belt Alfa Romeo 4C 2018 Service Manual

WARNING!
The air induction system (air cleaner, hoses, etc.)
can provide a measure of protection in the case of
engine backfire. Do not remove the air induction
system (air cleaner, hoses, etc.) unless such removal
is necessary for repair or maintenance. Make sure
that no one is near the engine compartment before
starting the vehicle with the air induction system
(air cleaner, hoses, etc.) removed. Failure to do so
can result in serious personal injury.
Engine Air Cleaner Filter Selection
The quality of replacement engine air cleaner filters
varies considerably. Only high quality filters should be
used to assure most efficient service. Mopar engine air
cleaner filters are a high quality filter and are recom-
mended.
Engine Cover
To avoid possible damage to the engine cover, please
disconnect each of the four mounting studs by pulling
the engine cover upward, and then lift off the complete cover. Tilting the engine cover when one or more studs
are still engaged will lead to premature failure of the
couplers.
To reassemble the cover back onto the engine, first make
sure it is properly aligned, the oil cap is centered, and
that all four studs are lined up with their couplers. Then
gently push on the four corners of the engine cover to
snap the stud back into position.
No tools are required to remove or reassemble the
engine cover.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a perfor-
mance test. Drive belt tension should also be checked at
this time.
WARNING!
•
Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
(Continued)
202 SERVICING AND MAINTENANCE

Special Care
•If you drive on salted or dusty roads or if you drive
near the ocean, hose off the undercarriage at least
once a month.
• It is important that the drain holes in the lower edges
of the doors, rocker panels, and trunk be kept clear
and open.
• If you detect any stone chips or scratches in the paint,
touch them up immediately. The cost of such repairs
is considered the responsibility of the owner.
• If your vehicle is damaged due to a collision or
similar cause that destroys the paint and protective
coating, have your vehicle repaired as soon as pos-
sible. The cost of such repairs is considered the
responsibility of the owner.
• If you carry special cargo such as chemicals, fertiliz-
ers, de-icer salt, etc., be sure that such materials are
well packaged and sealed.
• If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
• Use Mopar Touch Up Paint on scratches as soon as
possible. Your authorized dealer has touch up paint
to match the color of your vehicle.
INTERIORS
Seats And Fabric Parts
Use Mopar Total Clean to clean fabric upholstery and
carpeting.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the
fabric. Sun damage can also weaken the fabric.
If the belts need cleaning, use Mopar Total Clean, a mild
soap solution, or lukewarm water. Do not remove the
belts from the vehicle to wash them. Dry with a soft
cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
242 SERVICING AND MAINTENANCE

NOTE:If the belts retract slowly, inspect the upper
turning loop for soiling. If soiling is present, clean with
a wet soft cloth until all residue is removed.
WARNING!
A frayed or torn belt could rip apart in a collision
and leave you with no protection. Inspect the belt
system periodically, checking for cuts, frays, or
loose parts. Damaged parts must be replaced imme-
diately. Do not disassemble or modify the system.
Seat belt assemblies must be replaced after a colli-
sion if they have been damaged (i.e., bent retractor,
torn webbing, etc.).
Plastic And Coated Parts
Use Mopar Total Clean to clean vinyl upholstery.
CAUTION!
•Direct contact of air fresheners, insect repellents,
suntan lotions, or hand sanitizers to the plastic,
painted, or decorated surfaces of the interior may
cause permanent damage. Wipe away immediately.
(Continued)
CAUTION! (Continued)
•Damage caused by these type of products may not
be covered by your New Vehicle Limited War-
ranty.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft cloth. A mild soap solution may be used, but do not use high alcohol content or
abrasive cleaners. If soap is used, wipe clean with a
clean damp cloth.
2. Dry with a soft cloth.
Leather Parts
Mopar Total Clean is specifically recommended for
leather upholstery.
Your leather upholstery can be best preserved by regu-
lar cleaning with a damp soft cloth. Small particles of
dirt can act as an abrasive and damage the leather
upholstery and should be removed promptly with a
damp cloth. Stubborn soils can be removed easily with
8
SERVICING AND MAINTENANCE 243

