engine overheat Acura CL 2002 Owner's Manual

This indicator will come on along
with the ABS indicator if there is a
problem in the anti-lock brake
system (seeon page
).
The TCS indicator may occasionally
come on f or one or two seconds and
then go out. This is normal.
The Traction Control System turns
on every time you start the engine,
even if you turned it of f the last time
you drove the vehicle.
The TCS indicator comes on or
f lashes under the f ollowing condi-
tions:
When you turn the ignition switch
to ON (II).
When you manually turn of f TCS. If the TCS indicator comes on and
stays on for more than 10 minutes
while driving, pull to the side of the
road when it is saf e and turn of f the
engine. Reset the system by
restarting the engine, and watch the
TCS indicator. If the indicator
remains on, or comes back on while
driving, have the system inspected
by your Acura dealer. You can still
drive the vehicle without TCS.
It f lashes when TCS is regulating
wheelspin.
If the system’s diagnostics senses
a problem with TCS, the indicator
will come on and stay on.
If the brakes overheat, the
indicator will come on. 190
ABS Indicator
T CS Indicat or
Traction Control System
Driving192

´
µ´
µ
Install the ignition coil. Reinstall
the hexagon socket head cap bolt.
Push the wire connector onto the
ignition coil. Make sure it locks in
place.
Repeat this procedure f or the
other f ive spark plugs.
Reinstall the cover on the front
cylinder bank while putting its
mounting clip in the hole on the
passenger’s side. Secure the cover
by turning the heads of the two
holding clips one-quarter turn
clockwise with a f lat-tipped
screwdriver.
Spark Plug Gap:
Spark Plug Gap:
8.
9.
10.
11. NGK:
DENSO:
NGK:
DENSO:
Spark Plugs
Maint enance
Specif ications:
Premium model
T ype-S
237
0.04 in (1.1 mm)
0.04 in (1.1 mm) PZFR5F-11
PKJ16CR-L11
PZFR6F-11
PKJ20CR-L11
0
0.1 mm0
0.1 mm
Tighten the spark plugs caref ully. A
spark plug that is too loose can
overheat and damage the engine.
Overtightening can cause damage to
the threads in the cylinder head.

This section covers the more-
common problems that motorists
experience with their vehicles. It
gives you inf ormation about how to
safely evaluate the problem and what
to do to correct it. If the problem has
stranded you on the side of the road,
you may be able to get going again.
If not, you will also f ind instructions
on getting your car towed.......................
Compact Spare Tire .274
....................
Changing a Flat Tire .275
..........
If Your Engine Won’t Start . 280
Nothing Happens or the Starter Motor Operates ........................
Very Slowly .281
The Starter Operates ................................
Normally .282
................................
Jump Starting .283
............
If Your Engine Overheats . 286
.........
Low Oil Pressure Indicator . 288
..........
Charging System Indicator . 289
.......
Malf unction Indicator Lamp . 290
.......................
Readiness Codes .291
...............
Brake System Indicator . 292
..................
Closing the Moonroof . 293
..............................................
Fuses .294
..........
Checking and Replacing . 295
......................
Emergency Towing .300
Taking Care of the Unexpected
T aking Care of t he Unexpect ed273

If you see steam and/or spray
coming f rom under the hood, turn
of f the engine.
If you do not see steam or spray,
leave the engine running and
watch the temperature gauge. If
the high heat is due to overloading
(climbing a long, steep hill on a
hot day with the A/C running, for
example), the engine should start
to cool down almost immediately.
If it does, wait until the tempera-
ture gauge comes down to the mid-
point then continue driving. Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park and set the parking brake.
Turn of f the climate control and all
otheraccessories.Turnonthe
hazard warning indicators.
The pointer of your car’s tempera-
ture gauge should stay in the mid-
range under most conditions. It may
go higher if you are driving up a long
steep hill on a very hot day. If it
climbs to the red mark, you should
determine the reason. Your car can overheat f or several
reasons, such as lack of coolant or a
mechanical problem. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
In either case, you should take
immediate action.1.
2.
3.
If Your Engine Overheats
T aking Care of t he Unexpect ed286
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to your engine.

If the temperature gauge stays at
the red mark, turn of f the engine.
Wait until you see no more signs
of steam or spray, then open the
hood.
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks. Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see on page ).
If there was no coolant in the
reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the pointer reaches the middle of the tempera-
ture gauge, or lower, bef ore check-
ing the radiator.
Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
Start the engine and set the
temperature control dial to
maximum (climate control to
FULL AUTO at 90°F/32°C). Add
coolant to the radiator up to the
base of the f iller neck. If you do
not have the proper coolant
mixture available, you can add
plain water. Remember to have
the cooling system drained and
ref illed with the proper mixture as
soon as you can.
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly. Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .)
4.
5.
6.
7.
8.
9.10.
12.
11.
300
167 300
Emergency
Towing
Emergency
Towing
If Your Engine Overheats
T aking Care of t he Unexpect ed287
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

