boot Alfa Romeo 159 2005 Owner handbook (in English)

206
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
IN AN
EMERGENCY
FUSE LOCATION
Fuses are grouped into four fuse boxes
to be found respectively on the dash-
board, on the battery positive pole, near
the battery and inside the boot (right-
hand side).
Fuse box on the dashboard
To gain access to the fuses in the fuse
box on the dashboard, loosen the fas-
tening screw A-fig. 57and remove
the cover B.
A0E0157mfig. 57
A0E0124mfig. 58

209
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
IN AN
EMERGENCY
Fuse box in the boot
(left-hand side)
To gain access to the fuses, open the lid
on the left side of the boot as shown by
the arrow A-fig. 63.
A0E0129mfig. 63
A0E0224mfig. 64

210
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
IN AN
EMERGENCY
FUSE SUMMARY TABLE
LIGTHS FUSE AMPERE FIGURE
Right main beam headlight F14 10 62
Left main beam headlight F15 10 62
Right dipped beam headlight F12 15 58
Left dipped beam headlight F13 15 58
Front fog light F30 15 62
Reversing light F35 7.5 58
Third brake light F37 10 58
Front/rear ceiling light F39 10 58
Front ceiling light F49 7.5 58
Direction indicators F53 10 58
Hazard lights F53 10 58
USERS FUSE AMPERE FIGURE
Engine compartment control unit F70 (MEGA-FUSE) 150 60
Instrument panel control unit F71 70 60
Fuel pre-heating unit (diesel versions) F73 60 60
Boot control unit F01 (MAXI-FUSE) 70 62
Instrument panel control unit F01 (MAXI-FUSE) 70 62

212
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
IN AN
EMERGENCY
USERS FUSE AMPERE FIGURE
Water in diesel fuel filter sensor/flow meter F35 7.5 58
Brake light switch/central console control panel F35 7.5 58
Cruise Control F35 7.5 58
AQS sensor F35 7.5 58
Boot branch point/front door branch point power F36 20 58
Instrument panel branch point F37 10 58
Front headlight control unit/Power to control unit for gas-discharge
headights (Bixenon) (where provided) F37 10 58
Boot locking/unlocking gearmotor F38 15 58
EOBD system diagnostic socket F39 10 58
T.P.M.S. control unit F39 10 58
Mobile phone presetting F39 10 58
Alarm system control unit (where provided) F39 10 58
Climate control system F39 10 58
Heated rear window F40 30 58
Windscreen washer/rear window washer nozzle demister F41 7.5 58
Heated mirror demister F41 7.5 58
Brake branch point power (ABS/VDC) –
Steering angle branch point – Yawing sensor F42 7.5 58
Windscreen wiper/washer F43 30 58

221
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
CAR
MAINTENANCE
30 60 90 120 150 180
●●●●●●
●●●●●●
●●●●●●
●●●●●●
●●●●●●
●●●
●●●●●●
●●●●●●
●●●●●●
●●●
●●
SERVICE SCHEDULE
Thousands of km
Check tyre conditions/wear and
adjust pressure if required
Check light system operation (headlights,
direction indicators, hazard lights, boot lights, passenger
compartment lights, glovebox lights, warning lights, etc.)
Check windscreen wiper/washer operation,
adjust nozzles if required
Check windscreen/rear window blade
position/wear
Check front disk brake pad conditions and wear
and wear indicator operation
Check rear disk brake pad conditions and wear
Sight inspect the conditions of: body external parts,
underbody protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever cleanness
and lubrication
Check and top up, if required, fluid levels
(brakes/hydraulic clutch, power steering, windscreen washer,
battery, engine coolant, etc.)
Check and adjust handbrake lever stroke
Sight inspect accessory drive belt conditions

