filler cap AUDI R8 SPYDER 2012 Owners Manual

Instrument s and warnin g/indic ator ligh ts 17
loss of vehicle control and an accident.
Have your vehicle repaired immediately
by your authorized Aud i dealer or a quali­
fied workshop . Drive slowly and avoid
sudden, hard brake applications.
- Canada models: If the brake warn ing
light ., the
DJ warning light and the
ABS wa rning light
rii] come on together,
the rear wheels could lock up first unde r
hard bra king. Rear wheel lock-up can
cause loss of vehicle control and an acci­
dent. Have yo ur vehicle repaired immed i­
ately by your authorized A udi dealer or a
qualified workshop . Drive slowly and
avoid sudden, hard brake applicat ions.
(0 ) Worn brake pads
r;J Check b rak e pads!
If the warning light illum inates, immediately
contact your authorized A udi dealer or quali­
fied workshop to have all brake pads inspect­
ed. On USA models the warning light
r;J
comes on together with the war ning light
- · Both sets of brake pads on an axle
must always be replaced at the same time .
A WARNING
Driv ing with bad brakes can cause a coll i­
sion and serious personal injury .
- If the warning light
r;J and the warning
light -
1l with the message Brake
p ad s!
comes on in the i nstr ument cluster
display, immedia tely contact your au­
tho rized Audi dea le r or qualified work­
shop to have a ll brake pads checked or
replaced if necessary.
EPC Electronic power control
This warning/indicator light monitors the
electronic power control.
The ~ warn ing/ indica to r light ( Elect ronic
P ower Control) illumina tes when you swi tch
on the ignition as a function check.
1) - : USA mod els only
-
(D Tips
If this warn ing/indicator light illuminates
while yo u are driving, then there is a mal­
funct ion in the engine electronics. Have
the malfunct ion corrected as soon as pos­
s ible by your authorized Audi dealer or
qualified workshop .
~ Malfunction Indicator Lamp (MIL)
The Ma lfunction Indicator Lamp (MIL) is pa rt
of the On-Board Diagnostic (OBD II) system.
T he symbo l
lffl ligh ts up when the ignit ion is
turned on and will turn off after the eng ine
has started and has settled at constant id le
speed. This indicates that the MIL is working
proper ly.
T he warning light ill uminates when there is a
malfunction in the engine electronic system .
Contact your authorized Audi dea ler and have
the malfunct ion corrected.
An improperl y clo sed fu el filler cap ma y als o
c a use the MIL light to illuminate
¢ page 166 .
For more information ¢page 22.
!?') Engine speed limitation
Ma ximum 6000 RPM
The eng ine speed is automatically limited to
6000 RPM. This protects the engine from
overheating .
The eng ine speed limitation
(ll deactivates
once the eng ine is no longe r in the cr itica l
temperature range and yo u have re leased the
acce le rator pedal once.
(D Tips
When co ld, the engine speed is limited to
6000 RPM (w ith the
VlO engine) or
7000 R PM (with the VB engine) to protect
the engine. The limit is deactivated once
the oil temperature rises above 140 °F

-Blend must contain not more than 15%
MTBE.
Seasonally adjusted gasoline
Many gasoline grades are blended to perform
espec ially we ll for winter or summer driving.
During seasonal change-over, we suggest that
you fill up at busy gas stat ions where the sea­
sonal adjustment is more likely to be made in
time .
(D Note
-Methanol fuels which do not meet these
requirements may cause corrosion and
damage to plastic and rubber compo­
nents in the fuel system .
- Do not use fue ls that fail to meet the
specified criter ia in this chapter.
- If you are unable to determine whether
or not a particular fue l blend meets the
specifications, ask your service station or
its fuel supp lier.
- Do not use fuel for which the contents
cannot be identified.
- Fuel system damage and performance
problems resulting from the use of fuels
different from those specified are not
the responsibility of Audi and are not
covered under the New Vehicle or the Emission Control System Warranties.
- If you experience a loss of fuel economy
or driveability and performance prob­ l ems due to the use of one of these fuel
blends, we recommend that you switch
to unblended fuel.
Gasoline additives
A major concern among many auto manufac­
turers is carbon deposit build- up caused by
the type of gasoline you use.
Although gasoline grades differ from one manufacturer to another , they have certain
things in common. All gasoline grades contain
substances that can cause deposits to collect
on vital engine parts, such as fuel injectors
and intake valves. Although most gasoline brands include additives to keep engine and
Fuel supply and filling your fuel tank 165
fuel systems clean, they are not equally effec ­
tive .
