service Alfa Romeo 156 2006 Owner handbook (in English)

GETTING TO KNOW YOUR CAR
101
Warning light Message
on display
INERTIAL FUEL CUT-OFF SWITCHThe message + symbol are shown on the display when the fuel cut-off switch comes into operation.ENGINE OIL SENSOR FAILURE (JTD versions)The message + symbol are shown on the display when there is a failure in the engine oil level
sensor. Contact Alfa Romeo Authorized Services as soon as possible to have the fault eliminated.
If, after the message has been displayed, you can smell fuel or notice
leaks from the supply system, do not re-engage the switch to avoid
the risk of fire.
WARNING

GETTING TO KNOW YOUR CAR
102
Warning light Message
on display>
INEFFICIENT ABS SYSTEMWhen the ignition key is turned to MAR, the warning light comes on but must go out after a
few seconds.
This warning light comes on (together with the message + symbol, where required, on the display)
when the system is inefficient. In this case, normal braking is ensured, though without making use
of the ABS system. Caution is recommended, especially in cases of less than perfect grip. In any
case, contact Alfa Romeo Authorized Services as soon as possible.Inefficient EBD electronic braking distributor
x>+
The vehicle is equipped with an electronic braking distributor (EBD). Si-
multaneous lighting of dial warning lights
>
and
x
(together with the
message + symbol on the display) with the engine running indicates an EBD
system failure; in this case, any sudden braking action can cause early locking
of rear wheels, with possible sideslip. Drive very carefully and go immediately
to the nearest Alfa Romeo Authorized Service to have the system checked.
WARNING

GETTING TO KNOW YOUR CAR
103
Warning light Message
on displayá
VDC SYSTEM (VEHICLE DYNAMICS CONTROL)
(optional for versions/markets where applicable)When the ignition key is turned to MAR, the dial warning light comes on but must go out after
a few seconds.
If the warning light does not go out, or if it stays on (together with the message + symbol on the
display and the coming on of the ASR button led) when the vehicle is running, contact Alfa Romeo
Authorized Services.
The flashing of the warning lamp when the vehicle is running indicates the actuation of the VDC
system.
W
OUTSIDE LIGHT FAILUREThe warning light comes on when an anomaly is found in one of the following lights:
– sidelights
– braking lights or corresponding fuse
– rear fog guards
– number plate lights.
The warning of a fault may mean one or more blown bulbs, a burnt fuse or cut off connection.

GETTING TO KNOW YOUR CAR
107
Warning light
on the dialMessage
on display
SELESPEED GEARBOX FAILURETurning the ignition key to MAR, the warning light on the cluster shall come on and then go off af-
ter about 4 seconds. If the warning light stays on, it indicates that a fault has been detected in the Se-
lespeed gearbox; at the same time, the buzzer beeps intermittently for 4 seconds to draw the atten-
tion of the driver. Contact Alfa Romeo Authorised Services as soon as possible to remove the fault.Q-SYSTEM AUTOMATIC GEARBOX FAILURETurning the ignition key to MAR, the warning light on the cluster shall come on and then go off
after about 4 seconds. If the warning light stays on or turns on when travelling, it indicates over-
heated gearbox oil (glowing steadily) or a gearbox fault (flashing).
Warning light glowing steadily: it indicates that the gearbox oil has reached the maxi-
mum established temperature.
To make oil cooling down, stop the car, move the lever to Por Nand let the engine idle until the
warning light goes out. Resume driving without demanding high performance from the engine. If
the warning light comes on again, it is necessary to stop again with the engine idling until it goes
out again. If the interval between one lighting up of the warning light and next is below 15 minutes,
you are advised to stop the car, turn the engine off and wait for the engine-gearbox unit to cool down
completely. Contact Alfa Romeo Authorised Services as soon as possible.
Warning light flashing: it indicates a fault in the automatic gearbox.
The automatic control system provides an emergency programme. Under these circumstances,
you are advised to stop the car and turn the engine off; in fact, the next time the engine is started,
the self-diagnostic system could cut off the fault which will however be memorised. Conversely, if
the fault remains (warning light flashing), it is necessary to select the gears manually as if driving
a car with mechanical gearbox, bearing in mind that the only two speeds available are the 2
ndand
4
thgear. Contact Alfa Romeo Authorised Services as soon as possible.
t
t

