fuel Alfa Romeo 4C 2017 Owner's Guide

Engine Oil Viscosity — 1750 Turbo Engine
(SAE Grade)
SAE 5W-40 full synthetic engine oil is recommended for
all operating temperatures. This engine oil improves
low temperature starting and vehicle fuel economy.
Lubricants which do not have both the engine oil
certification mark and the correct SAE viscosity grade
number should not be used.
Materials Added To Engine Oil
The manufacturer strongly recommends against the
addition of any additives (other than leak detection
dyes) to the engine oil. Engine oil is an engineered
product and its performance may be impaired by
supplemental additives.
Disposing Of Used Engine Oil And Oil Filters
Care should be taken in disposing of used engine oil
and oil filters from your vehicle. Used oil and oil filters,
indiscriminately discarded, can present a problem to
the environment. Contact your authorized dealer, ser-
vice station or governmental agency for advice on how
and where used oil and oil filters can be safely dis-
carded in your area.
Engine Oil Filter
The engine oil filter should be replaced with a new filter
at every engine oil change.
Engine Oil Filter Selection
This manufacturer’s engines have a full-flow type dis-
posable oil filter. Use a filter of this type for replace-
ment. The quality of replacement filters varies consid-
erably. Only high quality filters should be used to
assure most efficient service. MOPAR engine oil filters
are high quality oil filters and are recommended.
Engine Air Cleaner Filter
Refer to the “Maintenance Schedule” in the “Mainte-
nance Schedules” section for the proper maintenance
intervals.
WARNING!
The air induction system (air cleaner, hoses, etc.)
can provide a measure of protection in the case of
engine backfire. Do not remove the air induction
system (air cleaner, hoses, etc.) unless such removal
is necessary for repair or maintenance. Make sure
(Continued)
7
MAINTAINING YOUR VEHICLE 215

WARNING!
•Exhaust gases can injure or kill. They contain
carbon monoxide (CO), which is colorless and
odorless. Breathing it can make you unconscious
and can eventually poison you. To avoid breath-
ing CO, refer to “Safety Tips/Exhaust Gas” in
“Things To Know Before Starting Your Vehicle”
for further information.
• A hot exhaust system can start a fire if you park
over materials that can burn. Such materials
might be grass or leaves coming into contact with
your exhaust system. Do not park or operate your
vehicle in areas where your exhaust system can
contact anything that can burn.
CAUTION!
• The catalytic converter requires the use of un-
leaded fuel only. Leaded gasoline will destroy the
effectiveness of the catalyst as an emissions con-
trol device and may seriously reduce engine per-
formance and cause serious damage to the engine.
(Continued)
CAUTION! (Continued)
•Damage to the catalytic converter can result if
your vehicle is not kept in proper operating
condition. In the event of engine malfunction,
particularly involving engine misfire or other
apparent loss of performance, have your vehicle
serviced promptly. Continued operation of your
vehicle with a severe malfunction could cause the
converter to overheat, resulting in possible dam-
age to the converter and vehicle.
Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is
important to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.
NOTE: Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
224 MAINTAINING YOUR VEHICLE

CavityMaxi Fuse Mini Fuse Description
F01 70 Amp Tan –Body Controller
F03 20 Amp Yellow –Ignition Switch
F04 40 Amp Orange –Anti-Lock Brake Pump
F05 20 Amp Yellow –Anti-Lock Brake Valve
F06 40 Amp Orange –Radiator Fan - Low Speed
F07 50 Amp Red –Radiator Fan - High Speed
F08 20 Amp Yellow –Blower Motor
F09 –5 Amp Tan Headlight beam switch (If Equipped)
F10 –10 Amp Red Horn
F11 –20 Amp Yellow Powertrain
F14 –15 Amp Blue Alfa Twin Clutch Transmission
F15 –15 Amp Blue Alfa Twin Clutch Transmission
F16 –5 Amp Tan Alfa Twin Clutch Transmission, ECM
F17 –10 Amp Red Powertrain
F18 –5 Amp Tan Powertrain
F19 –7.5 Amp Brown Air Conditioning Compressor
F21 –20 Amp Yellow Fuel Pump
F22 –20 Amp Yellow Engine Control Unit Power Supply
F24 –5 Amp Tan Anti-Lock Brake System (ABS)
F30 –10 Amp Red Water Pump, HVAC
242 MAINTAINING YOUR VEHICLE