Adding Engine Coolant (Antifreeze)...........209
Adding Fuel ........................... .149
Adding Washer Fluid .....................196
Additives, Fuel ......................... .248
AirBag .............................. .104
Air Bag Operation .....................106
Air Bag Warning Light ..................103
Driver Knee Air Bag ....................107
Enhanced Accident Response ..............184
Event Data Recorder (EDR) ...............184
If A Deployment Occurs .................110
Knee Impact Bolsters ....................106
Maintaining Your Air Bag System ...........113
Transporting Pets ..................... .122
Air Bag Light .....................71, 103, 124
Air Bag Maintenance ......................113
Air Cleaner, Engine (Engine Air Cleaner Filter) . . .201
Air Conditioner Maintenance ................202
Air Conditioning Refrigerant .............202, 203
Air Conditioning System ...................202
Air Filter ............................. .201
Air Pressure, Tires ....................... .227
Alarm System (Security Alarm) ...............20
Alfa DNA System (Dynamic Car Control System) .138
Alfa Twin Clutch Transmission............77, 133 Fluid Type
....................... .216, 254
Alterations/Modifications, Vehicle ..............6
Antifreeze (Engine Coolant) ..............208, 252
Capacities .......................... .252
Disposal .............................211
Anti-Lock Brake System (ABS) ................82
Anti-Lock Warning Light ....................74
Automatic Transaxle .......................17
Automatic Transmission ...................133
Fluid Type .......................... .254
Auxiliary Electrical Outlet (Power Outlet) ........50
Battery ............................ .71, 199
Charging System Light ...................71
Keyless Key Fob Replacement ..............16
Belts, Seat ............................. .124
Body Mechanism Lubrication ................203
B-Pillar
Location ........................ .222
Brake Fluid ........................... .254
Brake, Parking ......................... .131
Brake System ....................... .212, 248
Anti-Lock (ABS) ........................82
Master Cylinder ...................... .212
Parking ............................ .131
Warning Light .........................69
266 INDEX

Head Restraints..........................26
Heated Mirrors ...........................29
Heater .................................39
Holder, Cup .............................50
Ignition ................................17
Key ............................. .15, 17
Ignition Key Removal ......................17
Immobilizer (Sentry Key) ...................19
Inside Rearview Mirror .....................27
Instrument Cluster ........................76
Instrument Cluster ......................54
Instrument Panel Lens Cleaning ..............243
Interior And Instrument Lights ...............32
Interior Appearance Care ...................242
Interior Lights ...........................32
Intermittent Wipers (Delay Wipers) ............34
Introduction .............................4
Jack Operation ......................... .216
Jump Starting .......................... .176
Key Fob Unlock The Doors ......................15
Key Fob Battery Service (Remote Keyless Entry) . . .16 Key-In Reminder
.........................19
Key, Replacement .........................19
Keys ..................................15
Key, Sentry (Immobilizer) ...................19
Lane Change Assist .......................32
Lap/Shoulder Belts ........................95
Latches .............................. .126
Lead Free Gasoline ...................... .248
Leaks, Fluid ........................... .126
Life Of Tires ........................... .230
Light Bulbs ........................ .126, 156
Lights ............................. .30, 126
AirBag .......................71, 103, 124
Brake Warning .........................69
Bulb Replacement ..................... .156
Cruise ...............................76
Engine Temperature Warning ..............72
Exterior ............................ .126
Hazard Warning Flasher .................156
Interior ..............................32
Malfunction Indicator (Check Engine) ........75
Park ............................. .31, 76
Passing ..............................31
Seat

