ignition Acura TSX 2004 Manual PDF

This indicator should light when the
ignition switch is ON (II), and go out
af ter the engine starts. If it comes on
at any other time, it indicates one of
the engine’s emissions control
systems may have a problem. Even
though you may f eel no dif f erence in
your car’s perf ormance, it can
reduce your f uel economy and cause
your car to put out excessive
emissions. Continued operation may
cause serious damage.Youshouldalsohavethedealer
inspect your car if this indicator
comes on repeatedly, even though it
may turn of f as you continue driving.
This indicator may also come on
along with the ‘‘D’’ indicator.
If you have recently ref ueled your
car, the cause of this indicator
coming on could be a loose or
missing f uel f ill cap. Check the cap
and tighten it until it clicks at least
three times. Replace the f uel f ill cap
if it is missing. Tightening the cap
will not make the indicator turn of f
immediately; it takes at least three
days of normal driving.
If the indicator remains on past three
days of normal driving, or the f uel
cap was not loose or missing, have
the car checked by the dealer as
soon as possible. Drive moderately
until the dealer has inspected the
problem. Avoid f ull-throttle
acceleration and driving at high
speed.
Malf unction Indicator L amp
T aking Care of t he Unexpect ed319
MALFUNCTION INDICATOR LAMP
If you keep driving with the
malf unction indicator lamp on, you can
damage your car’s emissions controls
and engine. Those repairs may not be
covered by your car’s warranties.

Your car has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.
If your car’s battery has been
disconnected or gone dead, these
codes are erased. It takes several
days of driving under various
conditions to set the codes again.If possible, do not take your car f or a
state emissions test until the
readiness codes are set. Ref er to
State Emissions Testing f or more
inf ormation. (See page .)
To check if they are set, turn the
ignition ON (II), but do not start the
engine. The Malf unction Indicator
Lamp will come on f or 20 seconds. If
it then goes of f , the readiness codes
are set. If it blinks 5 times, the
readiness codes are not set.
345
Malf unction Indicator L amp
T aking Care of t he Unexpect ed
Readiness Codes
320

Î
ÎIf it comes on at any other time, it
indicates a problem with the car’s
brake system. In most cases, the
problem is a low f luid level in the
brake f luid reservoir. Press lightly on
the brake pedal to see if it f eels
normal. If it does, check the brake
f luid level the next time you stop at a
service station (see page ). If the
fluid level is low, take the car to your
dealer and have the brake system
inspected f or leaks or worn brake
pads.
However, if the brake pedal does not
f eel normal, you should take
immediate action. Because of the
brake system’s dual-circuit design, a
problem in one part of the system
will still give you braking at two
wheels. You will f eel the brake pedal
go down much f arther bef ore the car
begins to slow down, and you will
have to press harder on the pedal.
The distance needed to stop will be
much longer. Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the
longer distance needed to stop, it is
hazardous to drive the car. You
should have it towed, and repaired as
soon as possible. (See
on page .)
The Brake System Indicator
normallycomesonwhenyouturn
the ignition switch ON (II). It is a
reminder to check the parking brake.
It comes on and stays lit if you do not
f ully release the parking brake. If you must drive the car a short
distance in this condition, drive
slowly and cautiously.
If the ABS indicator comes on with
this indicator, have the car inspected
by your Acura dealer immediately.
259
328Emergency
Towing
Brake System Indicator
T aking Care of t he Unexpect ed321
BRAKE SYSTEM INDICATOR
U.S. indicator shown

Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box.
If something electrical in your car
stops working, the f irst thing you
should check f or is a blown f use.
Determine f rom the chart on pages
and , or the diagram on the
fuse box lid, which fuse or fuses
control that component. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
not the cause. Replace any blown
f uses and check the component’s
operation. Check each of the large f uses in
the under-hood f use box by
looking at the wire inside.
Removing these f uses requires a
Phillips-head screwdriver.
3.
1.
2. 326 327
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed324
BLOWN
BLOWN

