CHEVROLET TRACKER 1996 Owners Manual

At Least Twice a Year Automatic Transmission Check
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly.
Look for any other loose or damaged
safety belt system parts.
If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have
any torn or frayed safety belts replaced.
Also look for any opened or broken air bag covers, and
have them repaired or replaced.
(The air bag system
does not need regular maintenance.)
Fluid Level Check
Check the transfer case, axle differential(s) and
automatic
or manual transmission fluid levels and add as
needed. See “Transfer Case,” “Axle, Rear,” “Axle,
Front” and “Automatic Transmission” or “Manual
Transmission”
in the Index. A fluid loss in these systems
could indicate a problem. Have the system inspected and
repaired
at once.
Check the transmission fluid level; add if needed. See
“Automatic Transmission”
in the Index. A fluid IOSS may
indicate
a problem. Check the system and repair if needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified
in Part D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all hinges
and latches, including those for the hood, rear
compartment, glove box door, console door and any
folding seat hardware.
Part D tells you what to use.
More frequent lubrication may be required when
exposed
to a corrosive environment.
7-48
ProCarManuals.com

Starter Switch Check Brake-Transmission Shift Interlock (BTSI) Check
(Automatic Transmission)
When
you are doing this check, the vehicle could
move suddenly. If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
2. Firmly apply both the parking brake (see “Parking
Brake” in
the Index if necessary) and the regular brake.
NOTE:
Do not use the accelerator pedal, and be
ready to turn off the engine immediately
if it starts.
3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work only in
PARK
(P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try to
start the engine. The starter should work
only when the clutch
is pushed down all the way to
the floor.
If the starter works when the clutch isn’t
pushed all the way down, your vehicle needs service.
around the vehicle.
When you are doing this check,
the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
I. Before you start, be sure you have enough room around
the vehicle. It should
be parked on a level surface
2. Firmly apply the parking brake (see “Parking Brake”
in the Index
if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the key to the ON position,
but don’t start the engine. Without applying the
regular brake,
try to move the shift lever out of
PARK (P) with normal effort. If the shift lever moves
out of
PARK (P), your vehicle’s BTSI needs service.
7-49
ProCarManuals.com

Steering Column Lock Check
While parked, and with the parking brake set, try to turn
the
key to LOCK in each shift lever position.
With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
With a manual transmission, the key should turn to
LOCK only if you push the key in farther, while
turning it towards
LOCK.
On vehicles with a key release lever, try to turn the key
to LOCK without pressing the lever. The key should
turn to LOCK only when you press the key lever.
On all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
/d CAUTION:
When you are doing this check, your vehicle
could begin to
move. You or others could be
injured and property
could be damaged. Make
sure there
is room in front of your vehicle in case
it begins
to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake: With the engine running
and transmission in NEUTRAL (N), slowly remove
foot pressure from the regular brake pedal.
Do this
until the vehicle is held by the parking brake only.
To check the PARK (P) mechanism’s holding ability:
Shift to
PARK (P). Then release all brakes. If your
vehicle is four-wheel
drive, be sure the transfer case
is not in NEUTRAL (N).
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
7-50
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your
GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found
in a Geo service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front- Wheel-Drive
Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing
parts, signs of
wear, or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system.
Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections, or other conditions which
could cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust”
in
the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
7-51
ProCarManuals.com

Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage or missing parts. Replace parts as
needed. Replace any cables that have high effort
or
excessive wear. Do not lubricate accelerator and cruise
control cables.
Rear Axle (All) and Front Axle
(Four-wheel Drive) Service
Check the gear lubricant level and add if needed. See
“Rear
Axle” and “Four-wheel Drive” in the Index.
A fluid loss may indicate a problem. Check the
system(s), and repair
the system(s) if needed. Refer
to “Scheduled Maintenance Services,” earlier in this
section, to determine when to change the lubricant.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses
for proper hook-up, binding, leaks, cracks,
chafing,
etc. Inspect disc brake pads for wear and rotors
for surface condition.
Also inspect drum brake linings
for wear and cracks. Inspect other brake
parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment.
You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
Clutch System Service
Check clutch pedal free travel and adjust as necessary.
See “Clutch Adjustment”
in the Index.
7-52
ProCarManuals.com

