FORD EXPEDITION 2012 3.G Owners Manual

EXCEPTIONS
There are several exceptions to the Normal Schedule. They are listed
below:
Normal vehicle axle maintenance:Rear axles and power take-off
(PTO) units with synthetic fluid and light-duty trucks equipped with
Ford-design axles are lubricated for life; do not check or change fluid
unless a leak is suspected, service is required or the assembly has been
submerged in water. During long periods of trailer towing with outside
temperatures above 70°F (21°C) and at wide-open throttle for long
periods above 45 mph (72 km/h), non-synthetic rear axle fluids should
be changed every 3,000 miles (4,800 km) or three months, whichever
comes first. This interval can be waived if the axle is filled with 75W140
synthetic gear fluid meeting Ford specification WSL-M2C192-A, part
number F1TZ-19580-B or equivalent. Add friction modifier XL-3
(EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear
axles (refer toMaintenance product specifications and capacitiesin
theMaintenance and Specificationschapter for details).
Police/Taxi/Livery vehicle axle maintenance:Change rear axle fluid
every 100,000 miles (160,000 km). Rear axle fluid change may be waived
if the axle was filled with 75W140 synthetic gear fluid meeting Ford
specification WSL-M2C192-A, part number FITZ-19580-B or equivalent.
Add four ounces (118 mL) of additive friction modifier XL-3
(EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear
axles. The axle fluid should be changed anytime the axle has been
submerged in water.
E–450 and F–450/550 axle maintenance:Change rear axle fluid every
100,000 miles (160,000 km) under normal driving conditions. For
vehicles operated at or near maximum Gross Vehicle Weights, the rear
axle fluid should be changed every 50,000 miles (80,000 km). In
addition, this 50,000 mile (80,000 km) schedule should be observed
when the vehicles are operated under the Special Operating Conditions.
California fuel filter replacement:If the vehicle is registered in
California, the California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify the emission
warranty or limit recall liability prior to the completion of the vehicle’s
useful life. Ford Motor Company, however, urges you to have all
recommended maintenance services performed at the specified intervals
and to record all vehicle service.
Class A Motorhome:Change brake fluid every two years.
Scheduled Maintenance
391
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

Hot climate oil change intervals:If operating conditions are normal
and you drive your vehicle under typical, everyday conditionsandyou
are using an API performance category oil of SL or later (for example
SM, etc.) then you can follow the 7,500 mile (12,000 km) normal service
oil change intervals schedule. Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or locations with similar climates must
follow the oil change interval of 3,000 mile (4,800 km) if the owner is
using oils defined by the American Petroleum Institute (API)
performance category of API SK or earlier (for example SJ, etc).
Edge/MKX AWD only – vehicles operating off-road in sand during high
ambient temperatures must replace the AWD PTU (All-wheel drive
Power Transfer Unit) lube every 20,000 miles (32,000 km).
Engine air filter & cabin air filter replacement:Engine air filter and
cabin air filter life is dependent on exposure to dusty and dirty
conditions. Vehicles operated in these conditions will require frequent
inspection and replacement of the engine air filter and cabin air filter.
ENGINE COOLANT CHANGE RECORD
Initial change 6 years or 105,000 miles (168,000 km)
(whichever comes first)
After initial change Every 3 years or 45,000 miles (72,000 km)
Scheduled Maintenance
392
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

Engine coolant change log
DEALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
Scheduled Maintenance
393
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

A
ABS (see Brakes) .....................243
Accessory delay ..........................88
AdvanceTrac ..............................246
Airbag supplemental restraint
system ........................170, 174, 176
and child safety seats ............172
description ..............170, 174, 176
disposal ....................................179
driver airbag ............172, 175, 177
indicator light .................174, 179
operation .................172, 175, 177
passenger airbag .....172, 175, 177
side airbag ...............................174
Air cleaner filter ...............352, 357
Air suspension ...........................252
description ..............................252
Antifreeze
(see Engine coolant) ................332
Anti-lock brake system
(see Brakes) ......................243–244
Anti-theft system ..............129, 133
arming the system ..................133
disarming a triggered
system .....................................134
Armrests ....................................140
Audio system (see Radio) .........38
Automatic transmission
driving an automatic
overdrive .................................256
fluid, adding ............................352
fluid, checking ........................352
fluid, refill capacities ..............358
fluid, specification ..................358
Auxiliary input jack (Line in) ....46
Auxiliary power point .................85Axle
lubricant specifications ..........358
refill capacities ........................358
B
Battery .......................................330
acid, treating emergencies .....330
jumping a disabled battery ....300
maintenance-free ....................330
replacement, specifications ...357
servicing ..................................330
Belt-Minder.............................166
deactivating/activating the
Belt-Minder...........................169
Blind spot mirror ......................266
Booster seats .............................195
Brakes ........................................243
anti-lock ...........................243–244
anti-lock brake system (ABS)
warning light ...........................244
fluid, checking and adding ....351
fluid, refill capacities ..............358
fluid, specifications .................358
lubricant specifications ..........358
parking ....................................244
shift interlock ..................253, 255
Bulbs ............................................74
C
Capacities for refilling fluids ....358
Car2UHome Automation
System .........................................98
Cargo cover ...............................110
Cargo management system ......110
Cassette tape player ...................38
Cell phone use ..............................9
Changing a tire .........................290
Index
394
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