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
1750 Turbo Engine 10.5 Gallons40 Liters
Reserve Fuel 1.1 Gallons4 Liters
Engine Oil with Filter
1750 Turbo Engine 6.1 Quarts5.8 Liters
Cooling System
1750 Turbo Engine (MOPAR
Antifreeze/Engine Coolant 10
Year/150,000 Mile Formula). 11.2 Quarts
10.6 Liters
256 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant – 1750 Turbo Engine We recommend you use MOPAR Antifreeze/Coolant 10
Year/150,000 Mile Formula OAT (Organic Additive
Technology) or equivalent meeting the requirements of
FCA Material Standard MS.90032.
Engine Oil – 1750 Turbo Engine We recommend you use SAE 5W-40 API Certified
Synthetic Engine Oil, meeting the requirements of FCA
Material Standard MS-12991.
Engine Oil Filter – 1750 Turbo Engine We recommend you use MOPAR Engine Oil Filter.
Spark Plugs – 1750 Turbo Engine We recommend you use MOPAR Spark Plugs. *
Fuel Selection – 1750 Turbo Engine Use Only 91 Octane or higher, 0-10% Ethanol.
NOTE: * The following are essential to ensure correct
operation and prevent serious damage to the engine:
only use spark plugs of the same make and type which
are specially certified for such engines strictly comply
with the spark plug replacement interval given in the
maintenance schedule. For spark plug replacement, it is
advisable to contact the dedicated Alfa Romeo Dealer-
ship. Refer to the “Maintenance Schedule” section for
the required spark plug intervals.
7
MAINTAINING YOUR VEHICLE 257

Under any of the above circumstances, the following
checks need to be performed more frequently than
indicated in the Maintenance Schedule:
•Check front and rear disc brake pad condition and
wear.
• Check cleanliness of tailgate locks.
• Check cleanliness and lubrication of chassis and
steering linkage.
• Visually inspect condition of: engine, gearbox, trans-
mission, pipes and hoses (exhaust - fuel system -
brakes) and rubber elements (gaiters - sleeves -
bushes - etc.).
• Check battery charge and battery fluid level (electro-
lyte).
• Visually inspect condition of the auxiliary drive belts.
• Check and, if necessary, change engine oil and re-
place oil filter.
• Check and, if necessary, replace air cleaner filter. Using the vehicle on a track should be regarded as an
exception. The vehicle has been designed and manufac-
tured for road use.
Change Engine Oil at 4,000 miles (6,500 km) if the
vehicle is operated in a dusty and off road environment.
This type of vehicle use is considered Severe Duty.
If the vehicle is operated in a dusty or dirty environ-
ment the engine air filter has to be changed every 6,500
miles (10,000 km).
Once A Month Or Before A Long Trip/Periodic Checks
Every 600 miles (1,000 km) or before long trips, check
and, if necessary, top off the following:
•
Check engine oil level.
• Check brake fluid level.
• Check windshield washer fluid level.8
MAINTENANCE SCHEDULES 261

Mileage or time passed
(whichever comes first)
12,000
24,000
36,000
48,000
60,000
72,000
84,000
96,000
108,000
120,000
132,000
144,000
156,000
Or Months: 12 24 36 48 60 72 84 96 108 120 132 144 156
Or Kilometers:
20,000
40,000
60,000
80,000
100,000
120,000
140,000
160,000
180,000
200,000
220,000
240,000
260,000
Check position/wear of
windscreen wiper blade XXXXXXXXXXXXX
Check cleanliness of hood
and deck lid locks, as well
as cleanliness and lubrica-
tion of associated linkages XXXXXXXXXXXXX
Visually inspect condition
of: exterior bodywork, car-
bon monocoque, aerody-
namic bottom, pipes and
hoses (exhaust, fuel sup-
ply system, brakes), rub-
ber elements (boots, drive-
shaft boots, sleeves,
bushes, etc.) XXXXXXXXXXXXX
Check condition and wear
of front brake pads and
discs, and operation of
pad wear indicator XXXXXXXXXXXXX
264 MAINTENANCE SCHEDULES