A udi recommends using TOP TIER Detergent
Gasoline. For more info rmation on TOP TIER
Detergent Gasoline, please go to the official
website (www.toptiergas.com).
After an extended period of using inadeq uate
fuels, built-up carbon deposits can rob yo ur
engine of peak performance.
Q) Note
Damage or malf unct ion due to poor fue l
quality is not covered by the Aud i New Ve­
hicle Limited Warranty.
Fuel tank
Fuel filler neck
The fuel filler neck is located on the right rear
side panel behind the fuel fille r flap.
If the unlocking system should fail, you can
still open the flap manually -for detailed in ­
structions see
¢ page 167.
You can find the fuel tank capacity of your ve­ hicle in
Technical Data ¢ page 217.
The label on the inside of the fuel fi ller flap
tells you the correct fue l for your vehicle. For
more information about fuel specifications,
see
¢ page 164.
Your vehicle fue l tank has an on -board refue l­
ing vapor recovery system. This feature helps
to prevent fuel vapors from escaping from the
tank and polluting the environment while you refuel your vehicle . In order to fill the tank
properly while protecting the environment,
please fo llow this refueling procedure careful­
ly.
_&. WARNING
Under normal operating conditions, never
carry additional fuel containers in your car.
Gas canisters and other containers used to
transport f uel can be dangero us. Such con­
tainers, full or empty, may leak and could
cause a fire in a collision. If you must
•
•

166 Fuel suppl y and filli ng your fuel t ank
transport fue l to use for your lawn mower,
snow blower, etc., be very careful and al­
ways observe local and state laws regard­
ing the use, transportat ion and storage of
such fuel containers. Make certain the con­
tainer meets industry standards (ANSI/
AS TM F852 -86).
(D Note
Never drive your vehicle until the fuel tank
is completely dry. The irregular supply of
fuel can cause misfir ing. Gasoline cou ld
e nte r into the exhaust system and damage
the cata lytic conve rter.
Refueling
Fig. 133 D river 's doo r: Unlocki ng fuel filler flap
Fig. 134 Fuel cap hooked on the opened fuel filler flap
When adding fuel, the ignition and any cellu­
lar phones in the vehicle must be sw itched
off .
Tak ing th e fuel cap off
• To open the fuel filler flap, press the button
9fig. 133.
• Unscrew fuel filler cap counter-clockwise
and hang it on the fuel filler flap ¢
fig. 134 .
Refueling procedure
• Insert the f uel nozzle from the gasoline
pump into the fuel fi ller neck as far as it wi ll
go .
• Select a med ium refueling rate so that the
nozzle switches off automatically when the
tank is full.
Putting th e fu el cap bac k on
• After fi lling your tank, twist the fuel filler
cap clockwise until you hear a definite click.
• Close the fue l filler flap.
T o avoid fuel spilling or evaporating from the
fuel tank always close fuel filler cap properly and completely. An improperly closed fuel fi ll­
er cap may also cause the MIL lamp¢
page 22
to come on.
A WARNING
Improper refue ling or handling of fuel can
cause fire, explosion and severe burns.
- Fuel is highly flammable and can cause
severe burns and other injuries.
- Fai lure to shut the engine off while refu­
eling and/or to insert the pump nozzle
fully into the fuel filler neck could cause
fuel to spray out of filler neck or to ove r­
flow. F ue l spray and overflowing fuel can
cause a fire.
- Never use a ce llular telephone while re­
fue ling. The electromagnet ic rad iat io n
can cause spa rks that can igni te fuel va­
pors and cause a fire.
- Never get back into your vehicle whi le re­
fue ling.
If in exceptio nal circumstances
you must get back in your vehicle while
ref ueling, make certain that you close
the door and touch metal to discharge
static electricity before touching the fill­
er nozzle again. Static electricity can
cause sparks that can ignite fuel vapors
re leased d uring refueling .
- Never smoke or have an open f lame any­
where in o r near your veh icle when refu­
eling or filling a portable fue l conta iner.

-For your safety, we strongly recommend
that you do not travel with a portable
fuel container in your vehicle. The con­
tainer, full or empty may leak and could
cause a fire , especially in a crash .
-If, under exceptional circumstances, you
must transport a portable fuel container,
please observe the following:
- Never fill a portable fuel container
while it is anywhere in or on the vehicle (for example, in the luggage compart­
ment, or on the trunk) . Static electrici­
t y can build up while filling and can ig­
nite fuel vapors causing a fire .
