maintenance YAMAHA TW125 2000 Service Manual

PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
5
6
7
8
9
6-39
EAU03009Troubleshooting chartEW000125
w
Never check the fuel system while smoking or in the vicinity of an open flame.
1. Fuel
2. Compression
3. Ignition
4. Battery
Use the electric starter.
Remove spark
There is compression.
Go to ignition check.
No compression.
Ask a Yamaha dealer to inspect.
Wet.
Dry.Wipe clean with dry cloth and Open throttle half-way and start
Ask a Yamaha dealer to inspect.
Engine turns over
Engine turns overBattery good.
Check fluid, recharge,
Use the electric starter.
Check if there is fuel
Enough fuel.
No fuel.Go to compression check.
Supply fuel.
in the fuel tank.
electrodes. plug and check
quickly.
slowly. check connections.Engine doesn’t start, go to battery
check.the engine. correct spark gap or replace plug.
Engine doesn’t start, ask a Yamahadealer to inspect.
Engine doesn’t start, go to compression check.
5EK-9-E1 (TW125)<3.1> 4/6/0 11:50 PM Page 69

7-5
MOTORCYCLE CARE AND STORAGE
1
2
3
4
5
6
7
8
97. Check and, if necessary, cor-
rect the tire air pressure, then
raise the motorcycle so that
both of its wheels are off the
ground. Alternatively, turn the
wheels a little every month in
order to prevent the tires from
becoming degraded in one
spot.
8. Cover up the muffler outlet
with a plastic bag to prevent
moisture from entering.
9. Remove the battery and fully
charge it. Store it in a cool, dry
place and recharge it once a
month. Do not store the bat-
tery in an excessively cold or
warm place (less than 0°C or
more than 30°C). For more
information, see “Battery stor-
age” in the chapter “PERIODIC
MAINTENANCE AND MINOR
REPAIRS”.
NOTE:
Make any necessary repairs before
storing the motorcycle.
5EK-9-E1 (TW125)<3.1> 4/6/0 11:50 PM Page 74