spark plugs FIAT LINEA RHD 2010 1.G Owners Manual

76
FUEL FILLER CAP fig. 82
To carry out fuelling,
operate lever A-fig.
83/84 to release the flap A and unscrew
cap B; the cap is fitted with a special device
C which fastens it to the lid so it cannot
be mislaid.
In some versions, cap Bmay be provided
with a lock and key;
use the ignition key
to access the flap A-fig. 82, turn it anti-
clockwise and loosen the cap itself.
The airtight closing may determine a slight
increase of pressure in the tank. A suction
noise when you release the cap is there-
fore entirely normal.
PROTECTING THE
ENVIRONMENT
The devices for curtailing petrol engine
emissions are the following:
three-way catalytic converter;
lambda sensors;
fuel evaporation system.
In addition, do not let the engine run, even
for a test, with one or more spark plugs
disconnected.
The devices for curtailing diesel fuel en-
gine emissions are the following:
oxidising catalytic converter;
exhaust gas recirculation system
(E.G.R.).
fig. 82F0M0203m
Do not approach naked
flames or lit sigarettes to the
fuel filler : fire risk. Keep your face
away from the fuel filler to prevent
breathing in harmful vapours.
WARNING
fig. 83
fig. 84F0R0210m
F0R0210m
When refuelling, position the cap on the
device inside the lid as shown in fig. 82.The catalytic converter de-
velops high temperature dur-
ing operation. Do not park on grass,
dry leaves, pine needles or other flam-
mable material: fire risk.
WARNING
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS

  

LINEA Owner HAND BOOK RHD.pdf 76LINEA Owner HAND BOOK RHD.pdf 768/21/09 2:16:10 PM8/21/09 2:16:10 PM

Thousands of kilometres
Replace spark plugs
Check and Top up fluid levels (engine coolant, brake
fluid, screen washer, battery, and power steering oil,
etc, if requried) ( )
Check condition of toothed driving belt
Check operation of engine management systems
(using diagnostic socket) Replace toothed timing drive belt (*)
Change brake / clutch fluid (every 60000 kms or
24 months, whichever is earlier) Change engine oil and replace oil filter
(every 20,000 kms or 12 months, whichever is earlier)
Change pollen filter
(*) Regardless of the km covered, the timing belt shall be replaced every 3 years for particularly demanding use
(cold climates, driving in the city, idling for a long time) or in any case every 5 years
(**) Paint and or body damages must promply be rectified to prevent possible deterioration of paint and ( ) Regardless of the km covered, Air filter should be replaced earlier if operating in dusty condition
140
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
20 40 60 80 100 120 140 160 180
Check transmission oil level
( ) Change power steering oil every 24 months
formation of rust
LINEA Owner HAND BOOK RHD.pdf 140LINEA Owner HAND BOOK RHD.pdf 1408/21/09 2:16:22 PM8/21/09 2:16:22 PM

DEMANDING USE
OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
trailer or caravan towing;
dusty roads;
short distances (less than 7-8 km) re-
peated and with external temperatures
below zero;
frequently idling engines or long dis-
tance low speed driving (e.g . taxis or
door-to-door deliveries) or in case of
a long term inactivity;
in cities;
perform the following inspections and
shown on the Service Schedule:

check cleanness of locks, bonnet and
boot and lever cleanness and lubrica-
tion;
visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
check battery charge and liquid level
(electrolyte) (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
visually inspect the accessory drive belt
conditions;
check pollen filter
check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
 engine coolant fluid level; Engine Oil level, every 3,000 km and
brake - clutch fluid level and type;
power steering fluid level;


tyre pressure and conditions;
operation of lights (headlights, direction
indicators, hazard lights, etc.);
143
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
. If the vehicle is
replacements more frequently than
check front disk brake pad conditions
and wear; frequently than required; replace engine oil and oil filter more
frequently
than required on the service replace spark plugs more
schedules, in particular contact a Fiat
Dealership if a reduction in the
vehicle engine performance is noted;used frequently in dusty or heavily
polluted environments it is
advisable to replace the filtering
elementts more frequently, in
particular it should be replaced if a
reduction of the amount of air
admitted to the passenger
compartment is noted; top up if required;
LINEA Owner HAND BOOK RHD.pdf 143LINEA Owner HAND BOOK RHD.pdf 1438/21/09 2:16:22 PM8/21/09 2:16:22 PM

1.4 16v
323B6600
Otto
4 in line
72 x 84
1368
10.8 ± 0.2
6000
115
4500
4, NGK
ZKR7A-10 C 128
Unleaded petrol 91 RON min
1.3 Multijet
199A3000
Diesel
4 in line
69.6 x 82
1248
17.6 ± 0.2
4000
203
2500
–
Normal Diesel (avoid premium /
additives) 51 Cetane no. min.
ENGINE
GENERAL
Engine code
Cycle
Number and layout of cylinders
Piston bore and stroke mm
Total displacement cm3
Compression ratio
Maximum power
corresponding rpm
Maximum torque Nm
corresponding rpm
Spark plugs
Fuel
162
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
DASHBOARD
SAFETY
Kw 66 65
LINEA Owner HAND BOOK RHD.pdf 162LINEA Owner HAND BOOK RHD.pdf 1628/21/09 2:16:36 PM8/21/09 2:16:36 PM

177
TECHNICAL
SPECIFICATIONS
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY INDEX
AND CONTROLS
DEVICES
Key with remote control .............. 8
Key without remote control ......... 10
Load limiters .................................... 80
Main beam headlights
- bulb replacement ........................ 122
- control ........................................... 51
- flashing ........................................... 51
Multi functional display ....................
21
Number plate light ......................... 125
Oddment compartments .............. 60
Paint ................................................... 155
Parking ................................................ 96
Performance ...................................... 170
Plates
- model plate ...................................
171
Pollen filter .........................................
149
Power steering fluid .........................149Power windows ................................ 65
Pretensioners .................................... 80
Prolonged car inactivity .................. 100
Protecting the environment ........... 76
Radio transmitters and cellular
telephones .................................... 74
Radio navigation presetting system.. 73
Rear ceiling lights
- bulb replacement ........................ 126
- control ........................................... 54
Rear door emergency
lock device .................................... 64
Rear fog lights
- bulb replacement ........................ 123
- control button ............................. 57
Rearview mirrors
- door mirrors ................................ 35
- driving mirror ...............................
36Refueling ............................................. 75
Rev. counter ....................................... 14
Reversing light ...................................
123
Rubber hoses .................................... 153
Safety ................................................. 77
Seat adjustment ................................ 32
Seat belts
- general instructions .................... 81
- load limiters ................................. 80
- maintenance ................................. 83
- using the seat belts .....................
78
Seats
- adjustment .................................... 32
- cleaning ......................................... 157
- tilting (rear seats) ........................ 68
Side lights
- control ...........................................
42
bulb replacement ........................... 121

Smart washing ................................... 53
Smoker’s kit ....................................... 62
Sound system .................................... 73
Spark plugs
- type ................................................ 162
LINEA Owner HAND BOOK RHD.pdf 177LINEA Owner HAND BOOK RHD.pdf 1778/21/09 2:16:38 PM8/21/09 2:16:38 PM