sensor CHRYSLER VOYAGER 1996 Service Manual

FUNCTION
-
-
-
-
-
-
-CIRCUIT
-
-
-
-
-
-
-FUSED IGNITION (ST-RUN)
FUSED IGNITION (RUN)
CCD BUS(+)
CCD BUS(-)
AIRBAG WARNING LAMP DRIVER
GROUNDCAV
1
2
3
4
5
6
7
8
9
10
11
12
13F14 18LG/YL
F23 18 DB/YL
D1 20VT/BR
D2 20WT/BK
R41 18BK/TN
Z2 18BK/LG
7
BLACK
FUNCTION
CIRCUIT
AMBIENT TEMPERATURE SENSOR SIGNAL
SENSOR GROUNDCAV
1
2G31 20VT/LG
G32 20BK/LB
GRAY
21
FUNCTIONCIRCUIT
GROUND
BACK-UP LAMP FEEDCAV
1
2Z1 18BK
L1 18VT/BK
GRAY
21
13
16
21GROUND
BACK-UP LAMP FEED CIRCUIT
Z1 18BK
L1 18VT/BK CAV
2 1
FUNCTION GRAY
AIRBAG
CONTROL
MODULE - C2
ALL WHEEL
DRIVE
SOLENOID - C1
(3.8L ONLY)
AMBIENT AIR
TEMPERATURE
SENSOR (3.8L ONLY) SOLENOID - C2DRIVE ALL WHEEL
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 7
NSGS8007J988W-3

Z1 20BK
L50 18WT/TN 3
61
4
BLACKBLACK
4 1
6 3
L63 18DG/RD
6 5 1Z1 18BK Z1 20BK L50 18WT/TN
L50 18WT/TN L77 20BR/LB L1 20VT/BK L63 18DG/RD L63 18DG/RD
4 3 2 CAV
- CIRCUIT
6 5 1
L77 20BR/LB L1 20VT/BK
4 3
2 CAV
- CIRCUIT
3
61
4
BLACKBLACK
4 1
6 3
Z1 20BK L78 20DG/YL L62 18BR/RD
6 4 1Z1 18WT Z1 20BK L50 18WT/TN L78 18BR
L78 20DG/YL L1 20VT/BK L62 18BR/RD L62 18BR/RD
5 3 2 CAV
- CIRCUIT
6 4 1
L50 18WT/TN L1 20VT/BK
5 3 2 CAV
- CIRCUIT
B99
(TRAILER TOW) (TRAILER TOW)B98 T08
T05
DOOR ACTUATORBLEND
2 1
BACK-UP
SWITCH
BACK-UP LAMP FEED L1 18VT/BK
2F20 20WT* FUSED IGNITION SWITCH OUTPUTFUSED IGNITION SWITCH OUTPUT F20 18WT
1 1
CAV FUNCTION CIRCUIT
* DIESEL FUNCTION
CIRCUIT
BLEND AIR DOOR DRIVER
5 VOLT SUPPLY
BLEND DOOR FEEDBACK SIGNAL
SENSOR GROUND
BLEND AIR DOOR DRIVERCAV
1
2
3
4
5C33 20DB/RD
C26 20PK/DB
C36 20RD/WT
C57 20DB/GY
C34 20DB/WTNATURAL
1 5
8W - 80 - 14 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8014

