check engine BUICK REGAL 2003 Service Manual

75,000 Miles (125 000 km)
❑Inspect engine air cleanerlter. If necessary, replace
thelter. If vehicle is driven in dusty/dirty conditions,
inspectlter at every engine oil change. See
Engine Air Cleaner/Filter on page 5-18for more
information.An Emission Control Service. (See
footnote†.)
❑Replace passenger compartment airlter. If you
drive regularly under dusty conditions, thelter
may require replacement more often.
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
82,500 Miles (137 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
90,000 Miles (150 000 km)
❑Replace passenger compartment airlter. If you
drive regularly under dusty conditions, thelter
may require replacement more often.
❑Replace engine air cleanerlter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service.
❑For supercharged engines only: Check the
supercharger oil level and add the proper
supercharger oil as needed (or every 36 months,
whichever occursrst). SeePart D: Recommended
Fluids and Lubricants on page 6-16.An Emission
Control Service. (See footnote†.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
97,500 Miles (162 500 km)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-59for proper rotation pattern and additional
information.(See footnote @.) (See footnote +.)
6-8
2003 - Regal OM

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals specied to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever anyuids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuelll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-13for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOL®
coolant mixture if necessary. SeeEngine Coolant
on page 5-22for further details.
Windshield Washer Fluid Level Check
Check the windshield washeruid level in the windshield
washer tank and add the properuid if necessary.
SeeWindshield Washer Fluid on page 5-38for further
details.
At Least Once a Month
Tire Inflation Check
Make sure tires are inated to the correct pressures.
Don’t forget to check your spare tire. SeeTires on
page 5-56for further details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every 50 hours of tape play. SeeAudio System(s)
on page 3-44for further details.
6-10
2003 - Regal OM

Starter Switch Check
{CAUTION:
When you are doing this check, the vehicle
could move suddenly. If it does, you or others
could be injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake and the regular
brake. SeeParking Brake on page 2-24if
necessary.
Do not use the accelerator pedal, and be ready to
turn off the engine immediately if it starts.
3. Try to start the engine in each gear. The starter
should work only in PARK (P) or NEUTRAL (N).
If the starter works in any other position, your
vehicle needs service.
Automatic Transaxle Shift Lock Control
System Check
{CAUTION:
When you are doing this check, the vehicle
could move suddenly. If it does, you or others
could be injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a level
surface.
2. Firmly apply the parking brake. SeeParking Brake
on page 2-24if necessary.
Be ready to apply the regular brake immediately if
the vehicle begins to move.
3. With the engine off, turn the key to the RUN
position, but don’t start the engine. Without applying
the regular brake, try to move the shift lever out
of PARK (P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle needs service.
6-12
2003 - Regal OM

Ignition Transaxle Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.
The key should turn to LOCK only when the
shift lever is in PARK (P).
The key should come out only in LOCK.
Parking Brake and Automatic Transaxle
Park (P) Mechanism Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With
the engine running and transaxle in NEUTRAL (N),
slowly remove foot pressure from the regular
brake pedal. Do this until the vehicle is held by the
parking brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to PARK (P). Then
release the parking brake followed by the regular
brake.
Underbody Flushing Service
At least every spring, use plain water toush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-13
2003 - Regal OM

Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
ttings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
Throttle System Inspection
Inspect the throttle system for interference or binding,
and for damaged or missing parts. Replace parts
as needed. Replace any components that have high
effort or excessive wear. Do not lubricate accelerator
and cruise control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chang, etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake parts,
including calipers, parking brake, etc. Check parking
brake adjustment. You may need to have your brakes
inspected more often if your driving habits or
conditions result in frequent braking.
6-15
2003 - Regal OM

