oil filter YAMAHA VX110 2005 User Guide

3-19
E
INSP
ADJ
POWER UNIT
5. Remove the air filter element and check it
for dirt and oil. Replace the air filter ele-
ment if there is any oil buildup.
CAUTION:
Do not start the engine with the air filter
case removed, otherwise the engine
could be damaged.
If cleaning the air filter element, use cold
or lukewarm water and let it air dry com-
pletely. Do not use detergent or a solvent
to clean the air filter element, or dry it with
heat or compressed air, otherwise it
could be damaged.
6. Install:
Air filter element
NOTE:
Install the air filter element with its projections
a
facing away from the projections b
on the
air filter case.
7. Install:
Air filter case cover
8. Install:
Air filter case
T R..
Air filter case cover screw (short):
1.5 N  m (0.15 kgf  m, 1.1 ft  lb)
LOCTITE 572
Air filter case cover screw (long):
1.2 N  m (0.12 kgf  m, 0.9 ft  lb)
LOCTITE 572
T R..
Air filter case:
17 N  m (1.7 kgf  m, 12 ft  lb)
a
b
ProCarManuals.com

5-74
EPOWRCRANKCASE
EXPLODED DIAGRAM
REMOVAL AND INSTALLATION CHART
Step Procedure/Part name Q’ty Service points
OIL PIPE AND OIL FILTER BOLT
REMOVALFollow the left “Step” for removal.
Crankshaft Refer to “CRANKSHAFT”.
1Bolt 1
2 Oil pipe 1
3 O-ring 2
4 Oil filter bolt 1
5 Lower crankcase 1
Reverse the removal steps for installation.
E
E
51
2
3
4
AA
6 × 10 mm
12 N • m (1.2 kgf
• m, 8.7 ft
• Ib)
35 N • m (3.5 kgf
• m, 25 ft
• Ib)
Not reusable
ProCarManuals.com

9-4
E
TRBL
ANLS
TROUBLE ANALYSIS
TROUBLE ANALYSIS
NOTE:
Before consulting the “TROUBLE ANALYSIS CHART,” check the following items.
1. Check that the battery is charged and that its specified gravity is within specification.
2. Check that there are no incorrect wiring connections.
3. Check that all wiring connections are properly secured and that they are not rusty.
4. Check that the engine shut-off cord (lanyard) is connect to the engine shut-off switch.
5. Check that fuel is reaching the fuel rail.
TROUBLE ANALYSIS CHART
Trouble mode Check elements
ENGINE WILL NOT START
HARD STARTING
ROUGH IDLING
HIGH IDLING
ENGINE STALLS
POOR ACCELERATION
ENGINE WILL NOT STOP
POOR PERFORMANCE
LIMITED ENGINE SPEED
OVERHEATING
LOW OIL PRESSURE
LOOSE STEERING
BILGE INCREASE
IRREGULAR WARNING INDICATION
POOR BATTERY CHARGING
Relative partReference
chapter
FUEL SYSTEM
Fuel tank 4
Fuel tank breather hose 4
Fuel hose 4
Fuel filter 4
Fuel pump 4
Fuel rail 4
Fuel injectors 4
Trolling speed 3
Air filter 3
ProCarManuals.com

9-5
E
TRBL
ANLS
TROUBLE ANALYSIS
POWER UNIT
Compression 5
Cylinder head gaskets 5
Cylinder block 5
Crankcase 5
Piston rings 5
Pistons 5
Bearings 5
Valve(s) and valve seat(s) 5
Valve clearance adjusting
pad(s)3
Camshaft(s) 5
Timing chain 5
Oil pump 5
Engine oil 3
Oil filter 3
Oil pressure switch 7
Bearing housing 5
Drive couplings 5
Rubber coupling 5
Pilot water hose 5
Water hose 5
Water passage 5 Trouble mode Check elements
ENGINE WILL NOT START
HARD STARTING
ROUGH IDLING
HIGH IDLING
ENGINE STALLS
POOR ACCELERATION
ENGINE WILL NOT STOP
POOR PERFORMANCE
LIMITED ENGINE SPEED
OVERHEATING
LOW OIL PRESSURE
LOOSE STEERING
BILGE INCREASE
IRREGULAR WARNING INDICATION
POOR BATTERY CHARGING
Relative partReference
chapter
ProCarManuals.com