Child safety seats ......................184
in front seat ............................185
in rear seat ..............................185
LATCH .....................................188
recommendations ...................182
Child safety seats - booster
seats ...........................................195
Cleaning your vehicle
engine compartment ..............316
instrument panel ....................317
interior .............................318–319
plastic parts ............................316
washing ....................................314
waxing .....................................315
wheels ......................................315
wiper blades ............................317
Clock ............................................40
Compass, electronic ....................22
calibration .................................22
set zone adjustment ...........22, 34
Console ........................................84
overhead ..............................83–84
Controls
power seat ...............................141
steering column ........................96
Coolant
checking and adding ..............332
refill capacities ................335, 358
specifications ..........................358
Cruise control
(see Speed control) ....................94
Customer Assistance ................279
Ford Extended Service
Plan ..................................369, 372
Getting assistance outside the
U.S. and Canada .....................310
Getting roadside assistance ...279
Getting the service you
need .........................................306Ordering additional owner’s
literature .................................312
Utilizing the
Mediation/Arbitration
Program ...................................310
D
Daytime running lamps
(see Lamps) ................................70
Dipstick
automatic transmission
fluid ..........................................352
engine oil .................................327
Driving under special
conditions ..................259, 272, 275
sand .........................................274
snow and ice ...........................276
through water .................274, 278
E
Electronic message center ...19, 28
Emergencies, roadside
jump-starting ..........................300
running out of fuel .........299, 343
Emission control system ..........348
Engine ................................363–364
cleaning ...................................316
coolant .....................................332
fail-safe cooling .......................336
idle speed control ...................330
lubrication specifications .......358
refill capacities ........................358
service points ..........................324
starting after a collision .........281
Engine block heater .................241
Engine oil ..................................327
checking and adding ..............327
dipstick ....................................327
Index
395
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

filter, specifications ........329, 357
recommendations ...................329
refill capacities ........................358
specifications ..........................358
Event data recording ....................7
Exhaust fumes ..........................240
F
Fail safe cooling ........................336
Fleet MyKey programming ......113
Flexible Fuel Vehicle (FFV) ....338
Floor mats .........................104–105
Fluid capacities .........................358
Fog lamps ....................................69
Four-Wheel Drive vehicles .......267
control trac .............................267
description ..............................268
driving off road .......................270
indicator light .........................267
preparing to drive your
vehicle .....................................253
Fuel ............................................338
calculating fuel
economy ......................22, 30, 345
cap ...........................................340
capacity ...................................358
choosing the right fuel ...........342
detergent in fuel .....................343
filler funnel .............................343
filling your vehicle
with fuel ..................338, 340, 345
filter, specifications ........337, 357
fuel pump shut-off switch .....281
improving fuel economy ........345
octane rating ...........342, 363–364
quality ......................................343
running out of fuel .........299, 343safety information relating to
automotive fuels .....................338
Fuel - flex fuel vehicle
(FFV) .................................338, 342
Fuses ..................................282–283
G
Garage door opener ....................98
Gas cap (see Fuel cap) ............340
Gas mileage
(see Fuel economy) .................345
Gauges .........................................18
H
Hazard flashers .........................280
Headlamps ...................................69
aiming ........................................71
autolamp system .......................69
bulb specifications ....................75
daytime running lights .............70
flash to pass ..............................70
high beam .................................70
replacing bulbs .........................76
turning on and off ....................69
Heating
heating and air conditioning
system .................................58–59
Hood ..........................................323
I
Ignition .......................236, 363–364
Illuminated visor mirror .............82
Infant seats
(see Safety seats) .....................184
Index
396
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

