engine overheat DODGE DART 2016 PF / 1.G User Guide

WARNING!
•Exhaust gases can injure or kill. They contain
carbon monoxide (CO), which is colorless and
odorless. Breathing it can make you unconscious
and can eventually poison you. To avoid breathing
CO, refer to “Safety Tips/Exhaust Gas” in “Things
To Know Before Starting Your Vehicle” for further
information.
• A hot exhaust system can start a fire if you park
over materials that can burn. Such materials might
be grass or leaves coming into contact with your
exhaust system. Do not park or operate your ve-
hicle in areas where your exhaust system can con-
tact anything that can burn.
CAUTION!
• The catalytic converter requires the use of un-
leaded fuel only. Leaded gasoline will destroy the
effectiveness of the catalyst as an emissions control
device and may seriously reduce engine perfor-
mance and cause serious damage to the engine.
• Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition.
In the event of engine malfunction, particularly
involving engine misfire or other apparent loss of
performance, have your vehicle serviced promptly.
Continued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.
590 MAINTAINING YOUR VEHICLE

Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is im-
portant to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune-up to manufacturer’s specifica-
tions, should be obtained immediately.
To minimize the possibility of catalytic converter damage:
• Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion. •
Do not try to start the engine by pushing or towing the
vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.
Cooling System
WARNING!
• When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the OFF position. The fan is temperature
controlled and can start at any time the ignition
switch is in the ON position.
• You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
(Continued)
7
MAINTAINING YOUR VEHICLE 591

Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze).
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is
overheated. Do not loosen or remove the cap to cool
an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scalding
or injury, do not remove the pressure cap while the
system is hot or under pressure.
• Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
The coolant expansion bottle provides a quick visual
method for determining that the coolant level is ad-
equate. With the engine off and cold, the level of the
engine coolant (antifreeze) in the bottle should be be-
tween the “MAX” and “MIN” lines marked on the bottle.
7
MAINTAINING YOUR VEHICLE 595

DrivingThrough Flowing, Rising, Or Shallow Standing
Water ............................... .449
Electrical Power Outlets .....................282
Electric Rear Window Defrost .................294
Electric Remote Mirrors .....................123
Electronic Brake Control System ...............456
Anti-Lock Brake System ..................456
Traction Control System ...................462
Electronic Speed Control (Cruise Control) ........250
Electronic Stability Control (ESC) ..............463
Electronic Throttle Control Warning Light ........314
Electronic Vehicle Information Center (EVIC) . .266, 329
Emergency Brake ........................ .451
Emergency Deck Lid Release ..................48
Emergency, In Case Of Freeing Vehicle When Stuck ................559
Hazard Warning Flasher ..................531 Jacking
.............................. .544
Jump Starting ......................... .555
Overheating .......................... .531
Towing ............................. .563
Emergency Trunk Release ....................48
Emission Control System Maintenance ..........575
Engine ............................. .572, 573
Air Cleaner .......................... .582
Block Heater ......................... .420
Break-In Recommendations ................107
Checking Oil Level ..................... .578
Compartment ......................... .571
Cooling ............................. .591
Exhaust Gas Caution .................109, 509
Fuel Requirements ..................... .504
Jump Starting ......................... .555
Oil .......................... .578, 622, 623
Oil Filler Cap ................572, 573, 580, 581
Oil Filter ............................ .581
10
INDEX 651

Oil Selection...................... .579, 623
Overheating .......................... .531
Enhanced Accident Response Feature ............83
Entry System, Illuminated ....................23
Ethanol ............................... .506
Event Data Recorder ........................86
Exhaust Gas Caution ...................109, 509
Exhaust System ...................... .109, 589
Exterior Folding Mirrors ....................123
Exterior Lighting ......................... .234
Exterior Lights ...........................113
Filters Air Cleaner .......................... .582
Air Conditioning ....................409, 585
Automatic Transmission ..................601
Engine Oil ........................... .581
Engine Oil Disposal .....................581 Flashers
Hazard Warning ....................... .531
Turn Signal .....................113, 239, 326
Flash-To-Pass ........................... .240
Flooded Engine Starting ....................419
Floor Console ........................... .288
Fluid, Brake ............................ .625
Fluid Capacities ......................... .622
Fluid Leaks .............................113
Fluid Level Checks Automatic Transmission ..................600
Fluids ............................. .623, 625
Fluids, Lubricants And Genuine Parts ...........623
Fog Lights ............................. .238
Folding Rear Seat ........................ .230
Freeing A Stuck Vehicle .....................559
Fuel .................................. .504
Adding ............................. .509
652 INDEX

MOPAR Parts........................ .576, 641
MTBE/ETBE ........................... .506
Multi-Function Control Lever .................239
New Vehicle Break-In Period .................107
Occupant Restraints ........................48
Octane Rating, Gasoline (Fuel) ................504
Oil Change Indicator ...................338, 353
Oil Change Indicator, Reset ...............338, 353
Oil, Engine ...................... .578, 622, 623
Capacity ............................ .622
Change Interval ....................... .579
Checking ............................ .578
Disposal ............................. .581
Filter ............................... .581
Filter Disposal ........................ .581
Identification Logo ..................... .580
Materials Added To ..................... .581Pressure Warning Light
...................313
Recommendation .................579, 622, 623
Viscosity ......................... .580, 581
Oil Filter, Change ........................ .581
Oil Filter, Selection ....................... .582
Oil Pressure Light ........................ .313
Onboard Diagnostic System ..................574
Opener, Garage Door (HomeLink) .............270
Operating Precautions ..................... .574
Operator Manual (Owner’s Manual) .............4
Outside Rearview Mirrors ...................122
Overhead Console ........................ .268
Overheating, Engine ...................... .531
Owner’s Manual (Operator Manual) ..........4,642
Paint Care ............................. .602
Panic Alarm .......................... .22, 26
Parking Brake ........................... .451
Parking On Hill ......................... .451
658 INDEX