dashboard ACURA INTEGRA 1998 Service Manual PDF

Cable Reel
Replacement
@ store a removed airbag with the pad sur-
tac€ up. lf the airbag is improperly stored face down,
.ccidontal dcployment could propel the unit with
.nough torce to cause serious injury.
CAUTIONT
o Carefully insp€ct the airbag belore installing it. Do
not install an airbag that shows signs of boing
dropped or improperly handled, such as dents,
cracks or deformation.
. Always disconnect the airbag connector(s) when the
harness is disconnectod.
. Do not disassemble or tamper wiih the airbag.
1. Make sure you have the anti-theft code for the radio,
then write down the frequencies for the radio's pr+
set button.
2. Disconnect the battery negative cable, then discon-
nect the positive cable from the battery. and wait at
least three minutes,
3. Remove the access panel from the steering wheel,
then disconnect the 2P connector between the driv'
er's airbag and cable reel.
NOTE: When disconnected. the airbag connector is
automaticallv shoned.
DRIVER'S AIRBAG2P CONNECTORORIVER'S AIRSAGASSEMELY
CABLE REEL2P CONNECTOR
23-322
4, Make sure the wheels are aligned straight ahead.
5. Remove the dashboard lower cover and knee bol-
ster.
TORX BOLTSUse e Torx T30 bit.
DASHBOARD LOWER COVER
Remove the two Torx bolts from the steering wheel,
then remove the driver's airbag.

Instsll the steering wheel bolt, then install the driv-
er's airbag.
TORX BOLTS9.8 N m {1.0 kgf'm,7.2 lbtftlReplace.U3e . Torx T30 bit.
STEERING WHEEL NUT19 N.m (5 kgl.m, 36 lbl.ftl
Anach the 2P and 3P connectors to the connector
holder. then install the knee bolster and dashboard
lowgr cover,
le
CONNECTOR HOLDER
DASHBOARD LOWER COVER
23-325
\
'19. Reconnect the driver's aibag 2P connector to the
cable reel 2P connector, and reinstSll the access
panel on the steering wheel.
20, Reconnect the battery positive cable, then the nega-
tivs cable.
21. After installing the cable reel, confirm proper sys-
tgm operation:
Turn the ignition switch ON (ll); the SRS indica-
tor light should come on for about six seconds
and thsn go off.
Make surs both horn buttons work.
Make sure the headlight and wiper switches
Go {or a test drive, and make sure the cruise con-
trol switches work.
Ent6r the anti-theft code for tho radio, then enter the
customsr's radio station presets.
a
a

Circuit ldentification for In'Line and Fuse Box Connectors
tuse the chart (on page 204, sample below) to help diagnose multiple symptoms in separate
circuits which could be caused by a single problem in a connect,oishared by those circuits'
Here's how that chart could help you find such a problem:
1. Pick one of the multiple symptoms and look up the schematic for that circuit'
2. Make a list of all in-lrne and fuse box connectors in that schematic (include page numbers).
3. Then, in the chart, look up each connector on your list to see if circuits related to the other
symptoms run through one of them. lf they do, inspect that connector for the problem.
Example: The horn, A,/C, and the right headlight don't work. List all in-line and fuse box
connectors in the horn circuit and then check the chart (sample below). You find that C211 is
common to the A,/C circuit and the headlight circuit, so you inspect c211 and find the problem:
bent terminals.
)Connector
(6 or more
cavities)
Numbel of
Cavities - Color
1O-GRY
I 12-GRY
I
Wire
Harnesses
I Main/ | ComP er 'ror c.ntrols,
I Dashboard I
Circuits
Ant!lock brake system (ABS), Cruise control,
Programmed {uel injection system (PGM-FD
!ngrnei
lvlain
lgnition system
Antilock brake system (ABS), BIower controls, Fans,
Wiper/washer
lgnition system, Starting system
Blower controls, Compressor controls, Headlights'
Horns, Vehicle speed sensor (VSS), Wiper/washer
Programmed fuel injection system (PGM-Fl)'
Starting system
Engine/ |Main I
)

Fuse/Relay Information
- Under-dash Fuse/Relay Box
Front Viewt4
c55't(To dashboard wire harness)
c661(To root wire harness)
c801Oo SFIS main harness)c922(To ignition switch)
c440{To rrain wire harness)
c441(To main wire harness)
c442flo rra n wire harness)
c92sOo power window relay)
c928(Not used)
Rear View
c504(To rear wire harness)
c503. : Spare fuser : Not UsedO : Option (+B)
O : Option (Dash lights)O : Option (ACC)
O : Option (lG2)c439(To main wire harness)
6
-) n Fl r"r r'r rl r-l r-r ri r'1 Tl rl r-1. 23 24 25 26 27 2a 29 30 31 32 33t_-.1 u u ! tJ LJ Ll t. Ll tJ l. tJ
- r-l n T'l T-l r't T-1 T-t r-l T-t r-l r'1.12 13 14 15 16 17 18 19 2A 21 22LI tJ LJ LI tJ I.J t-J tJ IJ IJ IJ I.J
r-r Tl l;t T'l T-l T'1 rn r-l T-t r'l T1 Tl r'1 n. 1 2 3 4 5 6 7 I 9 10 11 . .t-l LJ LJ LJ LJ [J t-t LJ Ll LJ t_l t-J Lr u
(To rear wire harness)

Component Location
tf-
49. Center of Steering Wheel52. Rear of Dashboard Lower Cover
50. Top of Steering Column53. Behind Dashboard Lower Cover
51. Behind Left Kick Panel ('98-'99 Models)54. Above Left Kick Panel
201-8