M20 20BR G75 18TN G10 18LG/RD
G76 18TN/YL V14 18RD/VT G78 18TN/BK G29 20BK/TN P96 20WT/LG G6 20GY V20 20BK/WT V13 18BR/LG G74 18TN/RD G77 18TN/OR
G4 18DB
P97 20WT/DG
P98 20WT/RD
G70 18BR/TN V7 20DG/WT
80 79 78
77
76 75 74 73 72 71
70
69 68 67
66
65
64
63 62 61 60 59 58 57 56 55 54 53
52 51 50 49 48 47
46
45
44
43
42 41 CAV COURTESY LAMP GROUND DRIVER DOOR AJAR SWITCH SENSE SEAT BELT SWITCH SENSE
RIGHT REAR DOOR AJAR SWITCH SENSE WIPER ON/OFF RELAY CONTROL LIFTGATE AJAR SWITCH SENSE WASHER FLUID SWITCH SENSE PASSENGER DOOR SWITCH MUX ENGINE OIL PRESSURE SWITCH SENSE REAR WASHER MOTOR CONTROL REAR WIPER MOTOR CONTROL PASSENGER DOOR AJAR SWITCH SENSE LEFT REAR DOOR AJAR SWITCH SENSE
FUEL LEVEL SENSOR SIGNAL
DRIVER DOOR SWITCH MUX
LIFTGATE LOCK/UNLOCK MUX
HOOD AJAR SWITCH SENSE WIPER PARK SWITCH SENSE
- -
-
-
-
- - -
-
- - - CIRCUIT
- -
-
-
-
- - -
-
- - - FUNCTION
G7 18WT/OR*
V38 20LB/RD*
G18 20PK/BK*
G58 20BK/YL* ENGINE COOLANT TEMPERATURE SENSOR SIGNAL
G55 20OR/BK* ENGINE DISABLE SIGNALPOWER MIRROR FOLD RELAY P171 20VT/WT
P174 20YL/RD POWER MIRROR UNFOLD RELAY
ENGINE SPEED SENSOR SIGNAL K159 20VT/RD*
BODY
CONTROL
MODULE - C1
NATURAL
80 70 60 50
71 61 51 41 L24 20WT/LG**
L193 20OR/WT**
* DIESEL
** GAS
BUILT-UP-EXPORT
VEHICLE SPEED SENSOR SIGNAL
AUTOMATIC HEADLAMP SIGNAL
SPEED CONTROL LAMP DRIVER
COOLANT LEVEL SWITCH SENSE
LOW BEAM RELAY CONTROL
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 15
NSGS8015J988W-3

* EXCEPT BUILT-UP-EXPORTV23 18BRPK
Z1 20BK
L1 20VT/BK
P112 20YL/WT*
P114 20YL/BK*
L24 20WT/LG* L24 20WT/LG* P114 20YL/BK* 34
1 6
34
1 6
EC1 C19
5
64 321 CAV CIRCUIT CIRCUIT
CAV
V23 18BRPK
1
2
3Z1 20BK
L1 20VT/BK
4P112 20YL/WT*
6 5
BLACK
FUNCTION
- -
CENTER DOME LAMP GROUND CENTER DOME LAMP FEEDCIRCUIT
CAV
1
2
M113 20LB/PK
M20 20BR 3 3
1
31RED
31BLACK
L50 20WT/TN Z1 20BK
3 2
1 CAV STOP LAMP SWITCH OUTPUT GROUND
- FUNCTION
- CIRCUIT
K44 18TN/YL K4 18BK/LB K7 18OR
3 2
1 CAV CAMSHAFT POSITION SENSOR SIGNAL
SENSOR GROUND 8 VOLT SUPPLY CIRCUIT
FUNCTION
CENTER DOME
LAMP
CENTER HIGH
MOUNTED STOP
LAMP SENSOR POSITION CAMSHAFT
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 17
NSGS8017J988W-3

31 BLACK
9 8 7 1
25 24
23
1617 10NATURAL
K24 18GY/BK K4 18BK/LB
K7 18OR
3 2 1 CAV CRANKSHAFT POSITION SENSOR SIGNAL
SENSOR GROUND
8 VOLT SUPPLY CIRCUIT
FUNCTION
A10 12RD/DG Z7 12BK
F20 18WT B27 18RD/YL D1 18VT/BR D2 18WT/BK B6 18WT/DB
B2 18YL G19 18LG/OR L50 18WT/TN B8 18RD/DB B4 18LG A20 12RD/DB
Z7 12BK B9 18RD B7 18WT
B3 18LG/DB B1 18YL/DB
25 24 23 22
21 20 19
18 17 16
15 14 13 12 11 10 9 8 7
6 5 4
3 2 1 CAV FUSED B(+)
GROUND FUSED IGNITION (RUN) TRACTION CONTROL SWITCH SENSE CCD BUS (+) CCD BUS (-) RIGHT FRONT WHEEL SPEED SENSOR (-)
RIGHT REAR WHEEL SPEED SENSOR (+) ABS WARNING LAMP DRIVER STOP LAMP SWITCH SENSE LEFT FRONT WHEEL SPEED SENSOR (-) LEFT REAR WHEEL SPEED SENSOR (+) FUSED B(+)
GROUND LEFT FRONT WHEEL SPEED SENSOR (+) RIGHT FRONT WHEEL SPEED SENSOR (+)
LEFT REAR WHEEL SPEED SENSOR (-) RIGHT REAR WHEEL SPEED SENSOR (-)
- - - - - - - FUNCTION
- - - - - - - CIRCUIT
1 2
CRANK CASE
HEATER
(DIESEL)
GROUND Z1 18BK
2
1A141 18DG/WT CAV FUNCTION CIRCUIT
FUEL PUMP RELAY OUTPUT
BRAKE ANTI-LOCK CONTROLLER
SENSOR POSITION CRANKSHAFT
BLACK*
* DIESEL
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 19
NSGS8019J988W-3

