air filter CHEVROLET COLORADO 2021 Duramax Diesel Supplement

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
60 Vehicle Care
Caution
If the air cleaner/filter is off, dirt can
easily get into the engine, which could
damage it. Always have the air cleaner/
filter in place when driving.
Cooling System
The cooling system allows the engine to
maintain the correct working temperature.
2.8L 4-Cylinder Engine Pickup Models
See“Cooling System” in the owner’s
manual.
2.8L 4-Cylinder Engine Van Models
1. Coolant Surge Tank
2. Coolant Surge Tank Pressure Cap
3. Engine Cooling Fan (Out of View)
{Warning
An underhood electric fan can start up
even when the engine is not running and
can cause injury. Keep hands, clothing,
and tools away from any underhood
electric fan.
{Warning
Do not touch heater or radiator hoses,
or other engine parts. They can be very
hot and can burn you. Do not run the
engine if there is a leak; all coolant could
leak out. That could cause an engine fire
and can burn you. Fix any leak before
driving the vehicle.
Engine Coolant
The cooling system in the vehicle is
filled with DEX-COOL engine coolant
mixture. See Recommended Fluids and
Lubricants 078 and
Maintenance Schedule 073 or
Maintenance Schedule 077. The following explains the cooling system
and how to add coolant when it is low.
If there is a problem with engine
overheating, see
Engine Overheating 062.
A 50/50 mixture of clean, drinkable water
and DEX-COOL coolant will:
.Give freezing protection down to −37 °C
(−34 °F).
.Give boiling protection up to 129 °C
(265 °F).
.Protect against rust and corrosion.
.Help keep the proper engine temperature.
.Let the warning lights and gauges work
as they should.
What to Use
{Warning
Plain water, or other liquids such as
alcohol, can boil before the proper
coolant mixture will. With plain water or
the wrong mixture, the engine could get
too hot but there would not be an
overheat warning. The engine could catch
fire and you or others could be burned.

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
Vehicle Care 71
FusesUsage
MR-1 Fuel filter heater
MR-2 Diesel exhaust fluid power
MR-3 Diesel exhaust fluid wake up
Relays Usage
MR Rel 1 Fuel filter heater
MR Rel 2 Diesel exhaust fluid power/Wake up
Mega Fuse Holder
To check the fuse release the yellow clamps
on both sides and pull off the cover.
Fuse Usage
1 Starter motor
Appearance Care
Exterior Care
See the owner’s manual for additional
exterior care information.
Caution
Water sprayed into or on the air intake
box in the engine compartment may
damage the air filter or electrical
components. Do not spray water into or
on the air intake box.

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
74 Service and Maintenance
Extended Idle Use
When the vehicle is used in a way that
requires extended idle time, one hour of use
shall be deemed the same as 33 miles. See
Driver Information Center (DIC)010 for
hourmeter.
Required Services Every 12 000 km/
7,500 mi
.Check engine oil level and oil
life percentage. If needed, change engine
oil and filter, and reset oil life system.
See Engine Oil 055 and
Engine Oil Life System 058.
.Check engine coolant level. See Cooling
System 060.
.Visually check for fluid leaks.
.Inspect engine air cleaner filter. See
Engine Air Cleaner/Filter 058.
.Visually inspect fuel system for damage
or leaks.
.Visually inspect exhaust system and
nearby heat shields for loose or damaged
parts.

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
Service and Maintenance 75
Maintenance Schedule Additional
Required Services - Normal12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi 60 000 km/37,500 mi
72 000 km/45,000 mi84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi 120 000 km/75,000 mi 132 000 km/82,500 mi
144 000 km/90,000 mi 156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi 204 000 km/127,500 mi 216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Perform Required Services. Check engine oil level and oil
life percentage. Change engine oil and filter, if needed.@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace engine air cleaner filter. (1)@ @@
Drain and fill engine cooling system. (2)@
Visually inspect accessory drive belts. (3)@
Replace timing belt.@
Replace fuel filter. (Pickup) (4)@@@@
Replace fuel filter. (Van) (4)@@@@@
Footnotes—Maintenance Schedule
Additional Required Services - Normal
(1) Or every four years, whichever comes
first. If driving in dusty conditions, inspect
the filter at each oil change or more often
as needed. See Engine Air Cleaner/Filter
0 58. (2)
Or every five years, whichever comes
first. See Cooling System 060.
(3) Or every 10 years, whichever comes first.
Inspect for fraying, excessive cracking,
or damage; replace, if needed. (4)
Or every two years, or when the
CHANGE FUEL FILTER message in the Driver
Information Center (DIC) comes on,
whichever comes first. The fuel filter may
need to be replaced more often based on
biodiesel usage, driving in climates with
severe dust, off-road driving, or towing a
trailer for extended periods.