Belt Reminder ......................71
270 INDEX

Viscosity........................... .201
Oil Filter, Change ....................... .201
Oil Filter, Selection ...................... .201
Oil Pressure Light .........................70
Onboard Diagnostic System ..................77
Operating Precautions ......................77
Operator Manual (Owner’s Manual) ............5
Outside Rearview Mirrors ...................28
Overheating, Engine ..................... .180
Owner’s Manual (Operator Manual) .........5,264
Paint Care ............................ .240
Parking Brake .......................... .131
Passing Light ............................31
Pets ................................. .122
Placard, Tire And Loading Information .........222
Power Door Locks ...........................22
Mirrors ..............................29
Windows .............................42
Pregnant Women And Seat Belts ..............100
Pretensioners Seat Belts ........................... .100
Radial Ply Tires ........................ .228Radiator Cap (Coolant Pressure Cap)
..........210
Radio Frequency General Information ..................17, 20
Radio Operation ........................ .258
Rear Seat, Folding ........................24
Reclining Front Seats ......................25
Recreational Towing ..................... .151
Reformulated Gasoline ....................248
Refrigerant ............................ .203
Reminder, Seat Belt ........................94
Remote Keyless Entry Unlock The Doors ......................15
Replacement Bulbs ...................... .156
Replacement Keys ........................19
Replacement Tires ....................... .231
Reporting Safety Defects ...................263
Restraint, Head ..........................26
Restraints, Child .........................114
Rotation, Tires ......................... .238
Safety Checks Inside Vehicle ................124
Safety
Checks Outside Vehicle ...............126
Safety Defects, Reporting ...................263
Safety, Exhaust Gas ...................... .123
Safety Information, Tire ....................216
272 INDEX

Safety Tips............................ .123
Schedule, Maintenance ....................187
Seat Belt Automatic Locking Retractor (ALR) .........101
Energy Management Feature ..............100
Lap/Shoulder Belt Operation ..............97
Lap/Shoulder Belts .....................95
Lap/Shoulder Belt Untwisting ..............99
Pregnant Women ..................... .100
Seat Belt Pretensioner ...................100
Seat Belt Reminder ......................94
Seat Belt Maintenance .....................242
Seat Belt Reminder ........................94
Seat Belts .......................... .93, 124
Child Restraint ........................114
Front Seat ...................... .93, 95, 97
Inspection .......................... .124
Operating Instructions ...................97
Pregnant Women ..................... .100
Pretensioners ........................ .100
Rear Seat .............................95
Reminder ............................71
Untwisting Procedure ....................99
Seats ..................................24
Adjustment ...........................24 Easy Entry
............................24
Heated ..............................24
Memory .............................24
Rear Folding ..........................24
Reclining .............................25
Seatback Release .......................24
Tilting ...............................24
Vented ...............................24
Ventilated ............................24
Security Alarm ...........................20
Sentry Key (Immobilizer) ...................19
Service Assistance ....................... .260
Service Contract ........................ .262
Service Manuals ........................ .264
Shoulder Belts ...........................95
Signals, Turn ........................ .76, 126
Snow Chains (Tire Chains) ..................237
Snow Tires ............................ .233
Spar

e Tire ......................... .233, 235
Spark Plugs ........................... .253
Speed Control Accel/Decel ......................... .145
Speed Control (Cruise Control) ...............143
Starting .............................. .129
Automatic Transmission .................129
12
INDEX 273

TransaxleAutomatic ............................17
Transmission .......................... .133
Automatic .......................... .133
Fluid .............................. .215
Maintenance ......................... .215
Transporting Pets ....................... .122
Tread Wear Indicators .....................230
Turn Signals .............................76
Uniform Tire Quality Grades ................238
Unleaded Gasoline ...................... .248
Untwisting Procedure, Seat Belt ...............99
Vehicle Identification Number (VIN) ...........246
Vehicle Loading ........................ .223
Vehicle Modifications/Alterations ..............6
Vehicle Security Alarm (Security Alarm) .........20
Vehicle Storage ......................... .240Warning Flasher, Hazard
...................156
Warning Lights (Instrument Cluster Description) . . .75
Warnings And Cautions .....................6
Warranty Information .....................263
Washer Adding Fluid ........................ .196
Washers, Windshield .......................34
Washing Vehicle ........................ .241
Water Driving Through ...................... .153
Wheel And Wheel Trim ....................236
Wheel And Wheel Trim Care ................236
Windows ...............................42
Power ...............................42
Windshield Defroster ..................... .124
Windshield Washers .......................34
Windshield Wiper Blades ...................204
Windshield Wipers ........................34
Wiper Blade Replacement ..................204
Wipers, Intermittent .......................34
12
INDEX 275