CIRCUIT
-
-
-
-
-
-
-
-FUNCTION
-
-
-
-
-
-
-
- CCD BUS(+)
GROUND
GROUND
SCI RECEIVE
SCI TRANSMIT
CCD BUS(-)
SCI RECEIVE (EATX)
FUSED B(+)CAV
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16D1 20VT/BR
Z2 20BK/LG
Z11 20BK/WT
D20 20LG
D21 20PK
D2 20WT/BK
D6 20PK/LB
M1 20PK
18
916
BLACK
CONNECTORDATA LINK
CIRCUIT FUNCTION
GROUND
AUTOMATIC SHUT DOWN RELAY OUTPUT
SENSOR GROUND
HEATED OXYGEN SENSOR 1/2 SIGNALCAV
1
2
3
4Z12 20BK/TN
A142 18DG/OR
K4 20BK/LB
K141 20TN/WT12
34
BLACK
OXYGEN SENSOR DOWNSTREAM HEATED
COURTESY LAMPDRIVER DOORSWITCH ARM/DISARM DRIVER DOOR
2 1BLACK
21
BLACK
Z1 20BK M11 20PK/LB
2 1 CAV GROUND
COURTESY LAMP RELAY OUTPUT FUNCTION CIRCUIT
P97 20WT/DG Z2 20BK/LG
2 1 CAV DRIVER DOOR SWITCH MUX
GROUND FUNCTION CIRCUIT
8W - 80 - 22 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8022

LOCK SWITCH DRIVER DOOR
1
3BLACK
3 2 1Z2 20BK/LG* Z2 20BK/LG P97 20WT/DG*
P97 20WT/DG E2 20OR E2 20OR CAVGROUND DRIVER DOOR SWITCH MUX
PANEL LAMPS FEED CIRCUIT
FUNCTION
DRIVER DOOR
LOCK MOTOR
21BLACKF133 20BR F131 20BK/PK
2 1 CAV LOCK RELAY OUTPUT LEFT FRONT UNLOCK RELAY OUTPUT CIRCUIT
FUNCTION
FUNCTION
CIRCUIT
HEATED SEAT DRIVER
GROUNDCAV
A
BP88 18RD/WT
Z1 18BK
SEAT BACK DRIVER HEATED
FUNCTION CIRCUIT
HEATED SEAT DRIVER
HEATED SEAT DRIVERCAV
P87 18RD/WT
P88 18RD/WT
P89 20BK/RD
Z1 18BK
A
B
C
DRIVER HEATED
SEAT CUSHION
D
HEATED SEAT BACK
GROUND
FUSED B(+) DRIVER HEATED SEAT SWITCH
DSEAT MODULE DRIVER HEATEDC B A
F35 18RD P7 20WT/BK P86 20VT P87 18RD/WT CAV
HEATED SEAT TEMPERATURE SENSOR DRIVER HEATED SEAT SWITCH CIRCUIT FUNCTION
P89 20BK/RD EHEATED SEAT BACK
F
Z1 18BKGROUND
* RKE
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 23
NSGS8023J988W-3

