headlight bulb YAMAHA XVS125 2002 Owners Manual

Tires ...............................................................6-15
Spoke wheels ................................................6-18
Adjusting the clutch lever free play ................6-19
Adjusting the brake lever free play ................6-20
Adjusting the brake pedal position and free
play ..............................................................6-20
Adjusting the rear brake light switch ..............6-22
Checking the front brake pads and rear
brake shoes .................................................6-22
Checking the brake fluid level ........................6-23
Changing the brake fluid ................................6-24
Drive chain slack ............................................6-25
Lubricating the drive chain .............................6-27
Checking and lubricating the cables ..............6-27
Checking and lubricating the throttle grip
and cable .....................................................6-28
Checking and lubricating the brake and
shift pedals ...................................................6-28
Checking and lubricating the brake and
clutch levers .................................................6-29
Checking and lubricating the sidestand .........6-29
Checking the front fork ...................................6-29
Checking the steering ....................................6-30
Checking the wheel bearings .........................6-31
Battery ...........................................................6-31
Replacing the fuses .......................................6-33Replacing the headlight bulb .........................6-34
Replacing a turn signal light bulb ...................6-36
Replacing the tail/brake light bulb ..................6-37
Supporting the motorcycle .............................6-37
Front wheel ....................................................6-38
Rear wheel .....................................................6-40
Troubleshooting .............................................6-41
Troubleshooting chart ....................................6-42
MOTORCYCLE CARE AND STORAGE ...........7-1
Care .................................................................7-1
Storage ............................................................7-4
SPECIFICATIONS .............................................8-1
Specifications ...................................................8-1
Conversion table ..............................................8-5
CONSUMER INFORMATION ............................9-1
Identification numbers ......................................9-1
Key identification number ................................9-1
Vehicle identification number ...........................9-1
Model label ......................................................9-2
TABLE OF CONTENTS
789
5JX-28199-E2 honbun 10/11/01 2:14 PM Page 6

6-34
PERIODIC MAINTENANCE AND MINOR REPAIR
6
EAU04189
Replacing the headlight bulb
Headlight bulb, replacing
This motorcycle is equipped with a
quartz bulb headlight. If the headlight
bulb burns out, replace it as follows.
1. Remove the headlight unit by
removing the screws.2. Disconnect the headlight cou-
pler, and then remove the bulb
cover.
1
2
1
1. Headlight unit
2. Screw (×2)1. Headlight coupler
EC000103
cCDo not use a fuse of a higher
amperage rating than recommend-
ed to avoid causing extensive
damage to the electrical system
and possibly a fire.3. Turn the key to “ON” and turn on
the electrical circuit in question to
check if the device operates.
4. If the fuse immediately blows
again, have a Yamaha dealer
check the electrical system.
5JX-28199-E2 honbun 10/11/01 2:14 PM Page 64

6-35
PERIODIC MAINTENANCE AND MINOR REPAIR
6 3. Unhook the headlight bulb hold-
er, and then remove the defec-
tive bulb.
EW000119
wHeadlight bulbs get very hot.
Therefore, keep flammable prod-
ucts away from a lit headlight bulb,
and do not touch the bulb until it
has cooled down.4. Place a new headlight bulb into
position, and then secure it with
the bulb holder.
EC000105
cCDo not touch the glass part of the
headlight bulb to keep it free from
oil, otherwise the transparency of
the glass, the luminosity of the
bulb, and the bulb life will be
adversely affected. Thoroughly
clean off any dirt and fingerprints
on the headlight bulb using a cloth
moistened with alcohol or thinner.5. Install the headlight bulb cover,
and then connect the coupler.
1
a
1. Headlight bulb holder a. Do not touch this area.
1
1. Bulb cover
5JX-28199-E2 honbun 10/11/01 2:14 PM Page 65

6-36
PERIODIC MAINTENANCE AND MINOR REPAIR
6
EAU03218
Replacing a turn signal light
bulb1. Remove the turn signal lens by
removing the screws.2. Remove the defective bulb by
pushing it in and turning it coun-
terclockwise.
3. Insert a new bulb into the socket,
push it in, and then turn it clock-
wise until it stops.
4. Install the lens by installing the
screws.
EC000108
cCDo not overtighten the screws,
otherwise the lens may break.
2
1
1
1. Lens
2. Screw (×2)1. Bulb
6. Install the headlight unit by
installing the screws.
7. Have a Yamaha dealer adjust
the headlight beam if necessary.
5JX-28199-E2 honbun 10/11/01 2:14 PM Page 66

8-4
SPECIFICATIONS
8
Battery
Type GT6B-3
Voltage, capacity 12 V, 6 Ah
Headlight typeHalogen bulb
Bulb voltage, wattage ×quantity
Headlight 12 V, 60/55 W ×1
Tail/brake light 12 V, 5/21 W ×1
Front turn signal light 12 V, 21 W ×2
Rear turn signal light 12 V, 21 W ×2
Auxiliary light 12 V, 4 W ×1
Meter lighting 12 V, 1.7 W ×1
Neutral indicator light 12 V, 1.7 W ×1
High beam indicator light 12 V, 1.7 W ×1
Turn indicator light 12 V, 1.7 W ×1
Engine indicator light 12 V, 1.7 W ×1
Fuses
Main fuse 30 A
Headlight fuse 15 A
Signaling system fuse 10 A
Ignition fuse 10 A
Carburetor heater fuse 10 A
5JX-28199-E2 honbun 10/11/01 2:14 PM Page 81