trailer GMC SONOMA 2003 Service Manual

15,000 Miles (25 000 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Inspect engine air cleanerlter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service. (See footnote†.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Change automatic transmissionuid andlter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.If you do not use your vehicle under any of these
conditions, change theuid andlter every 50,000 miles
(83 000 km).
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
22,500 Miles (37 500 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
6-19
2003 - Sonoma OM

30,000 Miles (50 000 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑For Two-Wheel-Drive vehicles only: Clean and
repack the front wheel bearings (or at each
brake relining, whichever occursrst).
❑Change automatic transmissionuid andlter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
If you do not use your vehicle under any of these
conditions, change theuid andlter every 50,000 miles
(83 000 km).❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
❑4.3L V6 Engine Only: Replace fuellter.An Emission
Control Service. (See footnote†.)
❑Replace engine air cleanerlter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service.
37,500 Miles (62 500 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
6-20
2003 - Sonoma OM

45,000 Miles (75 000 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Inspect engine air cleanerlter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service. (See footnote†.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Change automatic transmissionuid andlter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
If you do not use your vehicle under any of these
conditions, change theuid andlter every 50,000 miles
(83 000 km).❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
50,000 Miles (83 000 km)
❑If you haven’t used your vehicle under severe
conditions listed previously and, therefore, haven’t
changed your automatic transmissionuid, change
both theuid andlter. Manual transmission
uid doesn’t require change.
52,500 Miles (87 500 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
6-21
2003 - Sonoma OM

60,000 Miles (100 000 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑For Two-Wheel-Drive vehicles only: Clean and
repack the front wheel bearings (or at each
brake relining, whichever occursrst).
❑Change automatic transmissionuid andlter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
If you do not use your vehicle under any of these
conditions, change theuid andlter every 50,000 miles
(83 000 km).❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
❑4.3L V6 Engine Only: Replace fuellter.An Emission
Control Service. (See footnote†.)
❑Replace engine air cleanerlter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service.
67,500 Miles (112 500 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
6-22
2003 - Sonoma OM

75,000 Miles (125 000 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Inspect engine air cleanerlter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service. (See footnote†.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Change automatic transmissionuid andlter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.If you do not use your vehicle under any of these
conditions, change theuid andlter every 50,000 miles
(83 000 km).
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
82,500 Miles (137 500 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
6-23
2003 - Sonoma OM

90,000 Miles (150 000 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑For Two-Wheel-Drive vehicles only: Clean and
repack the front wheel bearings (or at each
brake relining, whichever occursrst).
❑Change automatic transmissionuid andlter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.If you do not use your vehicle under any of these
conditions, change theuid andlter every 50,000 miles
(83 000 km).
❑Replace fuellter.An Emission Control Service.
(See footnote†.)
❑Replace engine air cleanerlter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.
An Emission Control Service.
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
97,500 Miles (162 500 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
6-24
2003 - Sonoma OM

Driving on Snow or Ice....................................4-37
Driving Through Deep Standing Water...............4-30
Driving Through Flowing Water.........................4-30
Driving Uphill..................................................4-19
Driving with a Trailer.......................................4-57
E
Electrical System
Add-On Equipment......................................5-88
Fuses and Circuit Breakers...........................5-89
Headlamps.................................................5-88
Power Windows and Other Power Options......5-88
Windshield Wiper Fuses...............................5-88
Electronic Transfer Case..................................2-30
Emissions Inspection and Maintenance
Programs...................................................3-32
Engine
Air Cleaner/Filter.........................................5-18
Battery.......................................................5-42
Check and Service Engine Soon Light............3-29
Compartment Overview................................5-10
Coolant......................................................5-25
Coolant Heater............................................2-24
Coolant Temperature Gage...........................3-29
Cooling System Inspection............................6-31
Exhaust.....................................................2-37
Fan Noise..................................................5-36Engine (cont.)
Oil .............................................................5-13
Overheating................................................5-28
Starting......................................................2-22
Engine Compartment Fuse Block......................5-91
Engine Coolant Level Check.............................6-26
Engine Oil Additives........................................5-16
Engine Oil Level Check...................................6-26
Entry Lighting.................................................3-14
Environmental Concerns..................................4-15
Exit Lighting...................................................3-14
Express Down Window....................................2-15
Extended Cab (Jump Seat)..............................1-48
Extender, Safety Belt.......................................1-29
Exterior Lamps...............................................3-10
F
Fabric/Carpet.................................................5-79
Filter
Engine Air Cleaner......................................5-18
Finding a PTY Station.....................3-43, 3-50, 3-60
Finding a Station....................3-38, 3-40, 3-48, 3-57
Finish Care....................................................5-83
Finish Damage...............................................5-85
Five-Speed....................................................2-28
Fixed Mast Antenna........................................3-69
Flash-To-Pass Feature....................................... 3-6
5
2003 - Sonoma OM