µµ
µ
µ
µ
Î
Î
No.
No. No. Amps. Circuits Protected
Amps. Circuits Protected Circuits Protected
Amps.
: On Canadian models
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
1
2
3
4
5
6 7
8
9
10
11
12 10 A
20 A
15 A
7.5 A 30 A Back-Up Lights
Door Lock
Front Accessory Sockets
IG OPDS
IG Wiper
Not Used
(15 A)
15 A
(10 A) 10 A
20 A
10 A DBW
Ignition Coil
Day Light
LAF
Audio Amp
Interior Light Not Used
Driver’s Power Seat Sliding
Heated Seat
Driver’s Power Seat Reclining
Not Used
IG ACG
IG Fuel Pump
IG Washer
IG Meter
IG SRS
IGP (PGM-FI ECU)
Lef t Rear Power Window
Right Rear Power Window
Right Front Power Window
Driver’s Power Window
Moonroof
Not Used
IG HAC
Not Used
ACC
HAC OP
(20 A)
(20 A)
(20 A)
15 A
15 A
7.5 A
7.5 A 10 A
7.5 A 20 A
20 A
20 A
20 A
(20 A)
7.5 A
7.5 A
7.5 A
Fuses
T aking Care of t he Unexpect ed327
INTERIOR FUSE BOX

If you decide to tow your car with all
f our wheels on the ground, make
sure you use a properly-designed and
attached tow bar. Prepare the car for
towing as described above, and leave
the ignition switch in Accessory (I)
so the steering wheel does not lock.
Make sure the radio and any items
plugged into the accessory power
socket are turned of f so they do not
rundownthebattery.
Emergency T owing
T aking Care of t he Unexpect ed329
The steering system can be damaged if
the steering wheel is locked. Leave the
ignition switch in Accessory (I), and
make sure the steering wheel turns
f reely bef ore you begin towing.Trying to lif t or tow your car by the
bumpers will cause serious damage.
The bumpers are not designed to
support the car’s weight.

Thediagramsinthissectiongive
you the dimensions and capacities of
your Acura, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your car’s tires and
emissions control systems.................
Identif ication Numbers . 332
................................
Specif ications .334
DOT Tire Quality Grading .............................
(U.S.Cars) .337
.................................
Treadwear .337
......................................
Traction .337
.............................
Temperature .338
...........................
Tire Inf ormation .339 .........................
Oxygenated Fuels .340
......
Driving in Foreign Countries . 341
.......................
Emissions Controls .342
.....................
The Clean Air Act .342
Crankcase Emissions Control ....................................
System .342
Evaporative Emissions Control ....................................
System .342
Onboard Ref ueling Vapor ................................
Recovery .342
...
Exhaust Emissions Controls . 343
....................
PGM-FI System .343
Ignition Timing Control ................................
System .343
Three Way Catalytic ...........................
Converter .343
....................
Replacement Parts . 343
..
Three Way Catalytic Converter . 344
..............
State Emissions Testing . 345
T echnical Inf ormat ion
T echnical Inf ormation331

The emissions control systems are
covered by warranties separate from
the rest of your car. Read your
warranty manual f or more informa-
tion. The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Acura replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your car.
The exhaust emissions controls
include three systems: PGM-FI,
Ignition Timing Control, and Three
Way Catalytic Converter. These
three systems work together to
control the engine’s combustion and
minimize the amount of HC, CO, and
NOx that comes out the tailpipe. The
exhaust emissions control systems
are separate from the crankcase and
evaporative emissions control
systems.
The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: Air Intake,
Engine Control, and Fuel Control.
The Engine Control Module (ECM)
or the Powertrain Control Module
(PCM) uses various sensors to
determine how much air is going
into the engine. It then controls how
much f uel to inject under all operat-
ing conditions. This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
2
2
Replacement Parts
Exhaust Emissions Controls
Emissions Cont rols
T echnical Inf ormation
PGM-FI Syst em Ignit ion T iming Cont rol Syst em
Three Way Catalytic Converter
343