GETTING TO KNOW YOUR CAR
114
Cooling adjustment
Proceed as follows:
– turn off inside air re-circulation (if on);
– turn knob (1) counterclockwise to re-
duce temperature;
– turn knob (4) counterclockwise to re-
duce the fan speed.
LOOKING AFTER THE SYSTEMDuring the winter the climate control sys-
tem must be turned on at least once a
month for about minutes.
Before summer, have the system checked
at Alfa Romeo Authorized Service.
AUTOMATIC
TWO-ZONE CLIMATE
CONTROL SYSTEMTo start the system (fig. 100):
– turn the knob rings to set the required
temperatures (driver’s side – passenger’s
side).
– press the
AUTO
button.
WARNINGThe climate control system
makes it possible to adjust the temperatures
required for the two sides with a maximum
difference of 7°C between the driver’s and
the passenger’s sides.
WARNINGThe climate control com-
pressor works only when the engine is run-
ning and the outside temperature is more
than 2°C.

GETTING TO KNOW YOUR CAR
134
This function is timed and switches off au-
tomatically after 20 minutes, or pressing the
button again; the function is also switched
off when the engine is stopped and will not
be switched on again the next time the en-
gine is started.
WARNINGThe system turns on
rearscreen heating automatically if the tem-
perature is below 3°C.
WARNINGDo not apply stickers on the
inside of the rearscreen over the heating fil-
aments to avoid damage that might cause
it to stop working properly.
WARNINGWhen reconnecting the neg-
ative battery cable after having disconnected
it, wait for 2 minutes before turning the key
to enable the climate control system to re-
set actuator strokes properly.
POLLEN FILTER This filter has the specific capability of com-
bining the mechanical filtering of the air with
an electrostatic effect so that the outside air
admitted to the passenger compartment is
purified and free from particles such as dust,
pollen, etc.
In addition to the above, it also effectively
reduces the concentration of pollutants.
The filtering action takes place under all
air inlet conditions and it is clearly most ef-
fective with the windows shut.
Have the conditions of the filter checked by
Alfa Romeo Authorized Services at least once
a year, preferably on the onset of summer.If the vehicle is used mainly in polluted
or dusty areas it should be checked and if
necessary replaced, at shorter intervals.
Failure to replace the fil-
ter may considerably re-
duce the effectiveness of
the climate control system up to
blocking the air flow from the out-
lets and vents.

GETTING TO KNOW YOUR CAR
139
To release the hand brake:
– slightly lift the lever (A) and press the
release button (B);
– holding the button down lower the lever.
The
x
warning light on the instrument
panel will go out.
To prevent the car from moving acciden-
tally, keep the brake pedal pressed when
engaging the handbrake.WARNINGThe handbrake lever (A) is
fitted with a safety device which prevents
the brake from being released when, if the
lever is pulled, button (B) is pressed. There-
fore, to release the brake, in addition to
pressing button (B), it is also necessary to
pull lever (A) further upwards to release the
safety device, then lower the lever com-
pletely
GEARSHIFT LEVER
(fig. 123)
Depending on the versions the car is fitted
with a five or six speed mechanical gearbox
(see “Technical specifications” chapter).
The position of the individual gears is
shown by the pictogram on the gearshift
lever knob.
When changing gear, always fully depress
the clutch pedal. Before engaging reverse
gear (R) wait for the car to be stationary.
fig. 123
A0B0290m
The wheels should be
locked after a few clicks of
the hand brake. If this does not oc-
cur, contact Alfa Romeo Authorized
Services to have the hand brake
adjusted.
WARNING