223
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
CAR
MAINTENANCE
❒sight inspect the conditions of: en-
gine, gearbox, transmission, pipes
and hoses (exhaust - fuel - brakes),
rubber parts (boots, sleeves, bushes,
etc.);
❒check battery charge;
❒visual check on various drive belt con-
ditions;
❒check and top up, if required, fluid
levels (engine coolant, brake fluid,
windscreen washer fluid, power steer-
ing fluid, battery fluid, etc);
❒ change engine oil and oil filter (petrol
versions);
❒change engine oil and oil filter, if re-
quired (diesel versions);
❒ replace pollen filter.
ADDITIONAL
CHECKS
Every 1,000 km or before long jour-
neys, check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒ tyre pressure and conditions.
Every 3,000 km check and top up if re-
quired: engine oil level.
You are recommended to use FL Se-
leniaproducts, designed and produced
specifically for Alfa Romeo cars (see
table “Capacities” in section “Techni-
cal specifications”).
ANNUAL INSPECTION
SCHEDULE
For cars with an annual mileage of be-
low 30,000 km (for example about
15,000 km) the following Annual In-
spection Schedule is advised:
❒check tyre conditions/wear and ad-
just pressure if required (including the
spare wheel);
❒check light system operation (head-
lights, direction indicators, hazard
lights, boot lights, passenger com-
partment lights, glovebox light, warn-
ing lights, etc.);
❒ check windscreen wiper/washer op-
eration;
❒check windscreen/rear window blade
position/wear;
❒check front disk brake pad conditions
and wear;
❒check cleanness of bonnet and boot
locks and lever cleanness and lubri-
cation;

257
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
TECHNICALSPECIFICATIONS
Versions A B C D E F G H
1.9 JTS - 2.2 JTS -
3.2 JTS - 1.9 JTD
M8v -4660 1000 2700 960 1422 1578 1828 1555
1.9 JTDM16v - 2.4 JTDM1417 (■) 1593 (■) 1573 (■)
DIMENSIONS
a
Dimensions are
expressed in mm and
refer to the car
fitted with standard tyres.
Min. size variations
when optional tyres are
fitted.
The height refers to
the car unladen.
BOOT VOLUME
Boot volume .............. 405 dm3
A0A0044mfig. 6
(■) With tyres 215/55 R16”

259
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
TECHNICALSPECIFICATIONS
2.2 JTS
1490
1200
1100
2010
520
1500
70
80
3.2 JTS
1740
1300
1100
2260
520
1800
70
80
1.9 JTDM8v
1525
1200
1100
2045
520
1500
70
80
1.9 JTDM16v
1535
1200
1100
2055
520
1500
70
80
2.4 JTDM
1630
1300
1100
2150
520
1500
70
80
1.9 JTS
1480
1200
1100
2000
520
1500
70
80
WEIGHTS
Weights (kg)
Kerb weight
Maximum admitted load (*)
– front axle
– rear axle
– total
Payload including
driver (**)
Towable loads
Max. load on ball
Maximum load on roof (***)
(*) Loads not to be exceeded. The driver is responsible for arranging the loads in the boot an/or on the roof so
that they comply with these limits.
(**) If special equipment is fitted (sunroof, tow hitch etc.) the unladen weight increases, thus reducing the payload as specified in
the maximum weight allowed.
(***) Lineaccessori Alfa Romeo roof rack, max capacity: 50 kg.

265
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
INDEX
265
– recharging .......................... 215
– replacing ............................ 235
– useful advice for
lengthening the life ............. 236
Bodywork (cleaning) ................ 241
Bonnet ................................... 101
Boot ....................................... 97
– light replacement ................ 204
Brakes .................................... 251
Bulb
(replacement) ....................... 192
– general instructions ............. 192
– types of bulbs ..................... 193
Capacities ............................... 260
Car inactivity ............................ 160
Car maintenance................. 219
– additional checks ................ 223
– annual Inspection Schedule .. 223
– service Schedule ................. 221
– scheduled service ................ 220
Carrying children safely ............. 131– child restraint systems ......... 134
– passenger’s seat compliance .. 134
– presetting for mounting
the “Universal Isofix” child
restraint system .................. 136
Ceiling lights
– front ................................. 78
– rear .................................. 80
Checking fluid levels ................. 226
Child lock device ...................... 93
Cigar lighter ............................. 85
Climate control system .............. 53
– automatic two-/three-zone .. 58
– manual .............................. 55
CO
2emissions ......................... 264
CODE card ............................... 11
Containing running costs ........... 153
Controls .................................. 81
Correct use of the car........ 147
Courtesy mirror light
– bulb replacement ................ 202
Cruise Control .......................... 76 ABS system ............................ 104
Accessories purchased
by the owner ......................... 113
Additional heater ...................... 69
Air/pollen filter ........................ 233
Air vents ................................. 54
Alarm ..................................... 17
Alfa Romeo CODE system .......... 9
Armrest
– central ............................... 82
– rear .............................. 83-84
Ashtray ................................... 86
ASR system ............................. 108
At the filling station .................. 121
Automatic headlight sensor ........ 71
Automatic two/three-zone
climate control system ............ 58
Battery
– checking the charge ............ 234
– jump starting ...................... 178
– maintenance ...................... 225
I I
N N
D D
E E
X X