belt DODGE CHALLENGER 2008 Owner's Guide

STARTING PROCEDURES
Before starting your vehicle, adjust your seat, adjust the
inside and outside mirrors, fasten your seat belt, and if
present, instruct all other occupants to buckle their seat
belts.WARNING!
•Never leave children alone in a vehicle. Leaving
unattended children in a vehicle is dangerous for a
number of reasons. A child or others could be
seriously or fatally injured. Don’t leave the key in
the ignition. A child could operate power win-
dows, other controls, or move the vehicle.
•Do not leave animals or children inside parked
vehicles in hot weather; interior heat buildup may
cause serious injury or death.
•Be sure to turn OFF the engine and remove the key
from the ignition switch if you want to rest or
sleep in your car. Accidents can be caused by
inadvertently moving the shift lever. Accidents
can also be caused by pressing the accelerator
pedal. This may cause excessive heat in the ex-
haust system, resulting in overheating and vehicle
fire, which may cause serious or fatal injuries.
214 STARTING AND OPERATING
ProCarManuals.com

6. Connect the other cable, first to the negative terminal
of the booster battery andthen to the engine ground (-)
of the vehicle with the discharged battery. Make sure
you have a good contact on the engine ground. Refer to
the following illustration for jump-starting connections. 7. Start the engine in the vehicle that has the booster
battery. Let the engine idle a few minutes. Then, start the
engine in the vehicle with the discharged battery.
NOTE:
Refer toSynchronizing ESP under Electronic
Stability Program in Section 5 if the ESP/BAS light (in
the instrument cluster) remains on continuously after
starting the engine of the vehicle with the discharged
battery.
8. When removing the jumper cables, reverse the above
sequence exactly. Be careful of the moving belts and fan.
Jump-Starting
288 WHAT TO DO IN EMERGENCIES
ProCarManuals.com

MAINTAINING YOUR VEHICLE
CONTENTS

Engine Compartment — 6.1L ..............296

Onboard Diagnostic System — OBD II ........297
▫ Loose Fuel Filler Cap ..................297

Emissions Inspection And Maintenance
Programs ............................298

Replacement Parts ......................299

Dealer Service .........................300

Maintenance Procedures ..................300
▫ Engine Oil ..........................301 ▫
Engine Oil Filter ......................303
▫
Drive Belts — Check Condition And Tension...303
▫ Spark Plugs .........................304
▫ Engine Air Cleaner Filter ................304
▫ Fuel Filter ..........................304
▫ Catalytic Converter ....................305
▫ Maintenance-Free Battery ................307
▫ Air Conditioner Maintenance .............309
▫ A/C Air Filter — If Equipped ............310
7
ProCarManuals.com

Materials Added to Engine Oil
The manufacturer strongly recommends against the addi-
tion of any additives (other than leak detection dyes) to the
engine oil. Engine oil is an engineered product and its
performance may be impaired by supplemental additives.
Disposing of Used Engine Oil and Oil Filters
Care should be taken in disposing of used engine oil and
oil filters from your vehicle. Used oil and oil filters,
indiscriminately discarded, can present a problem to the
environment. Contact your authorized dealer, service sta-
tion, or governmental agency for advice on how and where
used oil and oil filters can be safely discarded in your area.
Engine Oil Filter
The engine oil filter should be replaced at every engine
oil change.
Engine Oil Filter Selection
This manufacturer’s engines have a full-flow type oil
filter. Use a filter of this type for replacement. The qualityof replacement filters varies considerably. Only high
quality filters should be used to assure most efficient
service. MOPAR
engine oil filters are a high quality oil
filter and are recommended.
Drive Belts — Check Condition And Tension
Belt tension is controlled by means of an automatic
tensioner. Therefore, no belt tension adjustments are
required. However, belt and belt tensioner condition
should be inspected periodically and replaced if re-
quired. Improper belt tension can cause belt slippage and
failure. Low generator belt tension can cause battery
failure.
Inspect belts for evidence of cuts, cracks, glazing, or
frayed cords and replace if there is indication of damage
that could result in belt failure. Also, check belt routing to
make sure there is no interference between the belts and
other engine components. See your authorized dealer for
service.
MAINTAINING YOUR VEHICLE 303
7
ProCarManuals.com

Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Section 3 of the Warranty Information book for
further warranty information.
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
MAINTAINING YOUR VEHICLE 309
7
ProCarManuals.com

quarter window equipped with the radio antenna. Do
not use scrapers or other sharp instruments that may
scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag or micro-fiber towel. A mild
soap solution may be used, but do not use high alcohol
content or abrasive cleaners. If soap is used, wipe clean
with a clean damp rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use MOPARTotal Clean, a
mild soap solution, or lukewarm water. Do not remove
the belts from the vehicle to wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning The Center Console Cupholders
Clean with a damp cloth or towel using a mild detergent
with the cupholder in the center console.
NOTE: The cupholder cannot be removed.
328 MAINTAINING YOUR VEHICLE
ProCarManuals.com

