oil FORD BRONCO SPORT 2022 Warranty Guide

than Ford dealer facilities. Tire replacements under warranty will
be made with the same brand and model as originally equipped
with the vehicle unless the same brand and model is no longer
available, in which case a tire of the same brand, size, load, speed
and tread type will be used. In some circumstances, Ford may
authorize another brand and/or model to substitute for the
original brand and model, even if still available.
Normal tire wear or damage is not reimbursable. See page 18 for
details of what is not covered.
Extended warranty coverage periods are available for certain
vehicle parts and conditions. Specifically,
(1) Your vehicle's Powertrain components are covered for five
years or 60,000 miles, whichever occurs first. The extended
coverage applies to theEngine:all internal lubricated parts,
cylinder block, cylinder heads, electrical fuel pump, powertrain
control module, engine mounts, flywheel, injection pump,
manifold (exhaust and intake), manifold bolts, oil pan, oil pump,
seals and gaskets, engine thermostat, engine thermostat
housing, timing chain cover, timing chain (gears or belt),
turbocharger/supercharger unit, valve covers, water pump;
Transmission: all internal parts, clutch cover, seals and gaskets,
torque converter, transfer case (including all internal parts),
transmission case, transmission mounts (front and rear);
Front-Wheel Drive: axle shafts, support bracket, front bearings,
seals and gaskets, universal and constant velocity joints;
Rear-Wheel Drive:axle shafts, rear bearings, center support
bearing, drive axle housing (including all internal parts), drive
shaft, retainers, supports, seals and gaskets, universal and
constant velocity joints. Four-Wheel/All-Wheel Drive: axle
shafts, support bracket, bearings (front and rear), center support
bearing, drive shafts, final drive housing (including all internal
parts), hubs-automatic front locking (four-wheel drive), locking
rings (four-wheel drive), seals and gaskets, universal and
constant velocity joints.
11

(2) Your vehicle's safety belts and air bag Supplemental
Restraint System (SRS) are covered for an extended Safety
Restraint Coverage Period, which lasts for five years or 60,000
miles, whichever occurs first.
(3) Your vehicle’s body sheet metal panels are covered for an
extended Corrosion Coverage Period, which lasts for five years,
regardless of miles driven. The extended warranty coverage only
applies if a body sheet metal panel becomes perforated due to
corrosion during normal use due to a manufacturing defect in
factory-supplied materials or factory workmanship. If aluminum
body panels have corrosion or rust damage, and the damage is
not the result of abnormal usage, vehicle accident, customer
actions and/or extreme environmental conditions, the corrosion
or rust damage repairs are covered for 5 years, unlimited miles.
For damage caused by airborne material (environmental fallout)
where there is no factory-related defect involved and therefore
no warranty − our policy is to provide free repair of paint damage
due to the airborne material for 12 months or 12,000 miles,
whichever occurs first.
(4) Your vehicle's direct injection diesel engine and certain engine
components are covered during the Diesel Engine Coverage
Period, which lasts for five years or 100,000 miles, whichever
occurs first. The following parts are covered during this extended
coverage period: the engine, cylinder block, heads and all internal
parts, intake and exhaust manifolds, timing gear, harmonic
balancer, valve covers, oil pan and pump, water pump, fuel
system (excluding fuel lines, fuel tank and frame mounted fuel
conditioning module sometimes referred to as the frame
mounted pump/filter/water separator or frame mounted fuel
filter/water separator), high pressure lines, gaskets and seals,
glow plugs, turbocharger, two-stage turbocharger assembly,
turbocharger actuator, powertrain control module, high pressure
fuel injection pump assembly, injectors, injection pressure sensor,
fuel rail pressure sensor, exhaust back pressure regulator and
sensor, exhaust pressure sensor, manifold pressure sensor,
intake air temperature sensor, crankshaft position sensor,
camshaft position sensor, accelerator switch.
12

Damage Caused by Use and/or the Environment
The New Vehicle Limited Warranty does not cover surface rust,
deterioration and damage of paint, trim, upholstery, and other
appearance items that result from use and/or exposure to the
elements. You, as the owner, are responsible for these items.
Some examples are:
• dings, dents
• cuts, burns, punctures or tears
• road salt
• tree sap, bird and bee droppings
• windstorm, lightening, hail
• earthquake
• freezing, water or flood
• stone chips, scratches (some examples are on paint and glass)
• windshield stress cracks. However, limited coverage onwindshield stress cracks will be provided for the first 12 months
or 12,000 miles (whichever occurs first), even though caused
by use and/or exposure to the elements.
Maintenance/Wear
The New Vehicle Limited Warranty does not cover: (1) parts and
labor needed to maintain the vehicle; and (2) the replacement of
parts due to normal wear and tear. You, as the owner, are
responsible for these items. See your Owner’s Manual. Some
examples of maintenance and normal wear are:
• oil changes
• oils, lubricants, other fluids
• oil/air filters
• tire rotation/inflation
• cleaning/polishing • clutch linings
• wiper blades*
• wheel alignments and tire
balancing*
• brake pad/lining*
* Ford will replace or adjust certain maintenance items when
necessary, free of charge during a limited period:
• Wiper blade replacements will be provided during the first six months in service, regardless of miles driven.
16

• Heating Element of BackWindow (3.0L diesel F-150
only)
• High Voltage Battery (Hybrid and Plug-in Hybrid vehicles
only)
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Intercooler Assembly - Engine Charger
• Inverter System Controller (Plug-in Hybrid vehicles
only)
• Jumper Assembly Charge Inlet to Charger (Hybrid and
Plug-in Hybrid vehicles only)
• Jumper Assembly DC/DC Converter to High Voltage
Panel (Hybrid and Plug-in
Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic
(OBD) System
• Module and Bracket Assembly Transmission
Inverter Control (Hybrid and
Plug-in Hybrid vehicles only) • Motor Electronics Coolant
Pump (Plug-in Hybrid
vehicles only)
• PCV system and Oil Filler Cap
• Onboard Charger (Plug-in Hybrid vehicles only)
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles
only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid
vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in
Hybrid vehicles only)
• Transmission Control Module (TCM) and
Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
27

• Heating Element of BackWindow (3.0L diesel F-150
only)
• High Voltage Battery (Hybrid and Plug-in Hybrid vehicles
only)
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Intercooler Assembly - Engine Charger
• Inverter System Controller (Plug-in Hybrid vehicles
only)
• Jumper Assembly Charge Inlet to Charger (Hybrid and
Plug-in Hybrid vehicles only)
• Jumper Assembly DC/DC Converter to High Voltage
Panel (Hybrid and Plug-in
Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic
(OBD) System
• Module and Bracket Assembly Transmission
Inverter Control (Hybrid and
Plug-in Hybrid vehicles only) • Motor Electronics Coolant
Pump (Plug-in Hybrid
vehicles only)
• PCV System and Oil Filler Cap
• Onboard Charger (Plug-in Hybrid vehicles only)
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles
only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid
vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in
Hybrid vehicles only)
• Transmission Control Module (TCM) and
Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
37