engine coolant Alfa Romeo 156 2007 Owner handbook (in English)

CORRECT USE OF THE CAR
204
REMOVING FROM STORAGEBefore using your vehicle after a long pe-
riod of inactivity, the following operations
should first be carried out:
– Do not dust the outside of the vehicle.
– Visually check that there are no leaks
(oil, brake and clutch fluid, engine coolant,
etc.).
– Replace engine oil and filter.
– Check:
- brake-clutch fluid level
- level of engine coolant fluid.
– Check the air cleaner and replace if nec-
essary.
– Check tyre pressure and ensure that they
are not damaged, cracked or cut. If they are
they must be replaced.– Check the state of the drive belts.
– Reconnect the battery negative termi-
nal (–) after checking that the charge is ad-
equate.
– With the gear lever in neutral start the
engine and allow the engine to run for a few
seconds whilst repeatedly working the clutch
pedal.
USEFUL ACCESSORIESIn addition to the legal requirements, we
recommend keeping the following in the car
(fig. 1):
– first aid kit with non-alcoholic base dis-
infectant, steril gauzes, a roll of gauze, plas-
ters, etc.;
– torch;
– round-ended scissors;
– work gloves.fig. 1
A0B0389m
This operation must be per-
formed in the open. The
exhaust gases contain carbon
monoxide which is extremely toxic
and may also be lethal.
WARNING

CAR MAINTENANCE
250
20 40 60 80 100 120 140 160 180
Thousand of km
Change fuel filter (diesel versions only)Change air cleaner cartridge (petrol engines)Change air cleaner cartridge (diesel versions only)
Check and if necessary top up fluid levels (brakes, hydraulic clutch, power steering, windscreen wiper, battery, engine coolant, etc..) Check and if necessary top up Selespeed oil level (2.0 JTS version)Replacement of timing drive belt (*) and Poly-V accessory drive beltReplacement of counter-rotating shaft drive belt (only 2.0 JTS)Replacement of spark plugs (T.SPARK 16V, 2.0 JTS and 2.5 V6 24V versions) Check operation of engine control systems (through diagnosis)Check gearbox and differential oil levelCheck automatic gearbox oil level (2.5 V6 24V version)Change engine oil and oil filterChange brake fluid (or every 2 year)Replacement of dust/pollen filter
●●●●●●●●●
●●●●
●●●●●●●●●
●●●●●●●●●
●●●●●●●●●
●
●
●
●●●●
●●
●●●●●●●●●
●●●●●●●●●
●●●
●●●●●●●●●
(*) Or every 3 years in harsh conditions (cold – hot climates, stop and go city traffic, dusty areas or roads covered with sand and/or salt)
Or every 5 years, regardless of the mileage.

CAR MAINTENANCE
251
ADDITIONAL
OPERATIONSEvery 1000 kmor before long journeys
check and if necessary top up:
– engine coolant level
– brake fluid/hydraulic clutch control flu-
id level
– power steering fluid level
– windscreen washer and headlamp wash-
er fluid level
– tyre pressure and conditions.
Every 3000 kmcheck the level of the
engine oil and top up if necessary.
You are recommended to use products of
the FL Selenia, designed and developed
expressly for Alfa Romeo cars (see the table
“Specifications of fluids and lubricants” in
the “Technical specifications” chapter).
ANNUAL INSPECTION
PROGRAMMEAn annual inspection programme
has been established for cars thet
cover less than 20,000 km (e.g.
10,000 km). It consists of the fol-
lowing:
– Check tyre conditions/wear and adjust
pressure if required (including the compact
spare wheel)
– Check lighting system operation (head-
lights, direction indicators, hazard lights,
boot lights, passenger compartment lights,
glovebox light, warning lights of instrument
panel, etc.)
– Check windscreen and rear-screen
wiper/washer operation, adjust nozzles
– Check windscreen/rear-screen blade po-
sition/wear
– Check condition and wear of the front
brake pad
– Check for bonnet and boot lock clean-
ness, lever cleanness and lubrication– Visually check the following: engine,
gearbox, transmission, piping (exhaust - fu-
el - brakes) rubber components (casings -
sleeves - bushings, etc..), brake and fuel
hoses
– Check battery charge condition
– Visually check the condition of the belts
and various controls
– Check and top up if necessary, the flu-
id levels (coolant, brake fluid, windscreen
washer fluid, battery, etc.)
– Change engine oil
– Replace engine oil filter
– Change pollen filter.