- Always place a portable fuel container
on the ground before filling .
- Always keep the filler nozzle complete­
ly inside the portable container before
and during filling.
- If filling a portable container made of
metal, the filler nozzle must always be
in contact with the container . This will
help prevent static electricity from dis­
charging and cause a fire.
- Never spill fuel inside the vehicle or
luggage compartment. Fuel vapors are
highly flammable.
- Always observe local and state/provin­
cial laws regarding the use, storage
and transportation of fuel containers
- Make certain the fuel container meets
industry standards (ANSI/ ASTM
F852-86).
(D Note
I f any fuel has spilled onto the car, it
should be removed immediately to prevent
damage to the paint.
@ For the sake of the environment
As soon as the correctly operated nozzle switches off automatically for the first
time, the tank is full. Do not try to add
more fuel because fuel may spill out. In
addition, the expansion space in the fuel
tank will be filled -causing the fuel to
Fuel supply and filling your fuel tank 167
overflow when it becomes warm and pol­
lute the environment.
a) Tips
- Running your engine while refueling may
cause vapors to escape or even fuel to
spill out of the tank. This would then
shut off the fuel nozzle before the tank
is full.
- Do not refuel your vehicle with the igni­
tion switched on. The fuel gauge may
otherwise not indicate the correct fuel
level after refueling .
Unlocking the fuel filler flap
by hand
You can open the fuel filler flap by hand if the
power locking sy stem should fail .
Fig. 135 En gin e compar tment: loo sening the fue l fill er
fl ap cab le
Fig. 136 Engine compar tment: re lea sing the fuel fille r
flap using the emer gen cy re le ase
You can release the fuel filler flap using a red
emergency release loop .
It is located in the
right side of the engine compartment.
.. Open the engine compartment lid.
.. Loosen the fuel filler flap cable from its
mount @ on the crossmember
~ fig. 135 . liJJ,,

1 7 0 Che cking and filling
(D Note
When adding fluids, a lways make sure that
they are poured into the proper container or filler opening, otherwise serious dam­
age to veh icle systems will occur.
@ For the sake of the environment
To detect leaks in time, inspect the vehicle
floor pan from underneath regu larly . If
you see spots from oil or other vehicle flu­ ids, have your vehicle inspected by an au­
thorized Audi dealer.
Releasing the engine compartment lid
The engine compartment lid is released from
inside the vehicle .
Fig. 137 Driver's side: releasing t he engine co mpart ­
ment lid
Requirement : The ignition must be switched
on.
... Make sure the rear spoiler is retracted
¢page 144 .
... Pull the button @. The eng ine compart­
ment lid opens slightly .
... Open the engine compartment lid
c> ,& .
A WARNING
-
Hot engine coo lant can burn you . To re­
duce the risk of being bu rned, never open
the engine compartment lid if yo u see or
hear steam or coolant escaping from the
eng ine compartment. Wait until no steam
or coolant can be seen or heard before
carefully opening the engine compartment
lid.
(D Note
To prevent damage to the vehicle, on ly
open the engine compartment lid when
the convert ible top storage bay lid is
closed.
(D Tips
An emergency re lease can be used if the
engine compartment lid cannot be re­
leased with the button
® ¢ page 171.
Closing the engine compartment lid
... Make sure that the rear spoiler is retracted
Qpage 144.
.,. Pull the eng ine compartment lid down unti l
the pressure from the struts is reduced .
... Press the engine compartment lid closed
Q&. .
A WARNING
A engine compartment lid that is not com­
plete ly latched could fly up and b lock your
view wh ile driving.
- When you close the engine compartment
lid, check it to make sure the safety catch
has properly engaged. The engine com­
partment lid should be flush with the
surrounding vehicle body parts.
- If you notice while driving that the en­
gine compartment lid is not secured
properly, stop at once and close it.

Engine compartment lid emergency
release
The emergency release loop is located under
the right trim panel near the front passenger
seat.
F ig . 138 Front pas se n ge r footwe ll: emer gen cy re lease
l oo p
Engine compartment
Checkin g and fillin g 171
.. Make su re the rear spoiler is retracted
¢ page 144 .
.. Pull the loop forward to release the engine
compartment lid . The engine compartment
lid opens sligh tly.
.. Open the engine compartment lid¢.&.
in
Releasing the engine compartment lid on
page 170.
