FIAT PANDA 2007 169 / 2.G 4x4 Supplement Manual

10
FIAT PANDA 4 x 4
WASHING THE CAR
After using the car off-road (wheels, body,
underengine and underbody protections
very dirty), remember to wash it and to
clean accurately radiators (engine and air-
conditioner), radiator fan and wheels (rims
and wheelhouses), underengine and un-
derbody protections to preserve their
regular operation and to guarantee prop-
er ventilation of brake discs, perfect wheel
geometry and regular operation of the
propeller shaft.
TOWING THE CAR
The car can only be towed in one of the
following ways (always and exclusively
with the engine off, gearbox in neutral and
handbrake disengaged):
– with the 4 wheels on the roadbed;
– with front wheels raised or resting on
the wrecking car floor and rear wheels
resting on a suitable truck;
– with rear wheels raised or resting on the
wrecking car floor and front wheels rest-
ing on a suitable truck;
– on wrecking car, with front and rear
wheels resting on the wrecking car floor.
TOWING TRAILERS
IMPORTANT If the car is used at its max.
towing capacity on sloping road, change
engine oil every 10,000 km.
As concerns tow hook installation in-
structions and warnings refer to the at-
tached Owner Handbook.
The assembly diagram with the new tow
hook fixing points is given below.
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 10

11
FIAT PANDA 4 x 4
ASSEMBLY DIAGRAM, fig. 24
The tow hook structure must be fastened
in the points identified by symbol Øus-
ing a total of 4 M8 screws and 2 M12
screws. Internal plates 1 thickness shall be
6mm. The hook should be fastened to the
body avoiding any type of drilling and trim-
ming of the rear bumpers that remains vis-
ible when the hook is removed.
IMPORTANT It is compulsory to fasten,
at the same height as the tow hook and
in a clearly visible position, a label of suit-
able size and material with the following
information: MAX LOAD ON BALL 60 kg
After fitting, screw holes shall be sealed to
prevent an exhaust gas inlet.
fig. 24F0G0266m
existing screw
existing hole
existing hole
standard tow ball existing hole
existing
screw
existing hole
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 11

12
FIAT PANDA 4 x 4
20 40 60 80 100 120 140 160 180
●●●●● ●●●●
●●●●● ●●●●
●●●●● ●●●●
●●●●● ●●●●
●●●●● ●●●●
●● ● ●
●●●●● ●●●●
●●●●● ●●●●
●
●● ● ●
●● ● ●
●● ● ●
●●
SERVICE SCHEDULE
Thousands of km
Check tyre conditions/wear and adjust pressure
if required
Check light system operation (headlights, direction indicators,
hazard lights, passenger compartment lights, boot lights,
warning lights, etc.)
Check windscreen wiper/washer operation,
adjust nozzles
Check windscreen/rear window blade
position/wear
Check front disk brake pad conditions and wear
Check rear disk brake pad conditions and wear
Sight inspect the conditions of: body external parts,
underbody protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever cleanness
and lubrication
Check tension and adjust accessory drive belts
(excluding engines with automatic belt tighteners)
Sight inspect accessory drive belt conditions
Check and adjust tappet clearance (petrol versions)
Check handbrake lever stroke
Check antievaporation system (petrol versions)
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 12

13
FIAT PANDA 4 x 4
20 40 60 80 100 120 140 160 180
●● ●
●● ●●●●●●●
●●
●
●●●●
●●●●
●●
●● ●●●●●●●
●● ●
●● ●●●●●●●
●●●●
●● ●
Thousands of km
Change air cleaner cartridge
(every 30,000 km/for 1.3 Multijet engine)
Top up fluids
(engine coolant, brakes, windscreen, battery, etc.)
Check timing belt
(excluding 1.3 Multijet engines)
Replace timing belt (*)
(excluding 1.3 Multijet engine)
Change spark plugs (petrol versions)
Check engine control system operation
(through diagnosis socket)
Check mechanical transmission oil level
Change engine oil and oil filter
(every 30,000 km/for 1.3 Multijet engine)
Change brake fluid (or every 2 years)
Change pollen filter (or every year)
Check exhaust emissions/smoke (1.3 Multijet engine)
Replace fuel filter cartridge (Green-filter)
(1.3 Multijet engine)
(*) Or every 3 years for particularly demanding use:
– cold/hot climates,
– driving in the city, idling for a long time,
– dusty roads or roads covered with sand and/or salt.
Or every 5 years, regardless of the km covered and the car conditions of use.
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 13

14
FIAT PANDA 4 x 4
Engine code
188 A 4000
188 A 8000
188 A 4000
188 A 8000
188 A 8000
Fiat Panda 4 x 4
Fiat Panda 4 x 4 Climbing
Fiat Panda 4 x 4 CROSS
ENGINE CODES
BODY VERSIONS
Fiat Panda 4 x 4
Fiat Panda 4 x 4 Climbing
Fiat Panda 4 x 4 CROSS
Versions Engine code Body version
4-seat - Euro 4 5-seat - Euro 4
1.2 169AXB2A04 169AXB2A04B
1.3 Multijet 169AXC2A05F 169AXC2A05G
1.2 169AXB2A04C 169AXB2A04D
1.3 Multijet 169AXC2A05H 169AXC2A05I
1.3 Multijet 169AXC2A05L –Engine
1.2
1.3 Multijet
1.2
1.3 Multijet
1.3 Multijet
Versions
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 14