CAR MAINTENANCE
254
fig. fig. fig. 2 - 2.0 JTS version
A0B00436m
fig. 1 - 1.6 T.SPARK, 1.8 T.SPARK versions
A0B00174m
CHECKING FLUID
LEVELS1Engine oil - 2Battery - 3Brake fluid -
4Windscreen washer fluid - 5Engine
coolant fluid - 6Power steering fluid When topping up take
care not to confuse the var-
ious types of fluids: they
are all incompatible with one an-
other and could seriously damage
the car.
Never smoke while work-
ing in the engine compart-
ment; gas and inflammable
vapours may be present, with the
risk of fire.
WARNING

CAR MAINTENANCE
255
fig. 3 - 2.5 V6 24V version
fig. 4 - JTD version
A0B00175mA0B00176m
1Engine oil - 2Battery - 3Brake fluid -
4Windscreen washer fluid - 5Engine
coolant fluid - 6Power steering fluid
1Engine oil - 2Battery - 3Brake fluid -
4Windscreen washer fluid - 5Engine
coolant fluid - 6Power steering fluid

CAR MAINTENANCE
256
A0B0558m
1Engine oil - 2Battery - 3Brake fluid -
4Windscreen washer fluid - 5Engine
coolant fluid - 6Power steering fluid
1Engine oil - 2Battery - 3Brake fluid -
4Windscreen washer fluid - 5Engine
coolant fluid - 6Power steering fluidfig. 5 - JTD 16V Multijet version
fig. 6 - JTD 20V Multijet version
To improve picture detail, the engine compartment is illustrated without the bonnet
A0B0616m

CAR MAINTENANCE
261
ENGINE COOLANT LEVEL
Top up only with the same
fluid contained in the cool-
ing circuit. PARAFLU UP
(red) cannot be mixed with
PARAFLU 11 (blue) or with other
fluids. Should this take place, do
not start the engine and contact Al-
fa Romeo Authorized Service.
The level of the coolant in the header tank
(reservoir) should be checked with the en-
gine cold and the car on a level surface and
it should be between the MINand MAX
marks on the tank. If the level is low, loosen
the header tank cap (A) and slowly pour
a mixture of the fluid specified in the ”Flu-
ids and lubricants ” table in section “Tech-
nical Specifications”, through the filler neck
until nearing the MAXmark; have this op-
eration carried out at Alfa Romeo Authorised
Services.
The antifreeze mixture contained in the
cooling circuit guarantees protection down
to –35°C.fig. 16 - 2.5 V6 24V version
A0B0160m
fig. 15 - T.SPARK, 2.0 JTS and JTD versions
A0B0161m
Fig. 15: T.SPARK, 2.0 JTS and diesel ver-
sions
Fig. 16: 2.5 V6 24V versionThe cooling system is
pressurised. If necessary,
replace the cap only with
another genuine one, otherwise
system efficiency could be compro-
mised.
Do not remove he cap
when the engine is hot:
danger of burns.
WARNING

ALPHABETICAL INDEX
327
Bulbs
– general instructions ............... 218
– replacement .......................... 217
– types of bulbs ................. 218-219Car lifting
– with arm hoist ....................... 245
– with jack .............................. 245
– with workshop hoist .............. 245
Car maintenance..................... 248
Carrying children safely ................ 35
Catalytic converter ....................... 188
Ceiling lights................................ 162
– centre rear roof lamp .............. 163
– courtesy light......................... 163
– front roof light ....................... 162
– rear roof light ........................ 163
Centre rear roof lamp.................... 163
– bulb replacement ................... 231
Changing battery of key
with remote control ................... 10
Changing bulbs
– general instructions ............... 218
– replacement .......................... 217
– types of bulbs ................. 218-219
Changing wheels.......................... 209
– general instructions ................ 207Charging the battery .............. 242-268
Checking levels ............................ 254
– brake and clutch fluid ............. 263
– engine coolant....................... 261
– engine oil ............................. 257
– power steering oil .................. 261
– Q-system automatic
gearbox oil............................ 260
– Selespeed gearbox oil ............ 259
– windscreen/rearscreen/
headlamp washing fluid .......... 264
Child safety device .............. 19-35-279
Children (carrying safely) ............. 35
– child’s seats .................... 35-38
– presetting for installing the
Isofix type child restraint system 39
Cigar lighter ............................... 164
Cleaning and maintenance
– car exterior ........................... 274
– car interior ............................ 277
– engine compartment ............. 276
– fabric seats .......................... 277
– leather seats ........................ 277
– plastic parts........................... 277
– windows ............................... 276
Climate control system.................. 108
– air vents................... 108-109-110– controls ................................ 118
Climate control system, automatic
two-zone ................................. 114
Clock .......................... 57-58-59-60-61
Clutch
– checking fluid level
and topping up ...................... 263
CO
2emissions ............................. 324
CODE card................................... 7
Compact spare wheel ................... 294
– technical data ........................ 312
Controls ...................................... 135
Correct use of the car............ 189
Courtesy light .............................. 163
– bulb replacement ................... 232
Cruise control
(constant speed adjustment) ...... 53
Current socket (boot) ................... 285
D
ashboard ................ 57-58-59-60-61
– brighting adjustment............... 63
Dashboard lighting dimming .......... 136
Demisting-defrosting
– door mirrors .................... 25-133
– rearscreen....................... 26-133
– windscreen and front
side windows ........................ 132

