cooling Acura MDX 2003 Owner's Manua

When the coolant stops draining,
tightenthedrainplugatthe
bottom of the radiator.
Tighten the drain bolt at the rear
of the engine cylinder block
securely.
Tightening torque:
Remove the reserve tank f rom its
holder by pulling it straight up.
Drain the coolant, then put the
tank back in its holder.
Install a rubber hose on the drain
bolt in the back of the engine
block. Loosen the drain bolt. 6.
4. 5. 7.
Cooling Syst em
Maint enance314
DRAIN BOLT
RESERVE TANK
RESERVE
TANK CAP
HOLDER
7 lbf·ft (10 N·m , 1.0 kgf·m)

Fill the reserve tank to the MAX
mark. Install the reserve tank cap.
Install the radiator cap, and
tighten it to the first stop.
Start the engine and let it run until
the radiator cooling f an comes on
at least twice. Then stop the
engine.
Remove the radiator cap. Fill the
radiator with coolant up to the
base of the f iller neck.
Install the radiator cap, and
tighten it fully.
Pour Honda All Season
Antif reeze/Coolant Type 2 into
the radiator up to the base of the
f iller neck. This coolant is a
mixture of 50 percent antif reeze
and 50 percent water. Pre-mixing
is not required.
The cooling system capacity is: 10.
11.
12.
13. 9.
8.
Cooling Syst em
Maint enance315
FILLER NECK
Fill up to here
1.88 US gal (7.1)

Run the air conditioning at least once
a week during the cold weather
months. Run it f or at least ten
minutes while you are driving at a
steady speed with the engine at
normal operating temperature. This
circulates the lubricating oil con-
tained in the ref rigerant.If the air conditioning does not get as
cold as before, have your dealer
check the system. Recharge the
system with Ref rigerant HFC-134a
(R-134a). (See Specif ications on page
.)
Your vehicle’s air conditioning is a
sealed system. Any major mainte-
nance, such as recharging, should be
done by a qualif ied mechanic. You
can do a couple of things to make
sure the air conditioning works
ef f iciently.
Periodically check the engine’s
radiator and air conditioning
condenser f or leaves, insects, and
dirt stuck to the f ront surf ace. These
block the air f low and reduce cooling
ef f iciency. Use a light spray f rom a
hose or a sof t brush to remove them. 390
A ir Condit ioning Syst em
Maint enance330
AIR CONDITIONING
CONDENSER
Whenever you have the air conditioning
system serviced, make sure the service
f acility uses a ref rigerant recycling
system. This system captures the
ref rigerant f or reuse. Releasing
ref rigerant into the atmosphere can
damage the environment.
The condenser and radiator f ins bend
easily. Only use a low-pressure spray
or sof t-bristle brush to clean them.

This f ilter should be replaced every
30,000 miles (48,000 km) under nor-
mal conditions. It should be replaced
every 15,000 miles (24,000 km) if you
drive primarily in urban areas that
have high concentrations of soot in
the air f rom industry and diesel-pow-
ered vehicles. Replace it more of ten
if air f low f rom the climate control
system becomes less than usual.
Have dust and pollen f ilter replaced
by your Acura dealer. The dust and pollen f ilter removes
pollen and dust that is brought in
f rom the outside through the heating
and cooling system/climate control
system.Check the condition of the drive belt.
Examine the edges of the belt f or
cracks or fraying.
An auto-tensioner adjusts the tension
of the drive belt. The pointer on the
auto-tensioner should be in the
proper range. It should be checked
accordingtothetimeanddistance
recommendations in the
maintenance schedule.
If the pointer is out of this range or
you see signs of wear, have the drive
belt replaced by your Acura dealer as
soon as possible.
Maint enance
Dust and Pollen Filter Drive Belt
Dust and Pollen Filter, Drive Belt
331
Proper range
POINTER

If you see steam and/or spray
coming f rom under the hood, turn
of f the engine.
If you do not see steam or spray,
leave the engine running and
watch the temperature gauge. If
the high heat is due to overloading
(climbing a long, steep hill on a
hot day with the A/C running, for
example), the engine should start
to cool down almost immediately.
If it does, wait until the tempera-
ture gauge comes down to the mid-
point then continue driving. Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park and set the parking brake.
Turn of f the heating and cooling/
climate control system and all
otheraccessories.Turnonthe
hazard warning indicators.
Keep the ends of the jumper cables
away from each other and any metal
on the vehicle until all are
disconnected. Otherwise, you may
cause an electrical short.
The pointer of your vehicle’s
temperature gauge should stay in
the midrange under most conditions.
Itmaygohigherif youaredrivingup
a long steep hill on a very hot day. If
it climbs to the red mark, you should
determine the reason. Your vehicle can overheat for several
reasons, such as lack of coolant or a
mechanical problem. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
In either case, you should take
immediate action.
1.
2. 3.
CONT INUED
T aking Care of t he Unexpect ed
Jump Starting, If Your Engine Overheats
If Your Engine Overheats
371
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to your engine.

