gearbox Citroen DS4 RHD 2013.5 1.G Owner's Guide

243Checks









Particle emission filter (Diesel)

On a new vehicle, the first operations of
regeneration of the particle emissions
filter may be accompanied by the smell
of "burning", which is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration. This does
not affect the behaviour of the vehicle
or the environment.







Manual gearbox

The gearbox does not require any
maintenance (no oil change).
Refer to the maintenance and
warranty guide for the details of the
level checking inter val for this component.
According to your version of instrument panel, the start of
saturation of the par ticle emissions filter is indicated by:






Electronic gearbox

The gearbox does not require any
maintenance (no oil change).
Refer to the maintenance and
warranty guide for details of the
checking inter val for this component.
-
temporary illumination of the ser vice
warning lamp, accompanied by an
audible signal and a message that
there is a risk of blockage of the
particle emissions filter.




- fixed illumination of the par ticle
emissions filter warning lamp,
accompanied by an audible signal
and a message that there is a risk of
blockage of the particle emissions filter,
or
As soon as the traffic conditions permit,
regenerate the filter by driving at a speed of at
least 40 mph (60 km/h) until the warning lamp
goes off.
If the warning lamp stays on, refer to the
"Additive level" section.






Automatic gearbox

The gearbox does not require any
maintenance (no oil change).
Refer to the maintenance and
warranty guide for details of the level
checking inter val for this component.

Removing a wheel


Parking the vehicle

Immobilise the vehicle where it does
not block traffic: the ground must be
level, stable and non-slippery ground.
Apply the parking brake unless it has
been programmed to automatic mode,
switch off the ignition and engage first
gear * to lock the wheels.
Check that the braking warning lamps
in the instrument panel are on (not
flashing).
The occupants must get out of the
vehicle and wait where they are safe.
If necessary, place a chock under the
wheel diagonally opposite the wheel to
be changed.
Never go underneath a vehicle raised
using a jack; use an axle stand.


List of operations




Remove the chromed bolt cover from each
of the bolts using the tool 3
(according to
equipment).


Fit the security socket 4
on the
wheelbrace 1
to slacken the security bolt.


Slacken the other bolts using the
wheelbrace 1
only.

*
position R
for an electronic gearbox; P
for an
automatic gearbox.

12 V battery

The battery is located under the bonnet.
For access to the (+) terminal:



release the bonnet using the interior lever,
then the exterior safety catch,


raise the bonnet and secure it with its stay,


lift the plastic cover for access to the (+)
terminal.


Access to the battery


After refitting the battery, the Stop &
Start system will only be active after a
continuous period of immobilisation of the
vehicle, a period which depends on the
climatic conditions and the state of charge
of the battery (up to about 8 hours).





The presence of this label, in particular
with the Stop & Start system, indicates
the use of a 12 V lead-acid battery with
special technology and specification;
the involvement of a CITROËN dealer
or a qualified workshop is essential
when replacing or disconnecting the
battery.


Before doing any work

Immobilise the vehicle: apply the
parking brake, put the gearbox in
neutral, then switch off the ignition.
Check that all electrical equipment is
switched off.

Procedure for starting the engine using another
battery or charging a discharged battery.

277Practical information

Some functions are not available if the
battery is not sufficiently charged.
Protect your eyes and face before
handling the battery.
All operations on the battery must be
carried out in a well ventilated area and
away from naked flames and sources
of sparks, so as to avoid the risk of
explosion or fire.
Do not try to charge a frozen battery;
the battery must first be thawed out to
avoid the risk of explosion. If the battery
has been frozen, before charging have
it checked by a CITROËN dealer or
a qualified workshop who will check
that the internal components have not
been damaged and the casing is not
cracked, which could cause a leak of
toxic and corrosive acid.
Do not reverse the polarity and use
only a 12 V charger.
Do not disconnect the terminals while
the engine is running.
Do not charge the batteries without
disconnecting the terminals first.
Wash your hands after wards.

It is advisable to disconnect the battery
if the vehicle is to be left unused for
more than one month.











The batteries contain harmful substances
such as sulphuric acid and lead. They
must be disposed of in accordance
with regulations and must not, in any
circumstances, be discarded with household
waste.
Take used remote control batteries and
vehicle batteries to a special collection point.










Do not push the vehicle to start the
engine if you have an electronic or
automatic gearbox.

281Practical information





Towing the vehicle
Procedure for having your vehicle towed or for towing another vehicle using a removable towing eye.
The towing eye is installed in the boot under
the floor.
To gain access to it:



open the boot,


raise the floor,


secure it by hooking its cord on the hook on
the rear parcel shelf support,


remove the towing eye from the holder.



Access to the tools


General recommendations

Observe the legislation in force in your
country.
Ensure that the weight of the towing
vehicle is higher than that of the towed
vehicle.
The driver must remain at the wheel
of the towed vehicle and must have a
valid driving licence.
When towing a vehicle with all four
wheels on the ground, always use an
approved towing bar; rope and straps
are prohibited.
When towing a vehicle with the engine
off, there is no longer any power
assistance for braking or steering. In the following cases, you must always call
on a professional recovery ser vice:


- vehicle broken down on a motor way or
fast road,

- 4 wheel drive vehicle,

- when it is not possible to put the gearbox
into neutral, unlock the steering, or
release the parking brake,

- towing with only two wheels on the
ground,

- where there is no approved towing bar
available...