Inspection/maintenance (I/M)
testing ........................................350
Instrument panel
cleaning ...................................317
cluster ........................................12
lighting up panel and
interior .......................................71
J
Jack ............................................290
positioning ...............................290
storage .....................................290
Jump-starting your vehicle ......300
K
Keyless entry system
autolock ...................................118
keypad .....................................128
locking and unlocking doors ..129
programming entry code .......128
Keys ...................................112, 131
positions of the ignition .........236
L
Lamps
autolamp system .......................69
bulb replacement
specifications chart ..................75
daytime running light ...............70
fog lamps ...................................69
headlamps .................................69
headlamps, flash to pass ..........70
instrument panel, dimming .....71
interior lamps .....................73, 75
replacing bulbs ...................76, 78
LATCH anchors .........................188
Liftgate ......................105, 109, 124
Lights, warning and indicator ....12anti-lock brakes (ABS) ..........244
Limited-slip axle .......................252
Loading instructions .................228
Load limits .................................222
Locks
autolock ...................................118
childproof ................................122
doors ........................................118
Lubricant specifications ...........358
Lug nuts ....................................298
Lumbar support, seats .............141
M
Message center .....................19, 28
english/metric button .........24, 34
system check button ................34
warning messages ...............24, 34
Mirrors ...................................89–90
automatic dimming rearview
mirror ........................................89
fold away ...................................90
heated ........................................91
programmable memory ..........125
signal .........................................91
Moon roof ....................................97
Motorcraftparts ..............321, 357
MyKey ........................................113
N
Navigation system .......................57
O
Octane rating ............................342
Oil (see Engine oil) ..................327
Index
397
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

P
Parental MyKey
programming .............................113
Parking brake ............................244
Parts
(see Motorcraftparts) ...........357
Pedals (see Power adjustable
foot pedals) .................................92
Power adjustable foot pedals .....92
Power deployable running
boards ..........................................92
Power distribution box
(see Fuses) .......................283, 286
Power door locks ......................118
Power liftgate ............................105
Power mirrors .............................90
Power point .................................85
Power steering ..........................251
fluid, checking and adding ....351
fluid, refill capacity ................358
fluid, specifications .................358
Power Windows ...........................87
Preparing to drive your
vehicle ........................................253
R
Radio ............................................38
Rear heated seats .....................154
Rear-view camera system .........263
Recommendations for
attaching safety restraints for
children ......................................182
Relays ........................................282
Remote entry system .......122–123illuminated entry ....................127
locking/unlocking
doors ................................123–124
opening the trunk ...................124
panic alarm .............................125
replacement/additional
transmitters .............................126
replacing the batteries ...........126
Reverse sensing system ...........260
Roadside assistance ..................279
Roll stability control .................246
S
Safety belts (see Safety
restraints) ..................161–162, 164
Safety Canopy ...........................176
Safety defects, reporting ..........313
Safety restraints ........161–162, 164
Belt-Minder...........................166
Belt-Minder,
deactivating/activating ...........169
extension assembly ................166
for adults .........................161–162
for children .............................180
warning light and chime ........166
Safety restraints - LATCH
anchors ......................................188
Safety seats for children ..........184
Safety Compliance
Certification Label ....................364
Satellite Radio Information ........55
Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............378
Seats ..........................................136
child safety seats ....................184
cleaning ...................................320
Index
398
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

climate control ........................145
heated ......................................154
memory seat ...................125, 143
SecuriCode keyless entry
system ........................................128
SecuriLock passive
anti-theft system ...............129, 131
Servicing your vehicle ..............322
Setting the clock .........................40
Snowplowing .................................6
SOS Post Crash Alert ...............179
Spark plugs,
specifications .............357, 363–364
Special notice
utility-type vehicles ....................6
Specification chart,
lubricants ...................................358
Speed control ..............................94
Stability system .........................246
Starting a flex fuel vehicle .......239
Starting your
vehicle ........................236–237, 239
jump starting ..........................300
Steering wheel
controls ......................................96
tilting .........................................82
SYNC..........................................57
T
Third-row power fold seat .......156
Tilt steering wheel ......................82
Tire Pressure Monitoring
System (TPMS)
Driving .....................................274
Tires, Wheels and Loading ....217Warning Displays ..........12, 24, 34
Tires ...........................202–203, 290
alignment ................................210
care ..........................................206
changing ..........................290, 294
checking the pressure ............206
inflating ...................................204
label .........................................216
replacing ..................................208
rotating ....................................211
safety practices .......................210
sidewall information ...............212
snow tires and chains ............221
spare tire .................................290
terminology .............................203
tire grades ...............................203
treadwear ........................202, 207
Towing .......................................229
recreational towing .................235
trailer towing ..........................229
wrecker ....................................304
Transmission .............................256
brake-shift interlock
(BSI) ................................253, 255
fluid, checking and adding
(automatic) .............................352
fluid, refill capacities ..............358
lubricant specifications ..........358
Turn signal ..................................72
U
Universal garage door opener ....98
USB port ......................................48
V
Vehicle Identification Number
(VIN) ..........................................365
Vehicle loading ..........................222
Index
399
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)

Ventilating your vehicle ...........240
W
Warning lights (see Lights) .......12
Washer fluid ..............................325
Water, Driving through .............278
Windows
power .........................................87rear wiper/washer
.....................81
Windshield washer fluid and
wipers
..........................................80
checking and adding fluid
.....325
liftgate reservoir
.....................325
replacing wiper blades
...........326
Wrecker towing
.........................304
Index
400
2012 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)