lock YAMAHA XVS650 2000 User Guide

6-22
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
1. Minimum level mark
EAU00731
Inspecting the brake fluid
levelInsufficient brake fluid may let air enter
the brake system, possibly causing the
brakes to become ineffective.
Before riding, check that the brake flu-
id is above the minimum level and re-
plenish when necessary. Observe
these precautions:l
When checking the fluid level,
make sure the top of the master
cylinder is level by turning the
handlebars.
l
Use only the designated quality
brake fluid. Otherwise, the rubber
seals may deteriorate, causing
leakage and poor brake perfor-
mance.
l
Refill with the same type of brake
fluid. Mixing fluids may result in a
harmful chemical reaction and
lead to poor brake performance.
l
Be careful that water does not en-
ter the master cylinder when refill-
ing. Water will significantly lower
the boiling point of the fluid and
may result in vapor lock.
l
Brake fluid may deteriorate paint-
ed surfaces or plastic parts. Al-
ways clean up spilled fluid
immediately.
l
Have a Yamaha dealer check the
cause if the brake fluid level goes
down. Recommended brake fluid: DOT 4
EAU00742
Brake fluid replacementThe brake fluid should be replaced
only by trained Yamaha service per-
sonnel. Have the Yamaha dealer re-
place the following components during
periodic maintenance or when they are
damaged or leaking:l
oil seals (every two years)
l
brake hoses (every four years)

6-27
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9Battery storage
When the motorcycle is not used for a
month or longer, remove the battery,
fully charge it and store it in a cool, dry
place.
EC000102
CAUTION:l
Completely recharge the bat-
tery before storing. Storing a
discharged battery can cause
permanent battery damage.
l
Use a battery charger designed
for a sealed-type (MF) battery.
Using a conventional battery
charger will cause battery
damage. If you do not have a
sealed-type battery charger,
contact your Yamaha dealer.
l
Always make sure the connec-
tions are correct when reinstall-ing the battery.
1. Fuse block
2. Main fuse
3. Spare fuse
EAU00825*
Fuse replacementThe fuses are located behind panel B.
(See page 6-5 for panel removal pro-
cedures.)
If a fuse is blown, turn off the main
switch and the switch of the circuit in
question. Install a new fuse of proper
amperage. Turn on the switches and
see if the electrical device operates. If
the fuse immediately blows again, con-
sult a Yamaha dealer.
1. Ignition fuse
2. Signaling system fuse
3. Headlight fuse
4. Carburetor heater fuse
5. Spare fuse
EC000103
CAUTION:
Do not use fuses of higher amper-
age rating than those recommend-
ed. Substitution of a fuse of
improper rating can cause exten-
sive electrical system damage andpossibly a fire.

6-28
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9 Specified fuses:
Main fuse: 30 A
Ignition fuse: 10 A
Signaling system fuse: 10 A
Headlight fuse: 15 A
Carburetor heater fuse: 15 A
1. Screw (´ 2)
EAU00833
Headlight bulb replacementThis motorcycle is equipped with a
quartz bulb headlight.
If the headlight bulb burns out, replace
the bulb as follows:
1. Remove the headlight unit
screws.
2. Remove the connectors, the
headlight unit and then the bulb
cover.
1. Bulb holder3. Turn the bulb holder counter-
clockwise to remove it and re-
move the defective bulb.
EW000119
WARNING
Keep flammable products and your
hands away from a bulb while it is
on, as it is hot. Do not touch a bulbuntil it cools down.
4. Put a new bulb into position and
secure it in place with the bulb
holder.

6-29
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EC000105
CAUTION:
Avoid touching the glass part of a
bulb. Keep it free from oil; other-
wise, the transparency of the glass,
life of the bulb, and luminous flux
will be adversely affected. If oil gets
on a bulb, thoroughly clean it with a
cloth moistened with alcohol or lac-quer thinner.
5. Install the bulb cover, connectors
and headlight unit. Ask a Yamaha
dealer to adjust the headlight
beam if necessary.
1. Screw (´ 2)
EAU00855
Turn signal and taillight bulb
replacement1. Remove the screws and the lens.
2. Push the bulb inward and turn it
counterclockwise.
XVS6501. Screw (´ 2)3. Place a new bulb in the socket.
Push the bulb inward and turn it
clockwise until it engages into the
socket.
4. Install the lens and the screws.

INDEX
A
Air filter ....................................................6-12
Antitheft alarm (optional) ..........................3-3
B
Battery ....................................................6-26
Brake and clutch lever lubrication ..........6-24
Brake and shift pedal lubrication ............6-23
Brake fluid replacement ..........................6-22
Brake light switch adjustment .................6-21
C
Cable inspection and lubrication ............6-23
Carburetor adjustment ............................6-13
Care ..........................................................7-1
Checking the front brake pads and
rear brake shoes ..................................6-21
Clutch lever ...............................................3-5
Clutch lever free play adjustment ...........6-18
Controls/Instruments
(XVS650/XVS650A) ..............................2-5
D
Dimmer switch ..........................................3-3
E
Engine break-in ........................................5-5
Engine oil ..................................................6-9
Engine stop switch ...................................3-4
Engine trouble indicator light ....................3-2
F
Final gear oil ...........................................6-11
Front brake lever ......................................3-5
Front brake lever free play
adjustment ...........................................6-19
Front fork inspection ...............................6-25
Front wheel installation ...........................6-31
Front wheel removal ...............................6-31
Fuel ...........................................................3-7
Fuel cock ..................................................3-8
Fuel tank breather hose ...........................3-7
Fuel tank cap ............................................3-6
Fuse replacement ...................................6-27
G
Give safety the right of way ......................1-1
H
Handlebar switches ..................................3-3
Dimmer switch ....................................3-3
Engine stop switch ..............................3-4
Horn switch .........................................3-3
Lights switch .......................................3-4
Pass switch .........................................3-3
Start switch .........................................3-4
Turn signal switch ...............................3-3
Headlight bulb replacement ...................6-28
Helmet holder .........................................3-12
High beam indicator light ..........................3-2
Horn switch ...............................................3-3
I
Identification number records ...................9-1
Idle speed adjustment ............................6-14
Indicator lights ..........................................3-2
Engine trouble indicator light ..............3-2
High beam indicator light ....................3-2
Neutral indicator light ..........................3-2
Turn indicator light ..............................3-2
Inspecting the brake fluid level ...............6-22
K
Key identification number .........................9-1
L
Left view (XVS650) ...................................2-1
Left view (XVS650A) ................................2-3
Lights switch .............................................3-4
Luggage strap holders ............................3-15
M
Main switch/Steering lock .........................3-1
Model label ...............................................9-2
N
Neutral indicator light ................................3-2
P
Panel A .....................................................6-6
Panel B .....................................................6-7
Panel removal and installation .................6-5
Parking ......................................................5-6