Auto Unlock, Doors....................... 31
Automatic Dimming Mirror ................. 75
Automatic Door Locks ..................... 31
Automatic Headlights ..................... 117
Automatic Transaxle Special Additives ...................... 324
Automatic Transmission .............223,322,323
Adding Fluid ...................... 323,343
Autostick ............................ 228
Fluid and Filter Changes ................. 323
Fluid Change ......................... 323
Fluid Level Check ...................... 322
FluidType ........................... 343
Shifting ............................. 223
Special Additives ...................... 324
Automatic Transmission Limp Home Mode . . 226,227
Autostick ............................. 228
AxleFluid ............................. 343
Axle Lubrication (Axle Fluid) ............... 343BallJoints ............................. 311
Battery
............................... 307
Emergency Starting ..................... 286
Jump Starting ......................... 286
Keyless Transmitter Replacement (RKE) ....... 25
Location .......................... 287,307
Bearings .............................. 324
Belts,Drive ............................ 303
Belts, Seat ............................ 38,69
Body Mechanism Lubrication ............... 311
B-Pillar Location ........................ 250
Brake Assist System ...................... 239
Brake Control System, Electronic ............. 238
Brake Fluid ............................ 343
Brake, Parking .......................... 232
Brake System ........................ 234,320
Anti-Lock (ABS) .................... 235,238
Fluid Check ....................... 321,343
Hoses .............................. 320
INDEX 363
10
ProCarManuals.com

Diagnostic System, Onboard................ 297
Digital Video Disc (DVD) Player ............. 191
Dimmer Switch, Headlight ................. 120
Dipsticks Oil (Engine) .......................... 301
Disabled Vehicle Towing ................... 291
Disposal Antifreeze (Engine Coolant) ............... 317
Engine Oil ........................... 303
Door Locks ............................. 29
Door Locks, Automatic .................... 31
Door Opener, Garage ..................... 130
DriveBelts ............................ 303
Driving On Slippery Surfaces .................... 229
Through Flowing, Rising, or Shallow
Standing Water ........................ 230
Electric Remote Mirrors .................... 76 Electrical Power Outlets
................... 140
Electronic Brake Control System ............. 238
Electronic Power Distribution Center (Fuses) .... 331
Electronic Speed Control (Cruise Control) ...... 126
Electronic Stability Program (ESP) ............ 240
Electronic Throttle Control Warning Light ...... 151
Electronic Vehicle Information Center (EVIC) .... 159
Emergency Deck Lid Release ................ 36
Emergency, In Case of FreeingVehicleWhenStuck ............... 289
Hazard Warning Flasher ................. 280
Jump Starting ......................... 286
Overheating .......................... 280
Towing ............................. 291
Emergency Trunk Release ................... 36
Emission Control System Maintenance ......298,346
Engine ............................... 296
Air Cleaner .......................... 304
Block Heater ......................... 219
366 INDEX
ProCarManuals.com

Knee Bolster............................ 46
Lane Change and Turn Signals .............. 119
Lap/Shoulder Belts ....................... 38
LATCH (Lower Anchors and Tether
forCHildren) ......................... 61,62
Latch Plate ............................. 39
Latches ................................ 70
Hood ............................... 114
Lead Free Gasoline ...................... 270
Leaks, Fluid ............................ 70
LifeofTires ............................ 259
LightBulbs .......................... 70,336
Lights .............................. 70,116
Airbag ........................ 52,55,70,152
Anti-Lock ......................... 158,236
Automatic Headlights ................... 117
Brake Assist Warning ................... 244
Brake Warning ..................... 155,234Bulb Replacement
................... 336,337
Center Mounted Stop ................... 340
Courtesy/Reading ................... 120,129
Cruise .............................. 150
Daytime Running ...................... 118
Dimmer Switch, Headlight ............. 119,120
Electronic Stability Program (ESP) Indicator . . . 244
Electronic Throttle Control Warning ......... 151
Engine Temperature Warning .............. 152
Exterior .............................. 70
Fog ............................. 118,154
Hazard Warning Flasher ................. 280
Headlight Switch ...................... 116
Headlights ........................ 116,337
Headlights On Reminder ................. 118
Headlights On With Wipers ............ 117,124
High Beam ........................ 120,153
High Beam Indicator .................... 153
High Beam/Low Beam Select ............. 120
INDEX 371
10
ProCarManuals.com

Illuminated Entry....................... 20
Instrument Cluster .................. 116,150
Intensity Control ....................... 121
Interior .......................... 121,129
License ............................. 340
Lights On Reminder .................... 118
Low Fuel ............................ 158
LowTire ............................ 156
Malfunction Indicator (Check Engine) ........ 158
Map Reading ...................... 120,129
Oil Pressure .......................... 153
Parade Mode (Daytime Brightness) .......... 121
Passing ............................. 120
Reading .......................... 120,129
Seat Belt Reminder ..................... 154
Service ........................... 336,337
Service Engine Soon (Malfunction Indicator) . . . 158
Tire Pressure Monitoring (TPMS) ........156,264 Traction Control
....................... 244
Turn Signal ...................... 70,119,152
VanityMirror .......................... 77
Voltage ............................. 150
Warning (Instrument Cluster Description) ..... 150
Loading Vehicle ...................... 276,277
Capacities ........................... 277
Tires ............................... 250
Locks ................................. 29
AutoUnlock .......................... 31
Automatic Door ........................ 31
Door ................................ 29
Power Door ........................... 30
Low Tire Pressure System .................. 264
Lower Anchors and Tether for CHildren
(LATCH) ............................ 61,62
Lubrication, Body ....................... 311
Lumbar Support ........................ 111
372 INDEX
ProCarManuals.com