If the temperature gauge stays at
the red mark, turn of f the engine.
Wait until you see no more signs
of steam or spray, then open the
hood.
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks.
If there was no coolant in the
reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the pointer reaches the middle of the tempera-
ture gauge, or lower, bef ore check-
ing the radiator.
Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see
on page ). Start the engine and set the
temperature control dial to
maximum (climate control to
FULL AUTO at 90°F/32°C). Add
coolant to the radiator up to the
base of the f iller neck. If you do
not have the proper coolant
mixture available, you can add
plain water. Remember to have
the cooling system drained and
ref illed with the proper mixture as
soon as you can.
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly. Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .)
4.
5.
6.
7.
8. 9.10.
11.
12.
385
241 385
T aking Care of t he Unexpect ed
If Your Engine Overheats
Emergency
Towing
Emergency
Towing
372
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

µ
No.Circuits Protected No. Amps. Circuits Protected
Amps.
CONT INUED
No.
No. Amps. Amps.
Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 Spare Fuse
Spare Fuse
Right Headlight
ACG S
Hazard
Not used
Stop
Lef t Headlight
Radio
Power Window Motor
Rear A/C
Rear Defroster
Back Up, ACC 14
15
16
17
18
19
20
21
22
23
24
40 A
40 A
30 A
7.5 A 10 A
15 A
120 A 30 A
7.5 A 50 A
20 A Power Seat
Heater Motor
Cooling Fan
Spare Fuse
Spare Fuse
Spare Fuse
Battery
Condenser Fan
MG Clutch
IGI Main
Fog Lights
20 A
30 A
20 A
15 A
15 A
20 A
20 A
20 A
40 A
30 A
30 A
40 A
6
7
8
9
10
1
2
3
4
5 20 A
40 A
30 A
20 A
20 A 15 A
15 A
15 A
7.5 A 20 A
Rear Entertainment System
VSA F/S Relay
VSA Motor
4WD
Rear Accessory Socket ET C
IG Coil
LAF
FI-Back-up
P/W DR
Fuses
T aking Care of t he Unexpect ed383
PRIMARY UNDER-HOOD FUSE BOX
SECONDARY UNDER-HOOD FUSE BOX

ÎÎ
Î
Î
No.
Amps.
No. Amps.
Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
15 A
10 A
7.5 A
7.5 A 10 A
15 A
7.5 A
7.5 A 10 A
7.5 A 15 A
30 A
7.5 A
1
2
3
4
5
6
7
8
9
10
11
12
13
On Canadian models 30 A
20 A
20 A
20 A
20 A
10 A
20 A
20 A
15 A
15 A
10 A
20 A
7.5 A 20 A20 A
20 A
Fuel Pump
SRS
Heater Control, A/C Clutch
Relay, Cooling Fan Relay
Power Mirror
Daytime Running Light /
Rear Wiper
ECU(PCM),CruiseControl
OPDS
ACC Relay
Back-up Lights, Instrument
Lights
Turn Signals
IG Coil
Front Wiper
Starter Signal
Moonroof
Driver’s Power Seat Sliding
Passenger’s Power Seat
Reclining
Daytime Running Light
Driver’s side Rear Power
Window
Front Passenger’s Power
Window
Front Accessory Socket
Small Light
Interior Light
Power Door Lock
Back Up, Clock
Heated Seat
Driver’s Power Window
Passenger’s Side Rear
Power Window
Canadian models
:
Driver’s Power Seat Reclining
Passenger’s Power Seat Sliding
Fuses
T aking Care of t he Unexpect ed384
Driver’s Side INTERIOR FUSE BOX
Passenger’s Side
Front Front
:

.............
Halogen Headlight Bulbs . 341
..............
Hazard Warning Flashers . 87
........................................
Headlights .79
........................................
Aiming .341
....................
Automatic Lighting .80
..............
Automatic Lighting Off . 81
............
Daytime Running Lights . 82
..................
High Beam Indicator . 71
...........
High Beams, Turning on . 79
............
Low Beams, Turning on . 79
.........................
Reminder Chime .79
........
Replacing Halogen Bulbs . 341
...................................
Turning on .79
............................
Head Restraints .105
...............................
Heated Mirror .117
.....................
Heating and Cooling .134
.............
High Altitude, Starting at . 252
.................
High-Low Beam Switch . 79
HomeLink Universal ................................
Transceiver .229
....................................
Hood Latch .323
.......................
Hood, Opening the .238
..................................................
Horn .78
.................................
Hydroplaning .270
.............
Flashers, Hazard Warning . 87
...................
Flat Tire, Changing a . 361
Fluids ..........
Automatic Transmission . 317
..........................................
Brake .319
..........................
Power Steering .320
...................
Transf er Assembly . 318
..................
Windshield Washer . 316
FM Stereo Radio ...................................
Reception .169
........................................
Fog Lights .88
..............
Folding the Second Seat . 106
.................
Folding the Third Seat . 107
.....
Foreign Countries, Driving in . 396
..........................
Four-way Flashers .87
.................................................
Fuel .236
......................
Fill Door and Cap .237
...........................................
Gauge .75
................
Octane Requirement . 236
...............................
Oxygenated .395
........................
Reserve Indicator .71
........................
Tank, Filling the .237
.....................
Fuses, Checking the .380 ...............
Gas Mileage, Improving . 242
..........................................
Gasohol .395
.........................................
Gasoline .236
...............
Fuel Reserve Indicator . 71
...........................................
Gauge .75
................
Octane Requirement . 236
........................
Tank, Filling the .237
................
Gas Station Procedures . 237
Gauges ...
Engine Coolant Temperature . 75
...............................................
Fuel .75
...............................
Speedometer .74
.................................
Tachometer .74
GAWR (Gross Axle Weight .......................................
Rating) .272
GCWR (Gross Combined Weight .......................................
Rating) .272
............
Gearshif t Lever Positions . 254
..............................
Glass Cleaning .356
......................................
Glove Box .100
GVWR (Gross Vehicle Weight .......................................
Rating) .272
Index
GH
IV