A
Accessory Power Outlets.................................3-15
Activating the Theft-Deterrent Feature................3-55
Adding Washer Fluid.......................................5-38
Additional Program Information........................... 7-9
Additives, Fuel................................................. 5-5
Add-On Electrical Equipment............................5-86
Adjusting the Speakers (Balance/Fade)......3-47, 3-51
Air Bag
Readiness Light..........................................3-30
Air Bag Systems.............................................1-46
How Does an Air Bag Restrain?....................1-52
Servicing Your Air Bag-Equipped Vehicle.........1-54
What Makes an Air Bag Inflate?....................1-51
What Will You See After an Air Bag Inflates?......1-52
When Should an Air Bag Inflate?...................1-51
Where Are the Air Bags?..............................1-49
Air Cleaner/Filter, Engine.................................5-18
Aluminum or Chrome-Plated Wheels..................5-82
AM ...............................................................3-57
Antenna, Backglass.........................................3-59
Anti-lock Brake System (ABS)............................ 4-7
Anti-Lock Brake, System Warning Light..............3-32
Appearance Care............................................5-77
Care of Safety Belts....................................5-80
Chemical Paint Spotting...............................5-83
Cleaning the Inside of Your Vehicle................5-78Appearance Care (cont.)
Cleaning the Outside of Your Vehicle..............5-80
Finish Damage............................................5-83
GM Vehicle Care/Appearance Materials..........5-84
Sheet Metal Damage...................................5-83
Underbody Maintenance...............................5-83
Weatherstrips..............................................5-80
Ashtrays........................................................3-17
Audio System(s).............................................3-44
Audio Steering Wheel Controls......................3-57
Backglass Antenna......................................3-59
Care of Your Cassette Tape Player
................3-58
Care of Your CD Player
...............................3-59
Care of Your CDs
........................................3-59
Radio with Cassette
.....................................3-45
Radio with Cassette and CD
.........................3-49
Setting the Time
..........................................3-45
Theft-Deterrent Feature
................................3-55
Understanding Radio Reception
.....................3-57
Automatic Operation
........................................3-20
Automatic Transaxle
Fluid
..........................................................5-20
Operation
...................................................2-21
Automatic Transaxle Check
..............................6-11
Automatic Transaxle Shift Lock Control
System Check
.............................................6-12
Auxiliary Power Connection (Power Drop)
...........3-16
1
2003 - Regal OM

Center High-Mounted Stoplamp (CHMSL)...........5-52
Center Passenger Position, Safety Belts.............1-20
Chains, Tires..................................................5-65
Charging System Light....................................3-31
Check
Engine Light...............................................3-35
Checking Coolant............................................5-23
Checking Engine Oil........................................5-13
Checking Things Under the Hood....................... 5-8
Checking Your Restraint Systems......................1-54
Chemical Paint Spotting...................................5-83
Child Restraints
Child Restraint Systems...............................1-32
Infants and Young Children...........................1-29
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-38
Older Children.............................................1-27
Securing a Child Restraint Designed for the
LATCH System........................................1-40
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-42
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-40
Securing a Child Restraint in the Right Front
Seat Position...........................................1-44
Top Strap...................................................1-36
Top Strap Anchor Location............................1-37
Where to Put the Restraint...........................1-35Cigarette Lighter
.............................................3-17
Cleaning
Inside of Your Vehicle
..................................5-78
Outside of Your Vehicle
................................5-80
Underbody Maintenance
...............................5-83
Weatherstrips
..............................................5-80
Cleaning Exterior Lamps/Lenses
.......................5-81
Climate Control System
Air Filter, Passenger Compartment
.................3-24
Dual
..........................................................3-17
Dual Automatic
............................................3-20
Outlet Adjustment
........................................3-24
Compact Disc Messages
..................................3-54
Compact Spare Tire
........................................5-77
Control Buttons
...............................................3-43
Control of a Vehicle
.......................................... 4-5
Convenience Net
............................................2-36
Coolant
Engine Temperature Gage
............................3-34
Engine Temperature Warning Light
.................3-34
Heater, Engine
............................................2-20
Cooling System
..............................................5-28
Cornering Lamps
............................................3-13
Courtesy Lamps
.............................................3-13
Cruise Control
.................................................. 3-8
Cruise Control Light
........................................3-40
3
2003 - Regal OM