Part D: Recommended Fluids and
Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
USAGE
Engine Oil
Engine Coolant
FLUIDlLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol
of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and good
quality ethylene glycol base
antifreeze
(GM Part No. 1052753
or equivalent) conforming to GM
Specification 1825M
or approved
recycled coolant conforming
to
GM Specification 1825M. See
“Engine Coolant” in
the Index.
USAGE
Hydraulic Brake
System
Parking Brake
Cable Guides
Power Steering
System
Manual
Transmission
(All) and
Transfer Case
(4-Wheel-Drive)
~
Automatic
Transmission
Key Lock
Cylinders
FLUIDlLUBRICANT
Delco Supreme 11 @ Brake Fluid
(GM Part
No. 1052535 or
equivalent DOT-3 brake fluid).
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI Grade 2, Category’ LB
or GC-LB.
DEXR0N’-I11 Automatic
Transmission Fluid.
GM Goodwrench Synthetic
Manual Transmission Gear Oil
(GM Part No. 12346190 - 1 qt.),
Castrol Syntorq@
LT or equivalent
SAE 75W-90 GL-4 gear oil.
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-F‘urpose Lubricant, Superlube@
(GM Part No. 12346241
or equivalent).
7-53
ProCarManuals.com

USAGE
Manual
Transmission
Shift Linkage Clutch Linkage
Pivot Points
Floor Shift
Litikage
Chassis
Lubrication
Zear Axle (All)
md Front Axle
:Four-wheel
Drive)
FLUID/LUBRICANT
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI Grade 2, Category LB
or GC-LB.
Lithium base grease.
Lubriplate Lubricant aerosol
(GM
Part No. 12346293 or equivalent)
OF lubricant meeting requirements
of
NLGI Grade 2 Cat.egory LB or
Chassis lubricant (GM
Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of NLGI Grade 2, Category LB
or GC-LB.
Axle Lubricant (GM Part
No. 12345977) or SAE $OW-90
GL-5 Gear Lubricant.
GC-LB.
USAGE
(GM Part No. 105 15 15) or Washer Solvent
GM Optikleen@ Washer Solvent
Windshield
. FLUINLUBRICANT
Hood Latch
Lubriplate lubricant aerosol (GM
Assembly Pivots, Part No. 12346293 or equivalent)
Spring Anchor
or lubricant meeting requirements
and Release
or GC-LB. Pawl
of NLGI Grade 2, Category LB
Hood and Door Multi-purpose lubricant, Superlube@
Hinges (GM
Part No. 12346241 or
equivalent.
equivalent).
Weatherstrip
Part No. 12345579 or equivalent).
Conditioning Dielectric
Silicone Grease (GM
See “Replacement
Parts” in the Index for recommended
replacement filters, valves and spark
plugs.
7-54
ProCarManuals.com

Part E: Maintenance Record
After the scheduled services are performed, record the Services”
or “Periodic Maintenance” can be added on
date, odometer reading and who performed the service the
following record pages. Also, you should retain
all
in the boxes provided after the maintenance interval. maintenance receipts. Your owner information portfolio
Any additional information from “Owner Checks and is
a convenient place to store them.
Maintenance Record
ODOMETER
DATE MAINTENANCE
PERFORMED
SERVICED
BY READING
L
V.’ .* i ’, ,’ 7-55
ProCarManuals.com

I
Maintenance Record.
7-56
ProCarManuals.com

Maintenance Recora
ODOMETER
DATE MAINTENANCE PERFORMED
SERVICED
BY READING
7-57
ProCarManuals.com