15
FIAT PANDA 4 x 4
To prevent damages to the
viscous joint do not cover long
distances with underinflated
tyres (tyres partly or com-
pletely flat).
RIMS AND TYRES
All Fiat Panda 4x4 version tyres have been designed to obtain best performance on both regular roadbed and not asphalted and/or
snowy or icy roads.
These tyres are characterised by high road-holding performance off-road and good driveability on both snowy/icy roads and dry or
wet roadbeds.
The following tyres are provided:
5.5J x 14
5.5J x 14
5.5J x 14
6J x 15
165/70 R14 81T M+S
185/65 R14 86T M+S ()
165/70 R14 81T M+S (*)
185/65 R14 86T M+S
175/65 R15 84T M+S (*) ()4.00B x 14
4.00B x 14
4.00B x 14
4.00B x 15135/80 R14 84P
135/80 R14 84P
135/80 R14 84P
125/80 R15 95M Fiat Panda 4 x 4
Fiat Panda 4 x 4
Climbing
Fiat Panda 4 x 4
CROSS Version Rims Tyres Space-saver spare wheel
Rim Tyre
(*) Optional tyre
() Tyres that cannot be fitted with snow chains
Versions Medium load Full load Space-saver
front rear front rearspare wheel
1.22.2 2.0 2.3 2.3 2.8
1.3 Multijet2.3 2.1 2.3 2.3 2.8 / 4.2(*)
(*) For Fiat Panda 4 x 4 CROSS versions with 125/80 R15 95M
space-saver spare wheel
INFLATION PRESSURES (bar)
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 15

Keep your speed down when
snow chains are fitted. Do
not exceed 50 km/h. Avoid potholes,
steps and pavements and avoid also
to drive for long distances on roads
not covered with snow to prevent
damaging the car and the roadbed.Snow chains shall only be fit-
ted to front wheels.
16
FIAT PANDA 4 x 4
SNOW CHAINS
Use of snow chains should be in compli-
ance with local regulations.
Tyre 185/65 R14 86T M+S cannot be fitted
with chains only for Fiat Panda 4 x 4 Climb-
ing versions whereas it can be fitted with
chains for Fiat Panda 4 x 4 CROSS versions.
Tyre 165/70 R14 81T M+S can be fitted
with chains. For tyres that can be fitted
with chains only use snow chains with re-
duced size (max. protrusion beyond the
tyre profile of 9 mm).
WARNING
It is recommended to use Lineaccessori
Fiat snow chains.
Check the tension of the chains after the
first few metres have been driven.
Tyre 175/65 R15 84T M+S, (that can be
fitted on Fiat Panda 4 x 4 CROSS upon re-
quest) cannot be fitted with chains.
Five forward gears and reverse with synchromesh
for forward gear engagement
Self-adjusting with no travel-free pedal
four-wheel drive, automatic engagement through viscous joint and two differentials
rack and pinion with electric power steering (where provided)
9.610
TRANSMISSION
Gearbox
Clutch
Drive
STEERING
Fiat Panda 4 x 4 - Fiat Panda 4 x 4 Climbing Fiat Panda 4 x 4 CROSS
Type
Turning radius
(between pavements) m
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 16

17
FIAT PANDA 4 x 4
DIMENSIONS
Dimensions are expressed in mm and re-
fer to the car fitted with standard tyres.
The height refers to the car unladen.
Versions A B C D E F G H
Fiat Panda 4 x 43538 713 2305 520 1630 (*) 1358 1578 (**) 1366
Fiat Panda 4 x 4 Climbing3574 721 2305 548 1632 1358 1605 1366
(*) Without longitudinal racks mm 1592
(**) With side bands mm 1589
F0G0708m
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 17

18
FIAT PANDA 4 x 4
Dimensions are expressed in mm and re-
fer to the car fitted with standard tyres.
The height refers to the car unladen.
Versions A B C D E F G H
Fiat Panda 4 x4 CROSS3581 734 2305 542 1643 (*) 1382 1611 1387
(*) Without longitudinal racks mm 1605
F0G0709m
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 18

19
FIAT PANDA 4 x 4
BOOT VOLUME
Unladen boot volume (V.D.A. standards) in dm
3.
Boot closed and rear parcel shelf mounted
Boot at waist edge with rear seat back folded
Max. height to roof with rear seat back folded
Max. height to roof with rear seat back folded
(with sunroof)
(*) With seat set completely in backward position
(**) With seat set completely in forward position
petrol
145Multijet
150petrol
145Multijet
150Multijet
150
PERFORMANCE
Fiat Panda 4 x 4 Fiat Panda 4 x 4 ClimbingFiat Panda 4 x 4 CROSS
Top admitted
speed after running-in
in km/hRear single
and double seat
200
485
855
810Rear sliding
seat
170 (*) 230 (**)
410
780
735
603.83.460 PANDA 4X4 GB 26-06-2007 11:19 Pagina 19