automatic transmission Acura TL 2010 Service Manual

If you do not see steam or spray,
leave the engine running and
watch the temperature gauge. If
the high heat is due to overloading,
the engine should start to cool
down almost immediately. If it
does, wait until the temperature
gauge comes down to the midpoint,
then continue driving.
The pointer of the vehicle’s
temperature gauge should stay in
the midrange. If it climbs to the red
mark, you should determine the
reason (hot day, driving up a steep
hill, etc.).
If the temperature gauge stays at
the red mark, turn off the engine.
Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (seeon page ).
Saf ely pull to the side of the road.
Put the transmission in neutral
(manual) or Park (automatic), and
set the parking brake. Turn of f all
accessories, and turn on the
hazard warning lights.
If you see steam and/or spray
coming f rom under the hood, turn
of f the engine. Wait until you see
no more signs of steam or spray,
then open the hood.
If the vehicle overheats, you should
take immediate action. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood. You will also see a ‘‘WATER TEMP
HOT’’ message on the multi-
inf ormation display (see page ).
1.
2.3.
4.
5.
570
76
CONT INUED
Emergency
Towing
If theEngineOverheats
T aking Care of t he Unexpect ed
557
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to the engine.
09/07/29 18:36:57 31TK4610_562
2010 TL

If the indicator comes on repeatedly,
even though it may go of f as you
continue driving, have the vehicle
checked by your dealer as soon as
possible.
If this indicator comes on
while driving, it means one
of the engine’s emissions control
systems may have a problem. Even
though you may f eel no dif f erence in
your vehicle’s perf ormance, it can
reduce your f uel economy and cause
increased emissions. Continued
operation may cause serious damage. Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.
If the battery in your vehicle has
been disconnected or gone dead,
thesecodesmaybeerased.Ittakes
several days of driving under various
conditions to set the codes again.
If your vehicle has an automatic
transmission, the malf unction
indicator lamp may also come on
with the ‘‘D’’ indicator.
If you have recently ref ueled your
vehicle, the indicator coming on
could be due to a loose or missing
f uel f ill cap. Tighten the cap until it
clicks at least once. Tightening the
cap will not turn the indicator of f
immediately; it can take several days
of normal driving.
You will also see a ‘‘CHECK
EMISSION SYSTEM’’ message on
the multi-information display.Readiness Code
Malf unction Indicator L amp
560
If you keep driving with the
malf unction indicator lamp on, you can
damage your vehicle’s emissions
controls and engine. Those repairs may
not be covered by your vehicle’s
warranties.
09/07/29 18:37:30 31TK4610_565
2010 TL

Î
Î
With the f ront wheels on the ground,
it is best to tow the vehicle no farther
than 50 miles (80 km), and keep the
speedbelow35mph(55km/h).
If your vehicle is equipped with a
f ront spoiler, remove it bef ore
towing so it is not damaged. Models equipped with the
keyless access system have an
engine start/stop button instead
of an ignition switch.
ACCESSORY Mode is the
equivalent of ACCESSORY (I).
For more inf ormation, see pages
and .
178 181
:
CONT INUED
Emergency Towing
T aking Care of t he Unexpect ed
571
Trying to lif t or tow your vehicle by the
bumpers will cause serious damage.
The bumpers are not designed to
support the vehicle’s weight. Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine (automatic transmission), your
vehicle must be transported with the
f ront wheels of f the ground.
The steering system can be damaged if
the steering wheel is locked. Leave the
ignition switch in the ACCESSORY (I)
position, and make sure the steering
wheel turns f reely bef ore you begin
towing.
On models with the Keyless Access
system, the ENGINE START/STOP
BUTTON indicator will conf irm that
the power mode is in the ACCESSORY
mode and that the steering lock is
released. If the steering wheel does not
turn f reely, rotate the wheel right and
lef t while pressing the ENGINE
START/STOP BUTTON. This
inf ormation also appears on the multi-
inf ormation display (see page ).
183
09/07/29 18:39:21 31TK4610_576
2010 TL

The transmission number is on a
label on top of the transmission. The engine number is stamped into
the engine block.
Identif ication Numbers
Technical Inf ormation
577
AUTOMATIC TRANSMISSION
NUMBER
MANUAL TRANSMISSION
NUMBER
ENGINE NUMBER
09/07/29 18:39:58 31TK4610_582
2010 TL