On the front bumper, unclip the cover by
pressing at the bottom.


Screw the towing eye in fully.


Install the towing bar.


On the rear bumper, unclip the cover by
pressing at the bottom.


Screw the towing eye in fully.


Install the towing bar.


Switch on the hazard warning lamps on
both vehicles.


Move off gently, drive slowly and for a short
distance.



Towing your vehicle
Towing another vehicle



Place the gear lever in neutral
(position N
on an electronic or
automatic gearbox).
Failure to obser ve this instruction
could result in damage to
certain components (braking,
transmission...) and the absence
of braking assistance the next time
the engine is started.


Unlock the steering by turning the key
in the ignition one notch and release the
parking brake.


Switch on the hazard warning lamps on
both vehicles.


Move off gently, drive slowly and for a short
distance.

MODELS:



ENGINES AND GEARBOXES



Model codes:


NX...


5FS0



5FV8/P



5FMA



5FU8



PETROL ENGINES


VTi 120



THP 155



THP 160



THP 200


Cubic capacity (cc)
1 598
1 598
1 598
1 598
Bore x stroke (mm)
77 x 85.8
77 x 85.8
77 x 85.8
77 x 85.8
Max power * : EU standard (kW)
88
115
120
147
Max power engine speed (rpm)
6 000
6 000
6 000
5 500
Max torque: EU standard (Nm)
160
240
240
275
Max torque engine speed (rpm)
4 250
1 400
1 400
1 700
Fuel
Unleaded
Unleaded
Unleaded

Unleaded
Catalytic conver ter
yes
yes
yes
yes

GEARBOX

Manual
(5-speed)


Electronic gearbox system
(6-speed)

Automatic
(6-speed)
Manual
(6-speed)

OIL CAPACITIES (in litres)




Engine (with filter replacement)
4.2
4.2
4.2
4.2

* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).

291Te c h n i c a l d a t a


WEIGHTS AND TOWED LOADS (in kg)



Petrol engines


VTi 120



THP 155



THP 160



THP 200



Gearboxes


Manual



Electronic



Automatic



Manual



Model codes:
NX...


5FS0



5FV8/P



5FMA



5FU8




- Unladen weight
1 205
1 284
1 363
1 316


- Kerb weight
1 280
1 359
1 438
1 391


- Gross vehicle weight
(GV W)
1 755
1 795
1 835
1 820


- Gross train weight (GTW)
on a 12 % gradient
2 955
3 195
2 635
2 820


- Braked trailer (within the GTW limit)
on a 12 % gradient
1 200
1 400
800
1 000


- Braked trailer * (with load transfer within the
GTW limit)
1 450
1 650
1 000
1 250


- Unbraked trailer
640
680
715
695


- Recommended nose weight
75
75
75
75
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for
each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the per formance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.
*
The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount. Warning:
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

MODELS:



ENGINES AND GEARBOXES



Model codes:
NX...


9HP0



9HR8

9HR8/S



9HR8/PS



RHH8



RHHA



DIESEL ENGINES


HDi 90 PEF



HDi 110 PEF



HDi 160 PEF


Cubic capacity (cc)
1 560
1 560
1 997
Bore x stroke (mm)
75 x 88.3
75 x 88.3
85 x 88
Max power * : EU standard (kW)
68
82
120
Max power engine speed (rpm)
4 000
3 600
4 000
Max torque: EU standard (Nm)
230
270
340
Max torque engine speed (rpm)
1 750
1 750
2 000
Fuel
Diesel
Diesel
Diesel
Catalytic conver ter
yes
yes
Ye s
Particle emissions filter (PEF)
yes
yes
Ye s

GEARBOX

Manual
(5-speed)
Manual
(6-speed)
Electronic
(6-speed)
Manual
(6-speed)
Automatic
(6-speed)

OIL CAPACITIES (in litres)




Engine (with filter replacement)
3.75
3.75
3.75
-

* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).

.../S:
e-HDi model fitted with Stop & Start.

293Te c h n i c a l d a t a


WEIGHTS AND TOWED LOADS (in kg)



Diesel engines


HDi 90 PEF



HDi 110 PEF



e- HDi 110 PEF



HDi 160 PEF



Gearbox


Manual



Manual



Manual



Electronic



Manual



Automatic



Model codes:
NX...


9HP0



9HR8



9HR8/S



9HR8/PS



RHH8



RHHA




- Unladen weight
1 205
1 290
1 295
1 300
1 320
1 430


- Kerb weight
1 280
1 365
1 370
1 375
1 395
1 505


- Gross vehicle weight
(GV W)
1 765
1 805
1 810
1 815
1 880
1 940


- Gross train weight (GTW)
on a 12 % gradient
2 865
3 105
3 110
3 115
3 180
3 140


- Braked trailer (within GTW limit)
on 12 % gradient
1 100
1 300
1 300
1 300
1 300
1 200


- Braked trailer * (with load transfer with
the GTW limit)
1 350
1 550
1 550
1 550
1 550
1 450


- Unbraked trailer
640
680
680
680
695
750


- Recommended nose weight
75
75
75
75
75
75
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for
each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the per formance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.
*
The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount. Warning:
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.