CONT INUED
...
Accessories and Modif ications . 191
................................
Accessories .191
.
Additional Safety Precautions . 192
............................
Modif ications .192
ACCESSORY (Ignition Key .......................................
Position) .81
.............
Accessory Power Socket . 109
....................
Additives, Engine Oil . 246
.....................................
Airbag (SRS) .9
.....................
Air Cleaner Element .261
............................
Air Conditioning .115
..............................
Maintenance .269
.........................................
Usage .115
.......................
Air Pressure, Tires .273
.......................
Alcohol in Gasoline .340
......................................
Antif reeze .249
Anti-lock Brakes (ABS) ................................
Description .213
...............................
Indicator .61, 214
...................................
Operation .213
.
Anti-thef t Steering Column Lock . 80
..........................
Appearance Care .295
..........................................
Armrest .105
........................
Audio System .129, 148 .............
Automatic Speed Control . 174
..............
Automatic Transmission . 204
..........................
Capacity, Fluid .334
...............
Checking Fluid Level . 256
.......................................
Shif ting .204
.
Shif t Lever Position Indicator . 204
................
Shif t Lever Positions . 204
....................
Shif t Lock Release . 210
Battery ......
Charging System Light . 60,318
............................
Jump Starting .312
..............................
Maintenance .265
............................
Specif ications .335
..............................
Bef ore Driving .183
..........................................
Belts, Seat .8
.........................
Beverage Holders .106
...................................
Body Repair .312
Brakes ...........
Anti-lock System (ABS) . 213
.............
Break-in, New Linings . 184
....................
Bulb Replacement .286
...........................................
Fluid .259
.......................................
Parking .104 .........................
System Indicator .60
........................
Wear Indicators .212
.............................
Braking System .213
........................
Break-in, New Car .184
..
Brightness Control, Instruments . 72
........................
Brights, Headlights .70
Bulb Replacement ..........................
Back-up Lights .287
..............................
Brake Lights .286
..............................
Ceiling Light .290
................
Door Courtesy Light . 291
................
Front Parking Lights . 285
.................................
Headlights .282
.........
High-mount Brake Light . 289
...................
License Plate Light . 289
............................
Specif ications .335
...................................
Spotlights .290
...............................
Trunk Light .292
....................
Turn Signal Lights . 284
................
Vanity Mirror Lights . 291
..............................
Bulbs, Halogen .282
Index
A
B
I

................
Gas Station Procedures . 184
Gauges ...
Engine Coolant Temperature . 66
...............................................
Fuel .67
...............................
Speedometer .65
.................................
Tachometer .65
Gearshif t Lever Positions ..........
Automatic Transmission . 204
6-speed Manual .........................
Transmission .201
..............................
Glass Cleaning .300
........................................
Glove Box .89
.............
Halogen Headlight Bulbs . 282
..............
Hazard Warning Flashers . 75
........................................
Headlights .70
........................................
Aiming .282
..............
Automatic Lighting Off . 71
............
Daytime Running Lights . 72
............
Low Beams, Turning on . 70
.........................
Reminder Chime .70
........
Replacing Halogen Bulbs . 282
...................................
Turning on .70
..............................
Head Restraints .93 .....................
Heating and Cooling .114
...............................
Heated Mirror .103
.............
High Altitude, Starting at . 200
HomeLink Wireless Control ........................................
System .177
.......................
Hood, Opening the .186
...........................
Hydraulic Clutch .260
.................................
Hydroplaning .220
...
Identif ication Number, Vehicle . 332
Ignition ..............................................
Keys .77
...........................................
Switch .80
............
Timing Control System . 343
........................
Immobilizer System .79
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 59
...............................
Inf ant Restraint .30
......................................
Inf ant Seats .30
..........
Tether Anchorage Points . 39
...................
Inf lation, Proper Tire . 273
.................................
Inside Mirror .102
.............................
Inspection, Tire .275
............................
Instrument Panel .59 ........
Instrument Panel Brightness . 72
...........................
Interior Cleaning .298
...............................
Interior Lights .110
........................................
Introduction .i
........................
Jacking up the Car .307
.......................................
Jack, Tire .305
................................
Jump Starting .312
..................................................
Keys .77
.......................
Label, Certif ication .332
.................
Lane Change, Signaling . 73
........................
Lap/Shoulder Belts .43
.........................
Leather, Cleaning .299
Lights ....................
Bulb Replacement .282
.......................................
Indicator .59
.........................................
Parking .70
..................................
Turn Signal .73
Index
H IJ
K
L
IV