µµÎ
Î
Î
Î
Specif ications
578
Air Conditioning Seating Capacities Weights Dimensions Capacities
195.5 in (4,966 mm) 18.5 US gal (70
)
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 0.182 US gal (0.69
)
Excluding the oil remaining in the engine 6.1 US qt (5.8
)
2.6 US qt (2.5)
0.48 US qt (0.45
)
0.45 US qt (0.43)
2.93 US qt (2.77
)
2.67 US qt (2.53)
ND-OIL8
17.6 19.4 oz (500 550 g) HFC-134a (R-134a)
Refrigerant type
Charge quantity
Lubricant type Total
Front
Rear 3 2
5
See the certification label attached
to the driver’s doorjamb.
Gross vehicle weight rating 63.8 in (1,620 mm) 63.2 in (1,605.5 mm)
109.3 in (2,775 mm)
57.2 in (1,452 mm)
74.0 in (1,880 mm)
Length
Width
Height
Wheelbase
Track 196.4 in (4,989 mm)
1.66 US gal (6.3
)
2.19 US gal (8.3)
4.5 US qt (4.3
)
4.2 US qt (4.0)
5.3 US qt (5.0)
3.5 US qt (3.3
)
3.0 US qt (2.8)
7.9 US qt (7.5
)
8.1 US qt (7.7)
2.2 US qt (2.1)
2.6 US qt (2.5)
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Manual
transmission
fluid
Rear
differential
fluid (SH-AWD)
Transfer
assembly
fluid (SH-AWD)
Windshield
washer
reservoir Approx.
Front
Rear
Change
Total
Change
Total Change
Total
ChangeIncluding filter
Without filter
Total
Change
Total
U.S. Vehicle
Canada Vehicle 2WD
SH-AWD
2WD
SH-AWD
1:
2: Change
Total
U.S. Vehicle
Canada Vehicle
1
2
09/07/29 18:40:19 31TK4610_583
2010 TL

The exhaust emissions controls
include f our systems: PGM-FI,
ignition timing control, exhaust gas
recirculation, and three way catalytic
converter. These f our systems work
together to control the engine’s
combustion and minimize the
amount of HC, CO, and NOx that
come out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.The emissions control systems are
designed and certif ied to work
together in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Acura replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It then controls how much f uel to inject
under all operating conditions.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor. The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned. This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
2
2
Exhaust Emissions Controls Replacement Parts
PGM-FI System
Three Way Catalytic Converter
Exhaust Gas Recirculat ion (EGR)
Syst em
Ignit ion T iming Cont rol Syst em
Emissions Cont rols
588
09/07/29 18:42:14 31TK4610_593
2010 TL

CONT INUED
................................
AAC .262, 302,349
....................................
Accessories .453
ACCESSORY (Ignition Key .....................................
Position) .145
ACCESSORY Mode ...........................
(Power Mode) .178
............
Accessory Power Sockets . 207
................
Active Head Restraints . 159
....................................
AcuraLink
. 425
....................
Additives, Engine Oil . 510
...........................
Advanced Airbags .28
...............................
Airbag (SRS) .9, 24
..........
Airbag System Components . 24
......
Air Conditioning System . 216,217
.........................................
Usage .218
...............
Air Pressure, Tires . 535,536
......................................
Antif reeze .512
Anti-lock Brakes (ABS) ...............................
Indicator .66, 482
...................................
Operation .482
..............
Anti-thef t, Audio System . 372
Anti-thef t Steering Column ....................................
Lock .145, 183
................................
Audio System .225 .
Automatic Lighting Off Feature . 135
...
Automatic Seat Belt Tensioners . 22
.............
Automatic Speed Control . 382
..............
Automatic Transmission . 468
..........................
Capacity, Fluid .578
...............
Checking Fluid Level . 515
..........................
Paddle Shif ters .473
.......................................
Shif ting .469
Shif t Lever Position ...............................
Indicators .468
....................
Shif t Lock Release . 471
......................
Auxiliary Input Jack .371
Battery Charging System ...........................
Indicator .65, 559
............................
Jump Starting .555
..............................
Maintenance .543
............................
Specif ications .579
..............................
Bef ore Driving .443
....................................
Belts,Seat .8,20
.........................
Beverage Holders .206
...................
Audio . 269,359
...............
HandsFreeLink. 388, 406
..................................
Booster Seats .54
Brakes ...........
Anti-lock System (ABS) . 482
.............
Break-in, New Linings . 444
...........................................
Fluid .519
.......................................
Parking .204
.................
System Indicator . 65,561
........................
Wear Indicators .481
.............................
Braking System .481
.................
Break-in, New Vehicle . 444
Brightness Control, ...............................
Instruments .137
....................................
Built-In Key .195
Bulb Replacement ..........................
Back-up Lights .528
.........
Daytime Running Lights . 521
.................................
Fog Lights .526
.................................
Headlights .521
............................
Specif ications .579
............
Turn Signal Lights . 524,528
..............................
Bulbs, Halogen .526
Bluetooth Bluetooth
Index
A
B
INDEX
I
09/07/29 18:43:37 31TK4610_604
2010 TL