GETTING TO KNOW YOUR CAR
150
AUTOMATIC OPERATION (CITY)The CITYautomatic operating mode is se-
lected pressing the button (A-fig. 132),
at the base of the gearshift lever.
In addition to the gear, the display on the
rev counter will show the word CITY.
The system decides directly when gearshift-
ing according to the engine running speed
and the driving style.
Quickly releasing the accelerator pedal, the
system does not engage a higher gear in or-
der to maintain an adequate level of engine
brake.
FAILURE SIGNALLINGFailures to the Selespeed gearbox are in-
dicated by the
t
(A-fig. 133) warn-
ing light on the instrument cluster.
When the system is turned on (turning the
ignition key to MAR), the warning light
should turn on glowing steadily for about
4 seconds and then turn off.
If the warning light stays on it means that
a fault to the gearbox has been detected; at
the same time a buzzer sounds intermit-
tently for 4 seconds to attract the driver's
attention.In the case of a fault to the gearshift lever,
the system automatically activates the au-
tomatic CITYmode to allow the car to
reach the nearest Authorized Alfa Romeo
Services to have the fault detected elimi-
nated.
In the event of faults to other components
of the gearbox, the system only allows the
engagement of certain ratios: first gear (1),
second (2) and reverse (R).
fig. 132
A0B0269m
fig. 133
A0B0383m
If the warning light
t
comes on, contact the Alfa
Romeo Authorized Services
as soon as possible to remove the
fault.In case of transmission
fault, contact the Alfa
Romeo Authorized Services as
soon as possible to check the sys-
tem.
WARNING

GETTING TO KNOW YOUR CAR
151
SIGNALLING WITH THE BUZZERThe buzzer is activated when:
– reverse gear (R) is engaged;
– the vehicle is parked with the gearbox
at neutral (N); this can be seen turning the
ignition key to STOP;
– clutch overheating takes place during
pick-up;
– the car moves in the opposite direction
to the gear engaged (e.g.: the car tends to
do downhill with reverse gear engaged);
– in the event of gearbox failure;
– the system has automatically engaged
neutral (N) after:•
there is no action on the accelerator
and/or brake pedal for at least 3 min-
utes;
•
the brake pedal is pressed for over 10
minutes;
•
the driver’s door is opened and the ac-
celerator and brake pedal are not
pressed for at least 1 second;
•
detection of a gearbox fault.
PARKING THE VEHICLETo park the car safely it is absolutely
necessaryto engage first gear (1) or re-
verse (R) and, when on a sloping road, also
engage the hand-brake.
Turning the engine off with the car facing
uphill and a gear engaged, it is absolutely
necessaryto wait for the display on the
rev counter to go off before releasing the
brake pedal, so that the clutch has innested
completely.
If the gearbox is in neutral (N) and you
want to engage a parking gear, it is neces-
sary to activate the system and engage the
gear (1) or reverse (R) with your foot on
the brake pedal.
TOWING THE VEHICLEWARNINGFor towing the vehicle, ad-
here to local regulations. Make sure that the
gearbox is in neutral (N) (checking that the
car moves when pushed) and proceed as for
towing a normal car with mechanical gear-
box following the instructions given in the
chapter “In an emergency”.
Should it be impossible to set to neutral,
do not tow the vehicle; contact Alfa Romeo
Authorised Services.
Do not start the engine
when towing the vehicle.
WARNING

GETTING TO KNOW YOUR CAR
159
If the indicator light re-
mains flashing, contact the
Alfa Romeo Authorized
Service Centers as soon as possi-
ble to remove the fault.
If a fault is indicated when the engine is
started, this means that the gearbox control
system had detected and memorised a fault
during the journey prior to switching the en-
gine off. In this case, too, contact Alfa
Romeo Authorized Services to have the au-
tomatic gearbox checked over.It is possible to engage reverse gear.
ACOUSTIC WARNINGThis comes into operation for about 18 sec-
onds when:
– the driver’s door is open and/or the en-
gine is off with the selector lever in a posi-
tion other than P;
– position R(reverse) is engaged.PUSH STARTINGStarting the car by pushing or towing is not
possible. In the event of an emergency,
when the battery is flat, start the car with
a suitable emergency battery, following the
instructions given in the chapter “In an emer-
gency”.
When driving with a faulty
gearbox, drive with the ut-
most care considering the restricted
performance levels (in terms of ac-
celeration and speed) the car can
offer.
WARNING
When travelling with a
faulty gearbox, the reverse
lock might not work: absolutely
never move the lever to position
R with the car on the move.
WARNING