* BUILT-UP-EXPORT
MIRROR - C2 DRIVER POWERMIRROR - C1 DRIVER POWERDRIVER POWER MIRROR FOLD P160 20LB*DRIVER POWER MIRROR UNFOLD P159 20DG* 4
6 5P114 20YL/BK**
POWER MIRROR B(-)
RED564
1 2 3
456
1
2 3BLUE
P65 20DB/YL P69 20WT/RD P64 20YL/OR
3 2
1 CAV DRIVER POWER MIRROR LEFT/RIGHT
DRIVER POWER MIRROR RETURN DRIVER POWER MIRROR UP/DOWN CIRCUIT
FUNCTION
Z1 20BK C16 20LB/YL P73 20YL/PK
P71 20YL P75 20DB/WT
6 5 4
3 2 1 CAV GROUND REAR DEFOGGER LAMP DRIVER DRIVER POWER MIRROR RIGHT/DOWN
DRIVER POWER MIRROR LEFT DRIVER POWER MIRROR UP CIRCUIT
FUNCTION
** EXCEPT BUILT-UP-EXPORT POWER MIRROR B(-) P112 20YL/WTFUSED IGNITION (RUN)-
DSEAT SWITCH DRIVER HEATEDC B A
F20 20WT- F20 20WT P86 20VT CAV
FUSED IGNITION (RUN) HEATED SEAT TEMPERATURE SENSOR CIRCUIT FUNCTION
Z1 18BK EGROUND
F
P7 20WT/BKDRIVER HEATED SEAT BACK
8W - 80 - 24 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8024

12
- -
2
1V20 18RD CAV FUNCTION CIRCUIT
REAR WASHER MOTOR CONTROL BLACK
WIPER DE-ICER-C1ELECTRIC
ELECTRIC
WIPER DE-ICER-C2
BLACK
WIPER DE-ICE SWITCHED GROUND CIRCUIT FUNCTION
CAV
C66 18BK/WT
1
2--
2 1
SENSOR GROUND K4 20BK/LB
2
1K2 20TN/BK CAV FUNCTION CIRCUIT
ENGINE COOLANT TEMPERATURE SENSOR SIGNAL
ENGINE COOLANT TEMPERATURE SENSOR SIGNAL G58 20BK/YL
3ENGINE COOLANT
TEMPERATURE SENSOR
(DIESEL)
1 2
3
BLACK
(GAS) TEMPERATURE SENSORENGINE COOLANT
12BLACK
K2 18TN/BK K4 18BK/LB
2 1 CAV ENGINE COOLANT TEMPERATURE SENSOR SIGNAL SENSOR GROUND CIRCUIT
FUNCTION
PRESSURE SWITCHENGINE OIL
BLACK (2.0L)
1GREEN
2
G6 16GY
2 1 CAV ENGINE OIL PRESSURE SWITCH SENSE
- CIRCUIT
- FUNCTION
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 29
NSGS8029J988W-3

SOLENOID EVAP/PURGE
2
1BLACK
K70 18VT/RD K52 18PK/BK
2 1 CAV EVAP/PURGE CURRENT SENSE
EVAP/PURGE SOLENOID CONTROL CIRCUIT
FUNCTION
TEMPERATURE SENSOREVAPORATOR
CIRCUIT FUNCTION
A/C SWITCH SENSE
SENSOR GROUND CAV
1
2C21 20DB/OR
C57 20DB/GY 1
2
BLACK
(3.3L/ETHANOL)SENSOR FLEXIBLE FUEL
FLEXIBLE FUEL SENSOR SIGNAL SENSOR GROUND
8V SUPPLY
LT. GRAY
1
4
- - 4
K50 18YL/WT 3
FUNCTION
1 CAV
K7 18ORCIRCUIT
2
K4 18BK/LB
(EXCEPT BUILT-UP-EXPORT)DETECTION PUMPEVAP LEAK
LEAK DETECTION PUMP SWITCH SENSE K107 18YL/BK** 4
F87 18WT/BK K106 18WT/DG K107 18DB/WT*
4 3
2 1 CAV FUSED IGNITION SWITCH OUTPUT LEAK DETECTION PUMP SOLENOID CONTROL LEAK DETECTION PUMP SWITCH SENSE
- FUNCTION
- CIRCUIT
GRAY LIGHT
1 1 3
ENGINE SPEED
SENSOR
(DIESEL)
ENGINE SPEED SENSOR SIGNAL K24 20GY/BK
3--ENGINE SPEED RETURN K3 20BK/VT
21
CAV FUNCTION CIRCUIT
* 3.3L/3.8L
** 2.4L 1
8W - 80 - 30 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8030