Î
Î
...............
DANGER, Explanation of . iii
...................................
Dashboard .3, 62
..............
Daytime Running Lights . 136
.................................
Dead Battery .555
.........
Def ects, Reporting Saf ety . 596
..............
Def ogger, Rear Window . 139
..............
Def rosting the Windows . 221
....................................
Dimensions .578
.............
Dimming the Headlights . 133
Dipstick ..........
Automatic Transmission . 515
..................................
Engine Oil .448
........................
Directional Signals .133
........
Disc Brake Wear Indicators . 481
.................................
Disc Changer .241
...
Disc Changer Error Messages . 251
.....................
Disposal of Used Oil .512
............................
Capacities Chart .578
.............
Carbon Monoxide Hazard . 57
............................
Carrying, Cargo .455
.............
CAUTION, Explanation of . iii
.........................................
CD Care .364
...................................
CD Changer .241
.......................................
CD Player .295
........................
Certif ication Label .576
............................................
Chains .541
....................
Changing a Flat Tire .547
Changing Oil ........................................
How to .510
......................................
When to .497
...
Charging System Indicator . 65,559
............
Checklist, Bef ore Driving . 460
.....................................
Child Saf ety .37
..............................
Booster Seats .54
...................................
Child Seats .45
..........................................
Inf ants .42
............................
Large Children .53
.........................................
LATCH .47
......................
Risks with Airbags .38
.............................
Small Children .43
.........................................
Tethers .51 .....................
Warning Labels .39, 59
.........
Where Should a Child Sit? . 38
.......................................
Child Seats .45
.........................................
LATCH .47
..........
Tether Anchorage Points . 51
................
Childproof Door Locks . 147
................
Cleaning the Seat Belts . 530
..........
Client Service Inf ormation . 594
.......
Climate Control System . 216,217
..........................
On/Off Button .219
..............................................
Clock .373
...................................
Clutch Fluid .520
..................
CO in the Exhaust . 57,588
....
Cold Weather, Starting in . 461,463
......................
Compact Spare Tire .546
.........................................
Compass .378
.................
Console Compartment . 208
...............
Consumer Inf ormation . 594
.............
Controls, Instruments and . 61
Coolant ........................................
Adding .512
....................................
Checking .449
.........................
Proper Solution .512
...................
Temperature Gauge . 76
........
Water Temp Hot Message . 76Crankcase Emissions Control
........................................
System .587
................
Cruise Control Indicator . 72
............
Cruise Control Operation . 382
...................................
Cup Holders .206
.............
Customer Service Of f ice . 594
Index
D
C
II
09/07/29 18:43:43 31TK4610_605
2010 TL

