brake fluid Alfa Romeo 166 2006 Owner handbook (in English)

210
JTD 20V Multijet version
fig. 2
k
1)engine oil
π
2)brake and
clutch fluid
+
3)windscreen
washer fluid
n
4)engine coolant
fluid
∂
5)power steering
fluid
A0D0112m

When the cap (B) is
screwed off the reser-
voir ensure that the
electrical connections are not dis-
connected. Make sure that the
highly corrosive brake fluid
does not drip onto the paint-
work. If it does, wash it off
immediately with water.
IMPORTANT Contact Alfa Romeo Au-
thorized Services for maintenance and re-
pair operations.Oil consumption is very
low; if topping up again
is needed shortly after-
wards, have the system checked
for possible leaks by Alfa Romeo
Authorized services.
CHECKING AND TOPPING UP
THE BRAKE AND CLUTCH
FLUID
(fig. 11)
Check that the fluid level in the reservoir
is at maximum. Top up with the brake flu-
id specified in the table “Fluids and lubri-
cants” (see section “Technical Specifica-
tions ").
NOTEClean accurately the tank cap A
and the surrounding surface. When open-
ing the cap take the utmost care to pre-
vent impurities entering the tank. When
topping up, always use a funnel with
built-in filter with mesh equal to or lower
than 0.12 mm. On JTD 20V Multijet versions insert the
tube on the cap and refit the cover fasten-
ing with the three screws.
Do not allow power
steering fluid to touch hot
engine parts: it is inflammable.
WARNING
A0D0102m
fig. 11
216
IMPORTANTFor this operation it is
however recommended to contact Alfa
Romeo Authorised Services.
From time to time check the instrument
panel warning light by pressing cover (B)
of the reservoir (A) (with the ignition
key at MAR) the instrument warning
panel light
xshould come on.

217
CHECKING AND TOPPING UP
THE WINDSCREEN/HEADLIGHT
WASHER FLUID
(fig. 12-13)
Access to the windscreen/headlight
washer fluid reservoir, remove the cover
(A-fig. 12) after turning the pins (B).
Then remove the cap (C-fig. 13) and
pour the fluid in the tank until the level
can be seen through the filler neck.
Then close the filler with the cap and re-
fit the cover fastening with the two pins.To avoid damaging the
pump motor do not use
the windscreen washers
when the reservoir is empty.
A0D0104mA0D0103m
fig. 12 fig. 13
Symbolπon the con-
tainer indicates synthetic
type brake fluid distinguishing it
from the mineral kind. Using min-
eral type fluids damages the spe-
cial rubber braking system gaskets
beyond repair.
WARNING
Brake and clutch fluid is
poisonous and corrosive.
In the event of contact wash the
parts concerned immediately with
neutral soap and water, then rinse
thoroughly. See a doctor at once if
the fluid is swallowed.
WARNING
Some commercial addi-
tives for windscreen
washers are inflammable. The en-
gine compartment contains hot com-
ponents which could set it on fire.
WARNING

226
The characteristics of these products are
compatible with the type of paint, gas-
kets and trim of all Alfa Romeo vehicles.
The application of these products should
however be carried out by Alfa Romeo
personnel who will be able to guarantee
the best results and avoid problems which
may compromise the bodywork warranty
cover.
To correctly wash the car, proceed as fol-
lows:
1) Spray the vehicle with a low pres-
sure jet of water.
2) Pass a sponge moistened with a
light detergent solution (2-4% shampoo
in water) over the bodywork rinsing the
sponge frequently.
3) Rinse well with water and dry with a
jet of air or chamois leather.Detergents cause water
pollution. The car should
therefore be washed in
areas equipped for the collection
and purification of the liquid used
in the washing processes.RECOMMENDATIONS TO
PRESERVE THE BODYWORK
Particular care should be taken to en-
sure that residual deposits of industrial
dust, tar spots, dead insects etc. do not
remain on the bodywork.
Where possible do not park under trees
as, during certain seasons, residues, buds
and leaves containing chemical sub-
stances which are harmful to the paint
may fall onto the vehicle.
When topping up ensure that petrol, lu-
bricating oil, brake fluid, liquid for the
cooling system, battery electrolyte solu-
tion etc. is not splashed onto the body-
work.
If this should occur however, clean the
area immediately and wash the vehicle
as soon as possible.
PAINT
The paintwork does not only serve an
aesthetic purpose but also protects the
underlying sheet metal.
In the case of deep scrapes or scores
you are advised to have the necessary
touching up carried out immediately by a
specialised workshop to avoid the forma-
tion of rust.
Normal paint maintenance consists in
washing at intervals depending on the
conditions and environment of use.
For example:
– in areas with high atmospheric pollu-
tion.
– Roads sprayed with salt.
– Parking under trees that release
resinous substances.
It is wise to wash the car more frequently.
Alfa Romeo markets a complete series
of products specifically designed for the
care and cleanliness of its vehicles (sham-
poo, wax, touch-up paint stick, stain re-
mover, polish etc.).