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
76 Service and Maintenance
Maintenance Schedule Additional
Required Services - Severe12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi 60 000 km/37,500 mi
72 000 km/45,000 mi84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi 120 000 km/75,000 mi 132 000 km/82,500 mi
144 000 km/90,000 mi 156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi 204 000 km/127,500 mi 216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Perform Required Services. Check engine oil level and oil
life percentage. Change engine oil and filter, if needed.@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace engine air cleaner filter. (1)@ @@
Change automatic transmission fluid and filter.@@@
Drain and fill engine cooling system. (2)@
Visually inspect accessory drive belts. (3)@
Replace timing belt.@
Replace fuel filter. (Pickup) (4)@@@@
Replace fuel filter. (Van) (4)@@@@@
Footnotes—Maintenance Schedule
Additional Required Services - Severe
(1) Or every four years, whichever comes
first. If driving in dusty conditions, inspect
the filter at each oil change or more often
as needed. See Engine Air Cleaner/Filter
0 58. (2)
Or every five years, whichever comes
first. See Cooling System 060.
(3) Or every 10 years, whichever comes first.
Inspect for fraying, excessive cracking,
or damage; replace, if needed. (4)
Or every two years, or when the
CHANGE FUEL FILTER message in the Driver
Information Center (DIC) comes on,
whichever comes first. The fuel filter may
need to be replaced more often based on
biodiesel usage, when driving in climates
with excessive dust, or when off-road driving
or towing a trailer for extended periods.

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
Service and Maintenance 77
Maintenance Schedule
Owner Checks and Services
The service plan for your vehicle is available
in the Warranty Policy and Maintenance
Program.
See the owner’s manual for other services
and intervals that may be required.
At Each Fuel Stop
.Check the engine oil level. SeeEngine Oil
0 55.
Engine Oil Change
When the CHANGE ENGINE OIL SOON
message displays, have the engine oil and
filter changed within the next 1 000 km/
600 mi. If driven under the best conditions,
the engine oil life system may not indicate
the need for vehicle service for up to a year.
The engine oil and filter must be changed at
least once a year and the oil life system
must be reset. Your trained dealer technician can perform this work. If the engine oil life
system is reset accidentally, service the
vehicle within 5 000 km/3,000 mi since the
last service. Reset the oil life system when
the oil is changed. See
Engine Oil Life
System 058.
Extended Idle Use
When the vehicle is used in a way that
requires extended idle time, one hour of use
shall be deemed the same as 33 miles. See
Driver Information Center (DIC) 010 for
hourmeter.
Required Services Every 12 000 km/
7,500 mi
.Check engine oil level and oil
life percentage. If needed, change engine
oil and filter, and reset oil life system.
See Engine Oil 055 and
Engine Oil Life System 058.
.Check engine coolant level. See Cooling
System 060.
.Visually check for fluid leaks.
.Inspect engine air cleaner filter. See
Engine Air Cleaner/Filter 058.
.Visually inspect fuel system for damage
or leaks.
.Visually inspect exhaust system and
nearby heat shields for loose or damaged
parts.

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
Service and Maintenance 79
Maintenance Replacement Parts
Replacement parts identified below by name, part number, or specification can be obtained from your dealer.Part GM Part Number ACDelco Part Number
Engine Air Cleaner/Filter
4-Cylinder Pickup 23248945 A3216C
4-Cylinder Van 84000015 A3221C
Fuel Filter 4-Cylinder Pickup 52100212 TP1007
4-Cylinder Van 84186990 TP1016
Engine Oil Filter 4-Cylinder Pickup 12679114 PF2262G
4-Cylinder Van 12677407 PF2267G
Use only the specified filters.