(D Note
To prevent damage to the vehicle, only
open the eng ine compartment lid when
the convertible top storage bay lid is
closed .
Th es e ar e th e most important it ems that you can ch eck.
Fig. 139 Ty pical layout for containers , en gin e oil dipst ick and eng ine o il filler cap
(D Power steering fluid reservoir
(@) ... .. .... .... ... ...... .
@ Eng ine oi l filler cap ('l=r.) .. ...
® Engin e oi l dipstick
146
174
174
A WARNING
Before you check anything in the engine
compartment, always read and heed all
WARNINGS ¢.&. in Working in the engine
compartment on page 169 .
-
{!) Tips
The coolant expansion tank is located un­
der the convertible top storage bay lid
¢ page 177.

226 Index
Eng ine
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . 17 5
Eng ine compartment lid ... .. .. .... . 170
Starting . . . . . . . . . . . . . . . . . . . . . . 70, 71
Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . 72
E ng ine compartment .. ... .. .. ... ... . 17 1
Safety instructions ..... ... .. .. .... . 169
E ng ine compartment lid
C losing ...... ........... .. .. .... . 170
Release lever .......... .. .. .. .. .. . 170
Eng inecoolantsystem ............... 175
Malfunct io n .................. ..... 15
Tempe ratu re ga uge .................. 9
Eng ine data ........................ 217
E ng ine oil ... .. . .. ..... ... .. .. .... . 17 2
Adding ..... .. .. ..... ... .. .. .... . 174
Additives ... ... . ...... ... .. .. .... . 174
Check ing the eng ine o il level . . . . . . . . . 17 4
Dry sump lubrication ............... 149
Indications and condit ions req uiring ex-
tra check ing . . . . . . . . . . . . . . . . . . . . . . 17 4
o·t t· 1 consump 10n .... ...... .. .. .. .. . 173
O il grades .. .......... ...... ... .. . 172
Specif ication and vi scos ity ... ... .. .. . 17 2
T empe ratu re d ispl ay ................. 8
Eng ine oil level ................. ..... 18
Engine oi l pressure (malfunction) ... .. . . 14
E ng ine o il sensor defective .. .. .. .. .. . . 18
Eng ine speed limitat ion ..... .. .. .... .. 17
E nvi ronment
Cata lytic conve rter ..... ... .. .. .... . 150
Fu el . .. .... ... . ...... ... .. .. .... . 166
Un leaded fuel .............. .. .... . 164
E PC
refer to Electronic power control . . . . . . 17
ESC (Elec tronic S tability Control)
War ning/ indica to r lights ....... .. .... 16
Event Data Recorder ( EDR) ... .... .... . 142
E xha ust tail p ipes
C leaning .... .. .. ..... ... .. .. .... . 15 8
E xp ansion ta nk .. .... ...... .. .. .. .. . 176
E xterior mirrors
Ad justing .. .. . .......... .. .. .... .. 57
o· . 1mming ... ............... ...... .. 56
H eating .. ................. ...... .. 57
F
Fan ... ... .. .... .. ... .. .. ..... ... .. . 67
Fasten ing
Boos ter seats .. .. .. ........ ...... . 137
Co nvertib le child safety seats ........ 136
Infan t se ats ... .. ... .......... .... 135
Flat bed truck ..... .......... ....... 212
Flat tire Changi ng ..... .. .... ...... ... .. .. 206
Floo r ma ts . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Folding top
Care and cleaning . ................. 156
Foot peda ls ..... .. .. ... ..... ... .. .. . 96
F o r th e sake of the envi ronment
Gasoline fumes and the e nvir onme nt .. 166
L etting your eng ine warm up . ... .. .. . 71
Ref ueling ..... .. .. ... ..... ... .. .. 166
Front a irbags
Des cription .. .. .. ... .......... .. .. 113
How they wor k ................ .... 118
Frontal collis io ns and the laws of phys ics 103
Front lid
Emergency release .. ... ..... ... .. .. . 37
light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Power locking system .......... ..... 37
Trunk escape handle ... ....... ... .. 203
F ront passenger
refer to Seating position . . . . . . . . . 92, 93
F ron t seats . . . . . . . . . . . . . . . . . . . . . . . . . 59
Childrest rain tsinthefrontseat ......