ALPHABETICAL INDEX
328
Diesel filter ................................. 265
Dimensions ........................... 315-316
Dipped beam headlights
– aiming for left-hand/
right-hand driving ................... 178
– changing bulbs ..................... 224
– switching on ......................... 48
Direction indicators
– changing front bulbs ............... 223
– changing rear bulbs ................ 228
– changing side bulbs ................ 227
– switching on ......................... 49
Door mirrors.......................... 25-26
Doors
– centralized locking ................. 19
– child safety lock............... 20-279
– opening/closing
from inside ..................... 19-278
– opening/closing
from outside ................... 18-278
– remote control ....................... 7
– remote locking/unlocking ...... 16
Economy and environment-friendly
driving ..................................... 197
Electronic alarm system................. 11
– automatic engagement ........... 14
– cutting out the siren .............. 15
– description ............................ 11
– interrupting the alarm ............. 14
– ministerial homologation ........ 16
– request for additional
emote controls....................... 12
– switching off ........................ 13
– switching on ......................... 12
– volumetric protection ............. 15
– when the alarm is triggered ..... 14
Electronic control units ................. 270
Emergency starting ................ 191-205
– starting by inertia .................. 207
– starting with an auxiliary
battery ................................. 242
Engine
– identification codes................. 301
– marking ............................... 299
– specifications ......................... 302
Engine compartment
– bonnet ................................. 172
– cleaning................................ 276Engine coolant
– checking level and topping up .. 261
– temperature gauge
and warning light ................... 62
Engine lock system
(Alfa Romeo CODE) ................... 6
Engine oil
– checking level and topping up .. 257
– consumption ......................... 258
Environment
– economy and environment-
friendly driving....................... 197
– emission reducing devices . 187-188
– protecting emission
reducing devices .................... 198
– reducing running costs
and environment pollution ....... 195
– use of non-toxic materials........ 187
EOBD system............................... 182
First-aid kit ................................ 247
Fix&Go (quick tyre repair kit) ........ 212
Flashing main beam headlights ..... 49
Fluids and lubricants .................... 320
Front foglights
– adjustment............................ 177
– changing bulbs ..................... 225
– switching on.......................... 136

RIGHT HAND DRIVE VERSION
342
DASHBOARD1.Side air outlets - 2.Defrosting/demisting vents for side windows - 3.Upper side vents - 4.Passanger’s Air bag - 5.Sound system -
6.Engine coolant temperature gauge - 7.Clock - 8.Centre air vents - 9.Infocenter display - 10.Fuel level gauge - 11.Cruise control
lever (where fitted) - 12.Outside lights control lever - 13.Speedometer. - mileage recorder - 14.Check panel - 15.Rev counter -
16.Windscreen wiper control lever - 17.Bonnet opening lever - 18.Radio controls on the steering wheel (where applicable) -19.Igni-
tion switch - 20.Steering wheel lock/release lever - 21.Driver’s Air bag and horns - 22.Controls unit: instrument panel lighting adjust-
ment and healamp diming - 23.Controls for heating, ventilation and climate control - 24.Ashtray and cigar lighter - 25.Hazard warning
lights switch - 26.Glove box.fig. 1
A0B0611m