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
Index 85
IndexA
Accessories and Modifications . . . . . . . . . . . . .52
Air Cleaner/Filter, Engine . . . . . . . . . . . . . . . . . 58
Appearance CareExterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Automatic Transmission Fluid . . . . . . . . . . . . . . . . . . . . . . 58
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
BrakeExhaust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
C
Canadian Vehicle Owners . . . . . . . . . . . . . . . . . . . 1
Capacities and Specifications . . . . . . . . . . . . . . 82
CheckEngine Light (Malfunction Indicator) . . . . . 9
Cleaning Exterior Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Cluster, Instrument . . . . . . . . . . . . . . . . . . . . . . . . 4
Cold Weather Operation . . . . . . . . . . . . . . . . . . .27
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Covers Winter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
D
DieselStarting Your Engine . . . . . . . . . . . . . . . . . . . . . 13
Diesel Exhaust Fluid . . . . . . . . . . . . . . . . . . . . . . .22
Diesel Exhaust Fluid (DEF) Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Diesel Particulate Filter . . . . . . . . . . . . . . . . . . . .19
Drive Belt Routing, Engine . . . . . . . . . . . . . . . . 84
Driver Information Center (DIC) . . . . . . . . . . . 10
E
Electrical System Engine Compartment Fuse Block . . . . . . . . 64
Engine Air Cleaner/Filter . . . . . . . . . . . . . . . . . . . . . . . 58
Check Light (Malfunction Indicator) . . . . . . 9
Compartment Overview . . . . . . . . . . . . . . . . . 53
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . 60
Drive Belt Routing . . . . . . . . . . . . . . . . . . . . . . 84
Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Oil Life System . . . . . . . . . . . . . . . . . . . . . . . . . 58
Oil Pressure Gauge . . . . . . . . . . . . . . . . . . . . . . 8
Overheating . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Starting Your Diesel . . . . . . . . . . . . . . . . . . . . . 13
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Exhaust Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

Chevrolet/GMC 2.8L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-14465442) - 2021 - CRC - 2/3/20
86 Index
Exhaust FluidDiesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
Replacement (Fuel) . . . . . . . . . . . . . . . . . . . . . 30
Filter,
Engine Air Cleaner . . . . . . . . . . . . . . . . . . . . . . 58
Fluid Automatic Transmission . . . . . . . . . . . . . . . . 58
Fuel Additives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Cold Weather Operation . . . . . . . . . . . . . . . . 27
Diesel Engines . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Filling a Portable Fuel Container . . . . . . . . 34
Filling the Tank . . . . . . . . . . . . . . . . . . . . . . . . . 32
Filter Replacement . . . . . . . . . . . . . . . . . . . . . . 30
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Operated Heater (FOH) . . . . . . . . . . . . . . . . . 19
Running out of Fuel . . . . . . . . . . . . . . . . . . . . 30
Top Tier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Water in Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Fuel for Diesel Engines . . . . . . . . . . . . . . . . . . . . .25
Fuses Engine Compartment Fuse Block . . . . . . . . 64
G
Gauges
Engine Oil Pressure . . . . . . . . . . . . . . . . . . . . . . 8
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
General Information
Service and Maintenance . . . . . . . . . . . . . . . 72
H
HeaterEngine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Fuel Operated . . . . . . . . . . . . . . . . . . . . . . . . . . 19
I
Instrument Cluster . . . . . . . . . . . . . . . . . . . . . . . . . 4
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
L
LampsMalfunction Indicator (Check Engine) . . . . 9
Lights Check Engine (Malfunction Indicator) . . . . 9
Diesel Exhaust Fluid (DEF) . . . . . . . . . . . . . . 10
Power Take-off . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Wait to Start . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
M
Maintenance
Records . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
Maintenance Schedule . . . . . . . . . . . . . . . . . 73, 77 Maintenance Schedule (cont'd)
Recommended Fluids and Lubricants . . . . 78
Malfunction Indicator Lamp . . . . . . . . . . . . . . . . 9
O
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Engine Oil Life System . . . . . . . . . . . . . . . . . . 58
Engine Oil Pressure Gauge . . . . . . . . . . . . . . . 8
Overheating, Engine . . . . . . . . . . . . . . . . . . . . . . 62
P
Parking Over Things That Burn . . . . . . . . . . . . . . . . . . 19
Personalization Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Power Take-Off (PTO) . . . . . . . . . . . . . . . . . . . . . .37
Power Take-Off Light . . . . . . . . . . . . . . . . . . . . . 10
R
Recommended Fluids and Lubricants . . . . . . 78
Records Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
Replacement Parts Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Routing, Engine Drive Belt . . . . . . . . . . . . . . . . 84
Running out of Fuel . . . . . . . . . . . . . . . . . . . . . . 30