towing Citroen BERLINGO FIRST 2011.5 1.G Owner's Manual

3CONTENTS
-
110 - 117  AUDIO
RD3 audio system 110
118 - 122  VISUAL INDEX 58 - 63  LIFE ON BOARD
Front fi ttings 58
Courtesy lamps 59
Headlamp adjustment 60
Steering wheel adjustment 60
Lashing rings 61
Rear fi ttings 62
64 - 71  DRIVING
Handbrake 64
ABS and EBFD systems 64
Speed limiter 65
Cruise control 67
Airbags 69
72 - 97  PRACTICAL INFORMATION
Under the bonnet 72
Levels 77
Checks 78
Changing a wheel 79
Changing a bulb 82
Changing a fuse 88
Battery 92
Energy economy mode 92
Fitting audio equipment, speakers 93
Snow screen 94
Towing 95
Towing a trailer 96
Accessories 97
98 - 109  TECHNICAL DATA
Dimensions 98
Engines 102
Light van weights and loads 105
Ludospace weights
and loads 107
Identifi cation features 109

15 FAMILIARISATION
-
REAR FITTINGS



Stowing rings
For greater safety, always en-
sure that the loads transported
are secured fi rmly.



61



1.
Load space cover.

2.
High load retaining net.

3.
Stowing rings.

4.
Side door storage compartment.

5.
Trays between the front and rear
seats.

6.
Seat back storage pockets.



62-63

63 LIFE ON BOARD-
REAR FITTINGS

1. Load-space cover
To install it:


- position the front ends of the load
space cover on its support and
press gently to put it in place,

- unfold the load space cover fully,

- position the rear ends of the load
space cover on its support and
press gently to put it in place.
To remove it:


- unclip the rear ends,

- fold the load space cover fully,

- unclip the front ends and remove
the load space cover.
To store it, fold it like an accordion.
Do not roll it
.
2. High load retaining net
The high load retaining net can be fi t-
ted behind the front or rear seats.
Open the covers A
of the correspond-
ing upper fastenings.
Fit the ends of the metal bar in these
fastenings.
Secure the two net strap hooks be-
hind the front seats, with the rear
seat folded, or in the stowing rings B

on the fl oor.
The rings are located directly below
the corresponding upper fastenings.
Pull the two straps C
taut.
3. Stowing rings

4. Side door storage
compartments

5. Containers between the front
and rear seats

6. Seat back storage pockets

PRACTICAL INFORMATION
94 -
SNOW SCREEN *

The snow screen is installed on the
lower part of the front bumper to pre-
vent the accumulation of snow at the
radiator cooling fan.
Remove the snow screen:


- when the exterior temperature is
higher than 10 °C,

- when towing,

- for speeds higher than 75 mph
(120 km/h).


FITTING



)
Offer up the snow screen facing
the front bumper.

)
Put it in place positioning the lower
clips A
in the bumper.

)
Press the snow screen at each
upper clip B
.



REMOVAL



)
Press the two upper clips B
and
pull the snow screen.


*
As an accessory or according to country.

95 PRACTICAL INFORMATION
-

Without lifting
(four wheels on the ground)
You must always use a towbar.

By lifting
(two wheels only on the ground)
It is preferable to lift the vehicle by
the wheels.

TOWING YOUR VEHICLE


From the front or the rear
Attach the towbar to the towing eye.
Never use the radiator cross-
member.
When towing another vehicle,
it must freewheel.
Place the gearbox in "neutral".
Failure to observe this instruction
may result in damage to certain brak-
ing components and the absence of
braking assistance when the engine
is started again.

PRACTICAL INFORMATION
96 -
TOWING A TRAILER,CARAVAN, BOAT, ETC.
We recommend the use of original
CITROËN towbars and their har-
nesses that have been tested and
approved from the design stage of
your vehicle and that the fi tting of the
towbar is entrusted to a CITROËN
dealer.
If the towbar is not fi tted by a
CITROËN dealer, it is imperative that
it is fi tted using the electrical pre-
equipment installed at the rear of the
vehicle, in accordance with the man-
ufacturer's instructions.
Your vehicle is primarily designed
for transporting people and luggage
but it may also be used for towing a
trailer.
Driving with a trailer subjects the tow-
ing vehicle to more signifi cant stress
and its driver must be particularly
careful.
Air density decreases with altitude,
thus reducing engine performance.
Above 1 000 metres, the maximum
towing load must be reduced by 10 %
and so on for every 1 000 metres of
altitude.

Driving advice


Tyres:
Check the tyre pressures of
the towing vehicle and of the trailer,
observing the recommended pres-
sures.