I55. Above Left Kick Panel58. Behind Dashboard Lower Cover
56. Above Left Kick Panel59. Behind Dashboard Lower Cover
57. Above Left Kick Panel60" Behind Dashboard Lower Cover
201-9

Component Location
61. Behind Dashboard Lower Cover
65, Behind Dashboard Lower Cover
rt-
64. Behind Dashboard Lower Cover
SRS MEMORYERASE SIGNAL(MEs)CONNECTORc808(2-YEL)
62, Rear of Under-dash Fuse/Relav Box
63. Behind Dashboard Lower Cover
201-10
66. Behind Dashboard Lower Cover
l,l -

Component Location
iD121. Below Left Side of Dash124. Below Left Side of Dash
122. Above Left Kick Panel (Optional)125. Center ot Hatch Spoiler (Optional)
123. Behind Dashboard Lower Cover (Optional)126. Right Side of Hatch (Optional)
\
201-20

Connector ldentification and Wire Harness Routing (conrd)
Connector
ot
Terminal
Number of
Cavities/
Color
LocationConnects toNotes
Main Wire Harness (Left branch)
c30t
c302
c302
c406
c41'l
c412
c413
c414
c415
c416
c417
c418
c419
c420
c422
c425
c426
c427
c428
c429
c430
c430
c430
c431
c431
c432
c433
c434
c435
c436
c437
c438
c439
c440
c441
c442
Q444
c445
c446
c447
c448
c449
c450
2O-GBY
12.BRN
18-BRN
16-GRY
2-GRY
2-BLU
14-GRY
8-GRY
4-CAVITY
S.CAVITY
14.GRY
2O-WHT
22-GRY
26.GRY
16.GRY
14-GRY
2.GRY
14.GRY
3-YEL
2-YEL
2-WHT
2.GRY
8-GRY
1O-GRY
2-WHT
4-BLU
7-BRN
2-GRY
4-NAT
6-NAT
7-NAT
8-NAT
18-GRN
2O-GRN
18-GRN
7-GRN
6-GRN
6-WHT
4-BRN
7-BRN
4.GRN
4.BBN
15-GHY
3-GRY
Under left side of dash
Under lett side ol dash
Under left side of dash
Right side ol center console
Center console
Center console
Center console
Under left side of dash
Behind left kick panel
Behind lett kick panel
Behind left kick panel
Behind left kick panel
Behind lett kick panel
Behind lett kick panel
Behind left kick panel
Behind lelt kick panel
Under left side of dash
Under left side ot dash
Under lett side of dash
Under lett side of dash
Under left side of dash
Under left side of dash
Under left side of dash
Under lett side of dash
Under left side of dash
Under left side of dash
Under lett side of dash
Right side of steering column
Lett side of steering column
Right side of steering column
Left side of steering column
Right side of steering column
Behind dashboard lower cover
Behind dashboard lower cover
Behind dashboard lower cover
Behind dashboard lower cover
Behind dashboard lower cover
Under left side of dash
Under left side of dash
Under left side of dash
Under left side of dash
Under left side of dash
Behind under-dash fuse/relay box
Under lett side of dash
Engine compartment wire harness
Engine compartment wire harness
Engine comparlmenl wire harness
Data link connector (DLC)
A/T gear position console light
Shitt lock solenoid
A/T gear position switch
Interlock control unit
Daytime running lights control unit
Daytime runnang lights control unit
Cruise control unit
Junction connector
Transmission control module (TCM)
Transmission control module CrCM)
Rear wire harness
Rear wir€ harn€ss
Roof wire harness
Security system (Option)
SRS main harness
Clutch interlock switch
Clutch switch (Cruise control)
Dashboard wire harness
Dashboard wire harness
Dashboard wire harness
Brake switch (Without cruise control)
Brake switch (With cruise control)
Steering lock
Security system (Option)
Combination light switch
Combination wiper switch
Combination light switch
Combinalion wiper switch
Under-dash fuse/relay box
Under-dash fuse/rglay box
Under-dash fuse/relay box
Under-dash fuse/relay box
Under-dash fuse/relay box
Security system (Option)
Security system (Option)
PGM-Fl main relay
Starter cut relay
Rear window detogger relay
Integrated control unit
Security system (Option)
RS
All exceptRS
AtT
Atf
AN
A/T
Canada
Canada
A,/T ('98-'99
models)
A,/T (,98-'99
models)
All exceptRS
M/T
Mtf
Mrf
A,/T ('98-'99models)
AN('00 model)
All exceptRS
All exceptRS
All exceptRS
MN
AII excsptRS
203-1

)rD
)Ic418
c424
c423
c425
c448
c445c447
Cil46c416c421
c422
c417c420 c419
c415
G401
c412
c441 C442 C451
c41t
c438
UNDER-DASHFUSE/RELAY BOX
I
Connector
or
Terminal
Number of
Cavities/
Color
LocationConnects toNotes
Main Wire Harness (Left branch) (cont'd)
c451
c452
c452
c453
c454
c455
c456
4.NAT
14-GRY
16-GRY
3-GRY
4.GRY
3-GRY
5-GRN
Behind dashboard lower cover
Behind dashboard lower cover
Behind dashboard lower cover
Center console
Under middle of dash
Under leit side of dash
Right side of steerang column
Horn relay
Dashboard wire harness
Dashboard wire harness
Park pin switch
Secondary H02S
Cable reel
lmmobilizer receiver unit
RS
All exceptRS
'00 model
G401Behind lett kick panelBody ground, via main wire harness
MAIN WIRE HARNESS
o -,i---nnrnr-n
(Continued lrompage 203-11)
c439 C440
203-13