gas type YAMAHA XT500E 2002 Owners Manual

6-31
PERIODIC MAINTENANCE AND MINOR REPAIR
6
EAU00800
BatteryBatteryThis motorcycle is equipped with a
sealed-type (MF) battery, which does
not require any maintenance. There
is no need to check the electrolyte or
to add distilled water.
EC000101
cCNever attempt to remove the bat-
tery cell seals, as this would per-
manently damage the battery.
8 8
KEEP THIS AND ALL BATTER-
IES OUT OF THE REACH OF
CHILDREN.
EW000116
w8 8
Electrolyte is poisonous and
dangerous since it contains
sulfuric acid, which causes
severe burns. Avoid any con-
tact with skin, eyes or clothing
and always shield your eyes
when working near batteries.
In case of contact, administer
the following FIRST AID.
9 9
EXTERNAL: Flush with plen-
ty of water.
9 9
INTERNAL: Drink large quan-
tities of water or milk and
immediately call a physician.
9 9
EYES: Flush with water for
15 minutes and seek prompt
medical attention.
8 8
Batteries produce explosive
hydrogen gas. Therefore, keep
sparks, flames, cigarettes,
etc., away from the battery and
provide sufficient ventilation
when charging it in an
enclosed space.
4PT-E7 (English) 6/29/01 9:13 AM Page 68

8-1
EAU01038
SPECIFICATIONS
8
SpecificationsSpecifications
Model XT500E/XT600E
Dimensions
Overall length 2,220 mm
2.295 mm (N, S, CH only)
Overall width 865 mm
825 mm (CH only)
Overall height 1,205 mm
Seat height 855 mm
Wheel base 1,440 mm
Ground clearance 230 mm
Minimum turning radius 2,300 mm
Basic weight (with oil and full
fuel tank)176 kg
172 kg (CH only)
Engine
Engine type Air-cooled 4-stroke, SOHC,
gasoline
Cylinder arrangement Forward inclined single
cylinder
Displacement 499 cm
3
595 cm
3
Bore ×Stroke 87.0 ×84.0 mm (XT500E)
95.0 ×84.0 mm (XT600E)
Compression ratio 8.5:1
Starting system Electric starter
Lubrication system Dry sump
Engine oil
Type
Recommended engine oil
classification API Service SE, SF, SG type
or highercCBe sure to use motor oils that do not contain anti-friction
modifiers. Passenger car motor oils (often labeled
“ENERGY CONSERVING II”) contain anti-friction additives
which will cause clutch and/or starter clutch slippage, result-
ing in reduced component life and poor engine performance.
Capacity
Without oil filter element
replacement 2.7 L
With oil filter element
replaced 2.8 L
Total amount (dry engine) 3.3 L
–10° 0° 10° 20° 30°
40°
SAE 10W/30
SAE 10W/40
SAE 20W/40
SAE 20W/50
–20°
SAE 15W/40 50°C
4PT-E7 (English) 6/29/01 9:13 AM Page 88

8-2
SPECIFICATIONS
8
Air filterDry type element
Fuel
Type REGULAR UNLEADED
GASOLINE ONLY
Fuel tank capacity 15 L
Reserve amount 2 L
Carburetor
Type×quantity Y26PV×1
Manufacturer TEIKEI
Spark plug
Type/Manufacturer DPR8EA-9 or DPR9EA-9/NGK
Spark plug gap 0.8–0.9 mm
Clutch typeWet, multiple-disc
Transmission
Primary reduction system Spur gear
Primary reduction ratio 74/31 (2.387) (XT500E)
71/34 (2.088) (XT600E)
Secondary reduction system Chain drive
Secondary reduction ratio 2.533 (XT500E)
3.000 (XT600E)
Number of drive chain 38/15 (XT500E)
sprocket teeth (rear/front) 45/15 (XT600E)
Transmission type Constant mesh 5-speed
Operation Left foot operationGear ratio 1st 2.583
2nd 1.588
3rd 1.200
4th 0.954 (XT500E)
0.955 (XT600E)
5th 0.792
Chassis
Frame type Diamond
Caster angle 27.75°(XT500E)
27°45’ (XT600E)
Trail 120 mm
Tire
Front
Type With tube
Size 90/90-21 54S or
90/90-21 M/C 54S
Manufacturer/ BRIDGESTONE / TW47
model DUNLOP / TRAIL MAX L
Rear
Type With tube
Size 120/90-17 64S or
120/90-17 M/C 64S
Manufacturer/ BRIDGESTONE / TW48
model DUNLOP / TRAIL MAX
Maximum load* 176 kg (XT500E)
180 kg (XT600E)
4PT-E7 (English) 6/29/01 9:13 AM Page 89

8-3
SPECIFICATIONS
8
Air pressure (cold tire)
up to 90 kg load*
Front 150 kPa (1.50 kgf/cm
2, 1.50 bar)
Rear 150 kPa (1.50 kgf/cm2, 1.50 bar)
90 kg load–Maximum
load*
Front 150 kPa (1.50 kgf/cm2, 1.50 bar)
Rear 225 kPa (2.25 kgf/cm2, 2.25 bar)
Off-road riding
Front 125 kPa (1.25 kgf/cm2, 1.25 bar)
Rear 125 kPa (1.25 kgf/cm2, 1.25 bar)
High speed riding
Front 150 kPa (1.50 kgf/cm2, 1.50 bar)
Rear 225 kPa (2.25 kgf/cm2, 2.25 bar)
* Total weight of rider, passenger, cargo and accessories
Wheels
Front
Type Spoke wheel
Size 21 ×1.85
Rear
Type Spoke wheel
Size 17 ×MT2.50 or
17 M/C ×MT2.50Brakes
Front
Type Single disc brake
Operation Right hand
Fluid DOT 4
Rear
Type Single disc brake
Operation Right foot
Fluid DOT 4
Suspension
Front
Type Telescopic fork
Rear
Type Swingarm (new monocross)
Shock absorber
Front Coil spring/oil damper
Rear Coil spring/gas-oil damper
Wheel travel
Front 225 mm
Rear 200 mm
4PT-E7 (English) 6/29/01 9:13 AM Page 90