Cooling:
Towing a trailer on a slope
increases the temperature of the
coolant.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
On the contrary, use a high gear to
lower the engine speed and reduce
your speed.
The maximum towing load on a long
slope depends on the gradient and
the outside temperature.
In all cases, pay attention to the coolant
temperature.
In certain cases of particularly ardu-
ous use (towing the maximum load on
a steep gradient in high temperatures),
switching off the air conditioning permits
the recovery of engine power and there-
fore an increase in the towing capacity.
If the warning light comes on, stop
the vehicle and switch off the engine
as soon as possible.
Distribution of loads:
Distribute the
load in the trailer so that the heaviest
items are as close as possible to the
axle and the nose weight approach-
es the maximum permitted without
exceeding it.

Braking:
Towing increases the braking
distance.

Lights:
Check the electrical signalling
on the trailer.

Side wind:
Take into account the
increased sensitivity to side wind.

105 TECHNICAL DATA
-

Engine


1.4 litre



Gearbox


Manual



Length



L1



Version (kg)


800




●
Kerb weight (in running order)
1 055


●
Gross vehicle weight (GVW)
1 855


●
Gross train weight (GTW)
2 755


●
Unbraked trailer
500


●
Braked trailer (within GTW)
900


●
Recommended nose weight
70


●
Recommended weight on roof rack
100
The GTW and towing load values indicated are valid up to a maximum altitude of 1 000 metres; the towing load mentioned
must be reduced by 10 % for each additional 1 000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle in order to protect the engine; when
the ambient temperature is above 37°C, limit the towed load.
PETROL WEIGHTS AND TOWED LOADS (IN KG) FOR LIGHT VANS

TECHNICAL DATA
106 -
DIESEL WEIGHTS AND LOADS (IN KG) FOR LIGHT VANS


Engines


1.6 litre Turbo HDi 75



1.6 litre Turbo HDi 92



1.9 litre



Gearboxes


Manual



Manual



Manual



Length


L1



L2



L1



L2



L1



L2



Version (kg)


800



1 000



800



1 000



800



1 000




●
Kerb weight (in running order)
1 112
1 143
1 112
1 143
1 206
1 146


●
Gross vehicle weight (GVW)
1 915
2 150
1 915
2 150
1 955
2 180


●
Gross train weight (GTW)
2 715
2 950
2 715
2 950
3 055
3 005


●
Unbraked trailer
500

585
500
585
500
585


●
Braked trailer (within GTW)
800
800
800
800
1 100
825


●
Recommended nose weight
70
75
70
75
70
75



●
Recommended weight on roof rack

111
111
100
-
The GTW and towing load values indicated are valid up to a maximum altitude of 1 000 metres; the towing load mentioned
must be reduced by 10 % for each additional 1 000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle in order to protect the engine; when
the ambient temperature is above 37°C, limit the towed load.

107-

WEIGHTS AND TOWING LOADS (IN KG)
FOR PETROL LUDOSPACE 4/5 SEAT VERSIONS

Engines


1.4 litre



1.6 litre



Gearboxes


Manual



Manual



Length


L1



L2



Version (kg)


-



1 000




●
Kerb weight (in running order)
1 197
1 207


●
Gross vehicle weight (GVW)
1 780
2 170


●
Gross train weight (GTW)
2 680
2 880


●
Unbraked trailer
540
585


●
Braked trailer (within GTW)
900
710


●
Recommended nose weight
70
75


●
Recommended weight on roof rack
100
100
The GTW and towing load values indicated are valid up to a maximum altitude of 1 000 metres; the towing load mentioned
must be reduced by 10 % for each additional 1 000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle in order to protect the engine; when
the exterior temperature is above 37 °C, limit the towed load.

TECHNICAL DATA
108 -

WEIGHTS AND TOWING LOADS (IN KG)
FOR DIESEL LUDOSPACE 4/5 SEAT VERSIONS

Engines


1.6 litre Turbo HDi 75



1.6 litre Turbo HDi
92



1.9 litre



Gearboxes


Manual



Manual



Manual



Length


L1



L2



L1



L2



L1



L2



Version (kg)


-



1 000



-



1 000



-



1 000




●
Kerb weight (in running order)
1 200
1 244
1 200
1 244
1 240
1 244


●
Gross vehicle weight (GVW)
1 735
2 170
1 735
2 170
1 840
2 210


●
Gross train weight (GTW)
2 535
2 970
2 535
2 970
2 940
3 005


●
Unbraked trailer
540
585
540
585
500
585


●
Braked trailer (within GTW)
1 100
1 100
1 100
1 100
1 100
795


●
Recommended nose weight
70
75
70
75
70
75


●
Recommended weight on roof rack
70
70
100
The GTW and towing load values indicated are valid up to a maximum altitude of 1 000 metres; the towing load mentioned
must be reduced by 10 % for each additional 1 000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle in order to protect the engine; when
the exterior temperature is above 37 °C, limit the towed load.