Adding Engine Coolant (Antifreeze)...........227
Adding Fuel ........................... .187
Adding Washer Fluid .....................221
Additives, Fuel ......................... .185
AirBag................................36 Air Bag Operation ......................38
Driver Knee Air Bag .....................39
Enhanced Accident Response ..............206
Event Data Recorder (EDR) ...............206
If A Deployment Occurs ..................41
Knee Impact Bolsters ....................38
Maintaining Your Air Bag System ...........44
Air Bag Light ........................ .57, 97
Air Bag Maintenance ......................44
Air Cleaner, Engine (Engine Air Cleaner Filter). . . .215
Air Conditioner Maintenance ................217
Air Conditioning Refrigerant .............217, 218
Air Conditioning System ...................217
Air Pressure, Tires ....................... .168
Alarm System (Security Alarm) ...............12
Alfa DNA System (Dynamic Car Control System) ....................... .141
Alfa Twin Clutch Transmission ...........136, 210
Fluid Type ....................... .234, 258
Alterations/Modifications, Vehicle ..............6Antifreeze (Engine Coolant)
..............226, 256
Capacities .......................... .256
Disposal ............................ .228
Anti-Lock Brake System (ABS) ...............152
Appearance Care ....................... .234
Automatic Door Locks .....................19
Automatic Transaxle ........................9
Automatic Transmission ...................136
Fluid Type .......................... .258
Auto Unlock, Doors .......................19
Auxiliary Electrical Outlet (Power Outlet) ........83
Battery ............................ .99, 216
Charging System Light ...................99
Keyless Key Fob Replacement ..............16
Belts, Seat ..............................57
Body Mechanism Lubrication ................218
B-Pillar Location ........................ .162
Brake Fluid ........................... .258
Brake, Parking ......................... .148
Brakes ............................... .230
Brake System ....................... .150, 230
Anti-Lock (ABS) ...................... .152
Master Cylinder ...................... .230
Parking ............................ .148
276 INDEX

Daytime Running Lights....................72
Dealer Service .......................... .212
Deck Lid ...............................22
Deck Lid, Release .........................68
Defroster, Windshield ......................57
Delay (Intermittent) Wipers ..................75
Diagnostic System, Onboard ................210
Dimmer Control ..........................73
Disposal Antifreeze (Engine Coolant) ...............228
Door Locks .............................18
Child-Protection Door Lock — Rear Doors .....19
Power Door Locks ......................15
Doors .................................18
Driving Through Flowing, Rising, Or Shallow
Standing Water ....................... .147
Electrical Outlet, Auxiliary (Power Outlet) .......83
Electrical Power Outlets ....................83
Electric Remote Mirrors .....................64
Electronic Brake Control System ..............150
Electronic Speed Control (Cruise Control) ........77
Electronic Throttle Control Warning Light ........96Emergency, In Case Of
Hazard Warning Flasher .................192
Jump Starting ........................ .200
Overheating ......................... .192
Emission Control System Maintenance .........211
Engine Air Cleaner ......................... .215
Break-In Recommendations ................55
Checking Oil Level .....................214
Compartment ........................ .209
Cooling ............................ .225
Exhaust Gas Caution .................56, 187
Fails To Start ........................ .135
Flooded, Starting ..................... .135
Fuel Requirements .....................183
Jump Starting ........................ .200
Oil ............................ .214, 256
Oil Filler Cap ........................ .215
Oil Filter ........................... .215
Oil Selection ......................... .214
Overheating ......................... .192
Starting ............................ .134
Enhanced

Accident Response Feature ..........206
Ethanol .............................. .184
278 INDEX

Euro Twin Clutch TransmissionFluid Type .......................... .234
Exhaust Gas Caution ...................56, 187
Exhaust System ...................... .56, 223
Exterior Lights ...........................59
Filters Air Cleaner ......................... .215
Engine Fuel ......................... .257
Engine Oil .......................... .215
Engine Oil Disposal ....................215
Flashers Hazard Warning ...................... .192
Turn Signal ....................... .59, 107
Flooded Engine Starting ...................135
Fluid, Brake ........................... .258
Fluid Capacities ........................ .256
Fluid Leaks .............................59
Fluids, Lubricants And Genuine Parts ..........257
Four-Way Hazard Flasher ..................192
Fuel ................................. .183
Adding ............................ .187
Additives ........................... .185
Capacity ........................... .256
Clean Air ........................... .184Ethanol
............................ .184
Gasoline ........................... .183
Materials Added ...................... .185
Methanol ........................... .184
Octane Rating ........................ .183
Requirements ........................ .183
Tank Capacity ....................... .256
Fueling .............................. .187
Fuses ................................ .240
Gasoline, Clean Air ...................... .184
Gasoline (Fuel) ...................... .183, 256
Gasoline, Reformulated ....................184
General Information ...................125,
183
General Maintenance ..................... .213
Glass Cleaning ......................... .239
Hazard Driving Through Flowing, Rising, Or Shallow
Standing Water ....................... .147
Hazard Warning Flasher ...................192
Headlights ..............................71
Cleaning ........................... .239
Passing ..............................72
Head Restraints ..........................67
10
INDEX 279