W
Sb
B
Sb
B
BrBB
-
-
B
LR
WRW
B
-
A
L
L
GY
LB
Br
WB
RB
MAIN HARNESS
AHEAD LIGHT
B
B
BrB

17
16
11
12
13
14
15
91029
8
5
3
12
64
28
20
21
22
19
2325
24
30
31
27
267
32
18
ELECTRICAL SYSTEM
DIAGRAM1 AC generator/Pickup coil
2 Rectifier/Regulator
3 Battery
4 Starter relay
5 Starting motor
6 Fuse
7 Main switch
8 Right handlebar switch
9 Engine stop switch
0 Starter switch
q Diode
w Clutch switch
e Sidestand switch
r Neutral switch
t Diode
y Ignitor unit
u Ignition coil
i Left handlebar switch
o Horn switch
p Diode
a Pass switch
s Dimmer switch
d Flasher switch
f Horn
g Flasher relay
h Headlight
j Flasher light
k Relay assy
l Front brake switch
; Rear brake switch
z Tail/stop light
x Meter
COLOR CODE
B ...........Black
Br ..........Brown
Ch .........Chocolate
Dg .........Dark green
G...........Green Gy .........Gray
L............Blue
Lg..........Light green
O...........Orange
P ...........Pink R...........Red
Sb .........Sky blue
W..........White
Y ...........Yellow
B/L ........Black/Blue B/W.......Black/White
B/Y........Black/Yellow
Br/B.......Brown/Black
Br/L .......Brown/Blue
Br/W......Brown/White Br/Y.......Brown/Yellow
L/B ........Blue/Black
L/R ........Blue/Red
L/W .......Blue/White
L/Y ........Blue/Yellow R/B........Red/Black
R/G .......Red/Green
R/W.......Red/White
R/Y........Red/Yellow
ProCarManuals.com