wiper blades DODGE SPRINTER 2004 1.G Owners Manual

70 UNDERSTANDING THE FEATURES OF YOUR VEHICLETouch-wipe:
Press the windshield wiper switch up to the pressure
point.
NOTE: Smears may form on the glass when the
windshield wipers are in use. In this case, operate the
windshield washer, even in rainy weather.
Check wiper blades regularly for damage and
contamination.
Windshield wipers with rain sensor (Optional)To switch on:
Turn the windshield wiper switch to Intermittent
wipe.
When switched on, the windshield wipers wipe one
time. After that the wiping interval and wiping speed
(normal and rapid), depend on wetness of the
windshield and are controlled automatically.
WARNING!
Sudden loss of visibility through the windshield
caused by e. g. ice, steam, fog or water could lead
to an accident. You might not see other vehicles or
other obstacles. To avoid sudden icing of the
windshield during freezing weather, warm the
windshield with the defroster or with the wind-
shield heater (optional) before and during wind-
shield washer use.Follow the recommended settings for de-fogging
and de-icing the front windows given in Section 4.
CAUTION!
Do not leave windshield wipers in intermittent
setting when vehicle is taken to an automatic car
wash or during windshield cleaning and/or de-
icing. Wipers will operate if the windshield gets
wet, and wipers may be damaged as a result.
Freightliner-all.book Pag e 70 Monday , December 1, 2003 2:54 PM

MAINTAINING YOUR VEHICLE
7
CONTENTS
Engine Compartment . . . . . . . . . . . . . . . . . . . . . . . 205

Sprinter Original Parts . . . . . . . . . . . . . . . . . . . . . . 207

Service Products . . . . . . . . . . . . . . . . . . . . . . . . . . . 207Disposal of Service Products . . . . . . . . . . . . . . 208

Emission Related Component Warranty
Statement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208

Regular Checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208Windshield Washer System Fluid Reservoir . 209Air Filter Restriction Indicator (Optional) . . . 209Engine Oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 209Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . 210Ribbed V-Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . 211Hydraulic Brake System, Clutch Mechanism
Fluid Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212Engine Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Checking Coolant Level . . . . . . . . . . . . . . . . . . 213

Winter Operation . . . . . . . . . . . . . . . . . . . . . . . . . . 215

Batteries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216Disconnecting the Battery . . . . . . . . . . . . . . . . . 216Reconnecting the Battery . . . . . . . . . . . . . . . . . . 217Charging the Battery . . . . . . . . . . . . . . . . . . . . . 217

Replacing Wiper Blades . . . . . . . . . . . . . . . . . . . . . 218Appearance Car and Corrosion Protection . . 219Power Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . 220Automatic Car Wash . . . . . . . . . . . . . . . . . . . . . 221Tar Stains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221Paintwork, Painted Body Components . . . . . . 221Engine Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . 221Vehicle Washing . . . . . . . . . . . . . . . . . . . . . . . . . 222Ornamental Moldings . . . . . . . . . . . . . . . . . . . . 222Headlamps, Taillamps, Turn Signal Lenses . . 222Window Cleaning . . . . . . . . . . . . . . . . . . . . . . . 223
Freightliner-all.book Pag e 203 Monday, December 1, 2003 2:54 PM

218 MAINTAINING YOUR VEHICLEREPLACING WIPER BLADES1. Fold over the wiper arm (2) and place the wiper
blade crosswise.
2. Press the retaining spring (1) and push the wiper
blade out of the end of the wiper arm (2).
3. Remove the wiper blade.4. Insert the end of the wiper arm (2) into the larger
cutout (3) of the wiper blade.
5. Push the wiper blade into the end of the wiper
arm (2) until the retaining spring (1) engages.Freightliner-all.book Pag e 218 Monday, December 1, 2003 2:54 PM

INDEX 269
10
Overheating (Air Heater) . . . . . . . . . . . . . . . . . . . . . . 131
Overheating (Water Heater) . . . . . . . . . . . . . . . . . . . 131PPassenger Compartment Protection . . . . . . . . . . . . . . 21
Alarm Pushbutton . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Switching off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Permissible Roof Load . . . . . . . . . . . . . . . . . . . . . . . . 177
Programmed Top Speed . . . . . . . . . . . . . . . . . . . . . . . 173RRear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Rear Seat Bench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Removal and Installation . . . . . . . . . . . . . . . . . . . . . 58
Recommended Fluids and Lubricants . . . . . . . . . . . 245
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Regular Checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
Relay Assignment, Standard Equipment . . . . . . . . . 230
Remote Keyless Entry . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Replacing Batteries . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17Removing a Wheel. . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Replacing Wiper Blades . . . . . . . . . . . . . . . . . . . . . . . 218
Reporting safety Defects . . . . . . . . . . . . . . . . . . . . . . . 259
Reserve Fuel Indicator Lamp . . . . . . . . . . . . . . . . . . . . 94
Residual Engine Heat Utilization . . . . . . . . . . . . . . . 115
Residual Engine Heat Utilization (REST). . . . . . . . . 115
Restraints, Occupant . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Retrofitting Seat Mounting Cups . . . . . . . . . . . . . . . . 59
Ribbed V-Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211
Roof Load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
RPMs, Constant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
SSafety Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Seat Belt Warning Lamp and Airbag Malfunction . . 38
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Belt Tensioners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Fastening and Removing . . . . . . . . . . . . . . . . . . . . . 38
Height Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Seat Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Freightliner-all.book Pag e 269 Monday, December 1, 2003 2:54 PM