231
The following pages give the various specifications of the vehicle.
These pages will probably represent the main reference point in
this booklet for the “experts and enthusiasts”.
This section should be consulted in order to identify the main cha-
racteristics of your vehicle referred to in the previous chapters.IDENTIFICATION DATA...............................................................................page 232
ENGINE CODES-BODY VERSIONS
.....................................................................233
DIMENSIONS
...........................................................................................................234
ENGINE
......................................................................................................................235
SERVICING
................................................................................................................236
ENGINE OIL CONSUMPTION
..............................................................................236
LUGGAGE COMPARTMENT
..................................................................................237
WEIGHTS
...................................................................................................................237
FUEL SUPPLY - IGNITION
....................................................................................238
PERFORMANCE
.......................................................................................................239
FUEL CONSUMPTION
............................................................................................240
CO
2EMISSIONS......................................................................................................241
BRAKES
.....................................................................................................................241
STEERING
..................................................................................................................242
TRANSMISSION
.......................................................................................................242
FLUIDS AND LUBRICANTS
..................................................................................243
RIM AND TYRES
....................................................................................................245
TYRE INFLATION PRESSURE
...............................................................................247
RADIO FREQUENCY REMOTE CONTROL:
MINISTERIAL HOMOLOGATIONS
.....................................................................251
TECHNICAL SPECIFICATIONS

244
Mechanical gearbox and
differential 3.2 V6 24V engines
Mechanical gearbox and
differential JTD 20V Multijet
engines
Power steering
CV joints
Hydraulic brake and clutch
controls
Cooling circuits
Proportion: 50% water and
50% Paraflu UP
To be used diluted or undiluted TUTELA CAR
TECHNYX
TUTELA CAR
MATRYX
TUTELA GI/A
TUTELA STAR 500
TUTELA TOP 4
for ALFA ROMEO
PARAFLU UP
TUTELA
PROFESSIONAL SC 35 Synthetic-based oil, grade SAE 75W-85,that passes API GL 4 Plus specifications
100% synthetic oil, grade SAE 75W-85, that passes API GL 4 specifications
Lubricant for transmissions that passes "ATF DEXRON II D LEV" specifications
Lithium-soap-based grease with molybdenum bisulphate, NLGI 2 consistency
Synthetic fluid, F.M.V.S.S. n. 116, DOT 4, ISO 4925, SAE J-1704,
CUNA NC 956-01
Protective with antifreeze action for cooling systems, red colour, based on
inhibited monoethylen glycol and organic formula, that passes
CUNA NC 956-16, ASTM D 3306 specifications
Mixture of alcohol and surfactants CUNA NC 956-11
Use Fluid and lubricant specifications Genuine fluids Applications
for correct car operation and lubricants
Lubricants and greases
for transmission
Brake fluid
Protective agent
for radiators
Windscreen and rear
windowwasher fluid
IMPORTANT Do not top-up or mix with products having different properties

264
Engine starting ..............................134
EOBD (system) ..............................113
First aid kit ..................................199
Fluids and lubricants ......................243
Fog lamps ......................................93
"Follow me home" device ................60
Front roof lamp..............................100
Fuel consumption ..........................240
Fuel flap ........................................94
Fuel oil filter ..................................219
Fuel reserve ....................................73
Fuel tank cap ................................127
Fuses and relays ............................186
Gear shift ......................................95
Getting to know your car........11
Glovebox ........................................98
Handbrake ....................................95
Hazard warning lights ......................93Headlamps ....................................110
Headrests........................................33
High beam headlamps ......................58
Identification data..................232
In an emergency ............................157
In the event of an accident ..............198
Inside rear-view mirror ......................36
Installation of electric/
electronic devices ......................156
Instrument cluster ............................12
Instrument light dimmer ....................94
Interior equipment ............................96
Interior maintenance ......................228
Keys............................................ 16
Level checking ..............................209
Light switch ....................................57
Low beam headlamps ......................58
Luggage compartment ....................110
Maintenance
- Additional operations ................206
- Annual Inspection Programme ....206
- Maintenance programme ..........204
- Scheduled Maintenance ............202
Mileage recorder ..............................70
Number plate lights ......................179
Oddments compartments........103-104
Oddment compartment light ............183
Parking ......................................138
Parking lights ..................................58
Parking sensors................................67
Performance ..................................239
Pollen/dust filter ......................90-219
Position lights ..................................58
Power steering ..............................142
Power windows ..............................38