...............................
Halogen Bulbs .526
......
HandsFreeLink
(HFL) . 388,406
............
Hazard Warning Flashers . 139
Hard Disc Drive (HDD), ........................................
Playing .308
.....................................
Headlights .133
........................................
Aiming .521
............
Automatic Lighting Off . 135
............
Automatic Lighting On . 134
.........
Daytime Running Lights . 136
..................
High Beam Indicator . 71
.......................
Reminder Beeps .133
........................
Replacing Bulbs .521
.................................
Turning on .133
............................
Head Restraints .156
.............................
Heated Mirrors .163
...................................
Heater, Seat .196
...............
High-Low Beam Switch . 133
.............................
Hill Start Assist .486
HomeLink
Universal ................................
Transceiver .385
........
Hood, Opening and Closing . 447
...........................................
Horn .4,130
...........................
Hydraulic Clutch .520
...............
Gas Mileage, Improving . 450
.........................................
Gasoline .444
...........................................
Gauge .75
.....................
Low Fuel Indicator .73
................
Octane Requirement . 444
........................
Tank, Ref ueling .445
................
Gas Station Procedures . 445
Gauges ...
Engine Coolant Temperature . 76
...............................................
Fuel .75
Gearshif t Lever Positions ..........
Automatic Transmission . 468
..............
Manual Transmission . 465
......................................
Glove Box .208
Gross Vehicle Weight Rating .....................................
(GVWR) .457
.........................................
Features .215
....................
Filling the Fuel Tank . 445
Filters .........................
Dust and Pollen .532
...............................................
Oil .510
...........
Flashers, Hazard Warning . 139
...................
Flat Tire, Changing a . 547
.....................................
Floor Mats .531
Fluids ..........
Automatic Transmission . 515
..........................................
Brake .519
.........................................
Clutch .520
..............
Manual Transmission . 517
................
Windshield Washers . 514
FM Stereo Radio ...................................
Reception .368
.....................................
Fog Lights .137
........................
Four-way Flashers .139
..............................
Front Airbags .9 ,26
....................................
Front Seats .155
....................................
Adjusting .155
.....................................
Airbags .9, 26
.......................................
Heaters .196
.................................................
Fuel .444
......................
Fill Door and Cap .445
...........................................
Gauge .75 .....................
Low Fuel Indicator .73
................
Octane Requirement . 444
...............................
Oxygenated .445
........................
Tank, Filling the .445
...............................
Fuel Economy .450
.....................
Fuses, Checking the .563
Index
H
G
IV
09/07/29 18:43:56 31TK4610_607
2010 TL

Î
CONT INUED
...................
Stereo Sound System . 225
....................
Storing Your Vehicle .544
......................................
Sun Visors .209
........................
Sunglasses Holder .210
Super Handling All-Wheel ...
Drive (TM) (SH-AWD
) . 73,478
....
Supplemental Restraint System . 24
......................................
Servicing .35
...............................
SRS Indicator .32
...................
System Components . 24
..................................
Synthetic Oil .510
.....................................
Tachometer .75
.
Taking Care of the Unexpected . 545
Technical Descriptions ....
DOT Tire Quality Grading . 581
.....
Emissions Control Systems . 587
Three Way Catalytic .......................
Converter .588, 589
.......................
Temperature Gauge .76
....................
Temperature, Outside . 84
........
Temperature, Inside Sensor . 224
..............
Tether Anchorage Points . 51
................
Thef t Protection, Radio . 372 ..
Three Way Catalytic Converter . 589
.........
Tighten Fuel Cap Message . 446
................
Tilt the Steering Wheel . 140
..........................
Time, Setting the .373
....................................
Tire Chains .541
.........
Tire, How to Change a Flat . 547
...........................
Tire Inf ormation .581
.................................
Tire Labeling .583
Tire Pressure Monitoring ....................
System (TPMS) .488
Low Tire Pressure/TPMS ...........................
Indicator .69, 488
......................
Pressure Monitor .489
Required Federal ............................
Explanation .585
..............
TPMS System Failure . 491
...............................................
Tires .534
......................
Air Pressure .535, 536
........................................
Chains .541
.........................
Checking Wear .537
..........................
Compact Spare .546
......
DOT Tire Quality Grading . 581
.
Glossary of Tire Terminology . 584
......................................
Inf lation .535
..................................
Inspection .537
...................................
Replacing .539 ......................................
Rotating .539
................................
Service Lif e .538
...........................................
Snow .541
....................
Specif ications .540, 580
.............................
Summer Tire .540
.......................
Traction Devices .541
..........................
Winter Driving .540
...................
Tools, Tire Changing . 548
Torque Distribution Monitor ...............................
(SH-AWD
) .478
Towing .....................................
A Trailer .493
................
Emergency Wrecker . 570
...........................................
Hook .572
...........................
Traction Devices .541
Transmission Checking Fluid Level, ..............................
Automatic .515
Checking Fluid Level, ...................................
Manual .517
..................
Fluid Selection . 516,517
..............
Identif ication Number . 577
.............
Shif ting the Automatic . 469
..................
Shif ting the Manual . 465
Index
INDEX
T
IX
09/07/29 18:44:28 31TK4610_612
2010 TL