E
Electrical System
Add-On Equipment......................................5-86
Fuses and Circuit Breakers...........................5-87
Headlamp Wiring.........................................5-86
Power Windows and Other Power Options......5-86
Windshield Wiper Fuses...............................5-86
Emergency Trunk Release Handle.....................2-13
Emissions Inspection and Maintenance
Programs...................................................3-37
Engine
Air Cleaner/Filter.........................................5-18
Battery.......................................................5-42
Change Engine Oil Light...............................3-39
Check and Service Engine Soon Light............3-35
Compartment Overview................................5-10
Coolant......................................................5-22
Coolant Heater............................................2-20
Coolant Temperature Gage...........................3-34
Coolant Temperature Warning Light................3-34
Cooling System Inspection............................6-15
Exhaust
.....................................................2-29
Oil
.............................................................5-13
Overheating
................................................5-25
Starting
......................................................2-19
Supercharger Oil
.........................................5-18
Engine Coolant Level Check
.............................6-10Engine Cooling When Trailer Towing..................4-41
Engine Oil Additives........................................5-16
Engine Oil Level Check...................................6-10
Entry Lighting.................................................3-13
Express-Down Window....................................2-15
Extender, Safety Belt.......................................1-26
Exterior Lamps...............................................3-10
F
Fabric/Carpet.................................................5-78
Filter
Engine Air Cleaner......................................5-18
Finding a Station....................................3-46, 3-50
Finish Care....................................................5-81
Finish Damage...............................................5-83
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-66
Flat Tire, Changing.........................................5-66
Fluid
Automatic Transaxle.....................................5-20
Power Steering...........................................5-36
Windshield Washer......................................5-38
FM ...............................................................3-57
Fog Lamps ....................................................3-13
Folding Rear Seat............................................ 1-6
Following Distance..........................................4-39
Footnotes........................................................ 6-5
5
2003 - Regal OM

Fuel............................................................... 5-4
Additives...................................................... 5-5
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-8
Filling Your Tank........................................... 5-6
Fuels in Foreign Countries.............................. 5-6
Gage .........................................................3-41
Gasoline Octane........................................... 5-4
Gasoline Specifications.................................. 5-5
Low Warning Light.......................................3-42
System Inspection.......................................6-15
Full-Range Traction Control System..................... 4-9
Fuses
Fuses and Circuit Breakers...........................5-87
Windshield Wiper.........................................5-86
G
Gage
Engine Coolant Temperature.........................3-34
Fuel..........................................................3-41
Speedometer..............................................3-28
Tachometer.................................................3-29
Gasoline
Octane........................................................ 5-4
Specifications............................................... 5-5Glass Surfaces...............................................5-80
Glove Box.....................................................2-35
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-4
Head Restraints............................................... 1-5
Headlamp
Aiming .......................................................5-48
Headlamp High/Low-Beam Changer.................... 3-6
Headlamp Wiring
............................................5-86
Headlamps
....................................................5-51
Bulb Replacement
.......................................5-50
Front Turn Signal and Parking Lamps
.............5-52
Halogen Bulbs
............................................5-50
Heated Seats
................................................... 1-3
Highway Hypnosis
...........................................4-24
Hill and Mountain Roads
..................................4-24
Hitches
..........................................................4-38
Hood
Checking Things Under
.................................. 5-8
Release
....................................................... 5-9
Horn
............................................................... 3-5
6
2003 - Regal OM

How to Add Coolant to the Coolant
Recovery Tank............................................5-30
How to Add Coolant to the Radiator..................5-31
How to Add Fluid............................................5-21
How to Check........................................5-20, 5-57
How to Check and Add Oil...............................5-18
How to Check Power Steering Fluid..................5-37
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-11
Hydroplaning..................................................4-20
I
If No Steam Is Coming From Your Engine..........5-27
If Steam Is Coming From Your Engine...............5-26
If the Light Is Flashing.....................................3-36
If the Light Is On Steady.................................3-37
If You Are Stuck in Sand, Mud, Ice or Snow
.......4-30
If You Do Decide To Pull A Trailer
.....................4-36
If You’re Caught in a Blizzard
...........................4-28
Ignition Positions
.............................................2-18
Ignition Transaxle Lock Check
..........................6-13
Illumination on Remote Activation
........................ 2-7
Infants and Young Children, Restraints
...............1-29
Inflation -- Tire Pressure
..................................5-57Inspection
Brake System.............................................6-15
Engine Cooling System................................6-15
Exhaust System..........................................6-14
Fuel System...............................................6-15
Part C - Periodic Maintenance.......................6-14
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-14
Throttle System...........................................6-15
Instrument Panel
Cluster.......................................................3-27
Overview..................................................... 3-2
Instrument Panel Brightness.............................3-13
Instrument Panel Fuse Block............................5-87
Interior Lamps................................................3-13
Interior Plastic Components..............................5-80
J
Jump Starting.................................................5-43
K
Key Lock Cylinders Service..............................6-11
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
7
2003 - Regal OM