CONT INUED
..............................
Economy, Fuel .168
............
Emergencies on the Road . 273
.............
Battery, Jump Starting . 283
...........
Brake System Indicator . 292
................
Changing a Flat Tire . 275
.....
Charging System Indicator . 289
..................
Checking the Fuses . 295
.....
Low Oil Pressure Indicator . 288
...
Malf unction Indicator Lamp . 290
...
Manually Closing Moonroof . 293
..................
Overheated Engine . 286
.........................
Emergency Brake .102
......................
Emergency Flashers .70
......................
Emergency Towing .300
............
Emergency Trunk Opener . 84
.......................
Emissions Controls .312
.............
Emissions Testing, State . 315
Engine ............................................
Belts .244
....
Coolant Temperature Gauge . 62
Malf unction Indicator ................................
Lamp .55, 290
........
Oil Pressure Indicator . 55,288
..............
Oil, What Kind to Use . 219...............................
Overheating .286
............................
Specif ications .307
............................
Speed Limiter .184
.......................................
Starting .177
......................
Ethanol in Gasoline .310
.
Evaporative Emissions Controls . 312
...............................
Exhaust Fumes .49
Exhaust Gas Recirculation ........................................
System .313
Expectant Mothers, Use of Seat ........................................
Belts by .18
..................
Exterior, Cleaning the . 266
..........................
Fan, Interior .118, 123
Features, Comfort and ..............................
Convenience .113
....................
Filling the Fuel Tank . 163
Filters ................................
Air Cleaner .233
.........................
Dust and Pollen .244
...............................................
Oil .221
.............
Flashers, Hazard Warning . 70
................
Daytime Running Lights . 67
............
Def ects, Reporting Saf ety . 320
................
Def ogger, Rear Window . 70
......
Def rosting the Windows . 120,125
....................................
Dimensions .306
...............
Dimming the Headlights . 65
Dipstick ..........
Automatic Transmission . 230
..................................
Engine Oil .165
..........................
Directional Signals .67
........
Disc Brake Wear Indicators . 187
.....................
Disposal of Used Oil .222
Doors ....................
Lockout Prevention . 78
..............................
Monitor Light .58
......................
Power Door Locks .77
..........
DOT Tire Quality Grading . 308
.....................................
Drive Belts .244
...........
Driver and Passenger Safety . 5
...........................................
Driving .175
....................................
Economy .168
.........................
In Bad Weather .196
................
In Foreign Countries . 311
Driving Position Memory ..........................................
System .95
..................
Dust and Pollen Filter . 244
Index
E
F
III

...
Octane Requirement, Gasoline . 162
.........................................
Odometer .61
...............................
Odometer, Trip .61
Oil ........................
Change, How to .221
......................
Change, When to .210
......................
Checking Engine .165
..............
Pressure Indicator . 55,288
Selecting Proper Viscosity ......................................
Chart .220
...........
ON (Ignition Key Position) . 76
Onboard Ref ueling Vapor ....................................
Recovery .312
..
Operation in Foreign Countries . 311
..............................
Outside Mirrors .93
....
Outside Temperature Indicator . 62
....................
Overheating, Engine .286
.......
Owner Maintenance Checks . 217
.........................
Oxygenated Fuels .310
..............................
Paint Touch-up .267
..............
Panel Brightness Control . 67........................
Park Gear Position .180
...........................................
Parking .186
...............................
Parking Brake .102
Parking Brake and Brake .................
System Indicator . 55,292
.................................
Parking Lights .65
..
Parking Over Things that Burn . 314
.............................
PGM-FI System .313
..................
Polishing and Waxing . 267
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 18
............................
Protecting Adults .12
...
Additional Safety Precautions . 19
.....
Advice f or Pregnant Women . 18
........................
Protecting Children .20
.......................
Protecting Inf ants .28
.......
Protecting Larger Children . 35
.........
Protecting Small Children . 32
Using Child Seats with .....................................
Tethers .39
...................
Radiator Overheating . 286
Radio/Cassette/CD Sound ........................................
System .127 ...........................
Readiness Codes .291
..........
Rear Console Compartment . 85
..
Rear Lights, Bulb Replacement . 258
............................
Rear Seat Access .89
..........................
Rear Seat Armrest .91
............................
Rear View Mirror .93
.................
Rear Window Def ogger . 70
...............
Reclining the Seat Backs . 87
.............................
Reminder Lights .53
.......................
Remote Transmitter .78
Replacement Inf ormation .................
Air Cleaner Element . 233
..............
Dust and Pollen Filter . 244
..........................
Engine Coolant .225
................
Engine Oil and Filter . 221
..........................................
Fuses .295
................................
Light Bulbs .254
....................................
Schedule .208
................................
Spark Plugs .235
...........................................
Tires .249
.............................
Wiper Blades .241
Replacing Seat Belts Af ter a ............................................
Crash .42
...
Reserve Tank, Engine Coolant . 167
...............................
Restraint, Child .20
..................
Reverse Gear Position . 180
Index
O
P R
VI