111
Front towing loop .................. . 212
Fuel Additives ......................... 164
B lended gaso line .............. .... 164
Current fuel mileage ................ 24
Filler neck ... .. .. .. ... ....... ... .. 16S
Fuel supply too low . . . . . . . . . . . . . . . . . 18
Gasoli ne addit ives ................ . 165
O ctane rat ing .. .. ... .......... .... 164
Recommendation .............. .. .. 164
Ref ueling ..... .. ... .. ..... .... . .. 166
Reserve ... .... .. .. ... ..... ... .. .. . 10
Tank capac ity .... ... .. ..... ... .. .. 217
Unlocking the fuel fi ller flap by hand .. 167
F uel gauge . .. .. .. ............. .... . 10
Fuel range . . . . . . . . . . . . . . . . . . . . . . . . . . 24

230 Index
Safety belt position Safety belts worn by pregnant women 106
Safety belt pretens io ner
Service and disposal .... .. .. .. .. .. . 107
Safety belts Cleaning . .. .......... ...... ... .. . 162
Danger to passengers who do not wear a
safety belt ............ .. .. .. .. .. . 104
F astening .... ........... .. .. .... . 104
General notes ............ .. .. .. .. . 101
I mproperly worn .......... ... .... . 106
Not worn . . . . . . . . . . . . . . . . . . . . . . . . 104
Pretensioners ................ .... . 107
Safety belt position . . . . . . . . . . . . . . . . 105
Safety instructions . . . . . . . . . . . . . . . . . 102
Securing child safety seats ....... .. . 138
Special cons iderations for pregnant
women .. .. ................ ... ... 106
Unfasten ing ........... .. .. .. .. .. . 106
Warn ing/ indicato r light ...... .. .... . 101
Why you must wear them .. .. .. .. .. . 102
Worn properly ............ ... .... . 102
Safety belt warn ing light ........ .. .. .. 14
Safety compliance sticker ..... .. .. .. . 215
Safety equipment ........ .. .. .. .. .. .. 91
Safety features for occupant restraint and protection . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Safety guidelines Seat adjustment . . . . . . . . . . . . . . . . . . . . 59
Safety instructions For using chi ld safety seats .......... 133
F or using safety belts .............. 102
Monitoring the Advanced Airbag Sys-
tem ... .. ................. .. .... . 122
Seat adjustment Driver's seat . . . . . . . . . . . . . . . . . . . . . . . 59
Fr ont passenger's seat . . . . . . . . . . . . . . . 60
Front seats . . . . . . . . . . . . . . . . . . . . . . . . 59
Head restraints . . . . . . . . . . . . . . . . . . . . 94
Power seats . . . . . . . . . . . . . . . . . . . . . . . 60
Safety guidelines ..... .... .. .. .. .. .. 59
Seating capacity ............ ... .... . 101
Seating position
Driver . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Fr ont passenger . . . . . . . . . . . . . . . . . . . . 93
I ncorrect seat position . . . . . . . . . . . . . . . 95 Seats
Number of seats
101
Selector lever
Defective ... .. .. ............. .. .. . 19
Serv ice
Airbag system ... ..... ........... . 122
Service and disposal Safety be lt pretensioner ........ .... 107
Serv ice interval display . . . . . . . . . . . . . . . . 22
Service position for windshield wipers .. . 55
Set menu ....... .. ................ .. 26
Setting the t ime ... ... .......... .. .. .. 9
Side airbags Descrip tion .... .. ... .......... .. .. 127
How they work . .. .......... ...... . 128
Side marker lights ................. .. 49
Snow cha ins .. .. . .. ............ .. .. 198
Socket . .... .... ................... . 62
Sound system display ................. 21
Sources of information about child re-
stra ints and their use . ........... .. .. 141
Speedometer . . . . . . . . . . . . . . . . . . . . . . . 10
Speed rating letter code .............. 194
Speed warning system . . . . . . . . . . . . . . . . 29
Spoi ler ............................ 144
Starting on hills
Hill hold assist ... ............. .... . 73
Starting the engine . . . . . . . . . . . . . . . . . . 70
Steering column Adjusting ..... .. ............. .... . 70
Locking the steering . . . . . . . . . . . . . . . . 70
Steps for determining correct load limit . 191
Stopping the eng ine ..... ........... .. 72
Storage ... ..... .. .. .............. .. 62
Sun visors .. .. .. .. .... ......... .... . 53
Symbols Red symbols in the center display ...... 11
Yellow symbols in the center display .. . 12
also refer to Warning/Indicator lights .. 11
T
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Tank flap Unlocking the fuel filler flap by hand .. 167
T echnical modifications ........ .. .. .. 221