Headlamps (cont.)
Halogen Bulbs............................................5-50
One-Piece Front Turn Signal Lamps...............5-52
Two-Piece Front Turn Signal Lamps...............5-53
Heated Seats................................................... 1-5
Heating.........................................................3-18
Highway Hypnosis...........................................4-34
Hill and Mountain Roads..................................4-34
Hitches..........................................................4-56
Hood
Checking Things Under.................................. 5-8
Release....................................................... 5-9
Horn ............................................................... 3-4
How to Add Coolant to the Coolant
Recovery Tank............................................5-32
How to Add Coolant to the Radiator..................5-34
How to Add Fluid....................................5-22, 5-24
How to Check................................5-20, 5-23, 5-59
How to Check and Add Fluid
............................5-25
How to Check Lubricant
..........................5-47, 5-49
How to Check Power Steering Fluid
..................5-37
How to Inspect the Engine Air Cleaner/Filter
.......5-19
How to Use This Manual
...................................... ii
How to Wear Safety Belts Properly
...................1-15
Hydraulic Clutch
.............................................5-24
Hydraulic Clutch System Check
........................6-27
Hydroplaning
..................................................4-30I
If No Steam Is Coming From Your Engine..........5-29
If Steam Is Coming From Your Engine...............5-28
If the Light Is Flashing.....................................3-30
If the Light Is On Steady.................................3-31
If You Are Stuck in Sand, Mud, Ice or Snow.......4-40
If You Do Decide To Pull A Trailer.....................4-52
If You’re Caught in a Blizzard...........................4-38
Ignition Positions.............................................2-20
Ignition Transmission Lock Check......................6-29
Infants and Young Children, Restraints...............1-32
Inflation–Tire Pressure...................................5-58
Inspection
Brake System.............................................6-32
Engine Cooling System................................6-31
Exhaust System..........................................6-31
Fuel System...............................................6-31
Part C - Periodic Maintenance.......................6-31
Steering, Suspension and Front Drive
Axle Boot and Seal..................................6-31
Throttle System...........................................6-32
Transfer Case and Front Axle
(Four-Wheel Drive)...................................6-32
Installing a Garage Door Opener.......................2-43
Instrument Panel
Cluster.......................................................3-21
Overview..................................................... 3-2
7
2003 - Sonoma OM

Locks
Door ........................................................... 2-8
Leaving Your Vehicle....................................2-11
Lockout Protection.......................................2-11
Power Door .................................................. 2-9
Programmable Automatic Door Locks............... 2-9
Rear Door Security Locks.............................2-11
Long Trip/Highway Definition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-18
Loss of Control...............................................4-12
Low Fuel Warning Light...................................3-35
Luggage Carrier..............................................2-50
Lumbar
Manual Controls............................................ 1-4
Power Controls............................................. 1-5
M
Maintenance, Normal Replacement Parts............5-96
Maintenance Schedule
At Each Fuel Fill.........................................6-26
At Least Four Times a Year..........................6-27
At Least Once a Month................................6-26
At Least Once a Year..................................6-28
At Least Twice a Year..................................6-26Maintenance Schedule (cont.)
Brake System Inspection..............................6-32
Engine Cooling System Inspection.................6-31
Exhaust System Inspection...........................6-31
Fuel System Inspection................................6-31
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-18
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-26
Part C - Periodic Maintenance Inspections......6-31
PartD-Recommended Fluids and
Lubricants...............................................6-33
PartE-Maintenance Record........................6-35
Selecting the Right Schedule
.......................... 6-5
Short Trip/City Scheduled Maintenance
............. 6-7
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection
...................6-31
Throttle System Inspection
............................6-32
Transfer Case and Front Axle
(Four-Wheel Drive) Inspection
....................6-32
Using Your
................................................... 6-4
Your Vehicle and the Environment
................... 6-2
Maintenance When Trailer Towing
.....................4-60
Making Turns
.................................................4-58
9
2003 - Sonoma OM

Top Strap Anchor Location...............................1-43
Torque Lock...................................................2-35
Total Weight on Your Vehicle’s Tires..................4-55
Towing
Recreational Vehicle.....................................4-42
Towing a Trailer..........................................4-51
Your Vehicle...............................................4-42
Trailer
Recommendations.......................................4-50
Trailer Brakes.................................................4-57
Transfer Case................................................5-48
Transfer Case and Front Axle
(Four-Wheel Drive) Inspection.......................6-32
Transmission
Fluid, Automatic...........................................5-20
Fluid, Manual..............................................5-23
Up-Shift Light..............................................3-27
Transmission Operation, Automatic....................2-25
Transmission Operation, Manual........................2-28
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-10
Transportation Options...................................... 7-7
Traveling to Remote Areas...............................4-15
Trip Odometer................................................3-23
Truck-Camper Loading Information....................4-48
Turn and Lane-Change Signals.......................... 3-5
Turn Signal/Multifunction Lever........................... 3-5
Turn Signals When Towing a Trailer..................4-58
Two-Piece Composite Headlamp System............5-51
Two-Tiered Loading.........................................4-48U
Underbody Flushing Service.............................6-30
Understanding Radio Reception........................3-67
Uniform Tire Quality Grading
............................5-63
United States
................................................... 7-4
Up-Shift Light
.........................................2-29, 3-27
Used Replacement Wheels
..............................5-66
Using Cleaner on Fabric
..................................5-80
Using RDS
....................................3-42, 3-50, 3-59
Using Song List Mode
.....................................3-65
Using the Recovery Hooks
...............................4-41
V
Vehicle
Control
........................................................ 4-5
Damage Warnings
........................................... iv
Loading
......................................................4-46
Parking Your
...............................................2-36
Symbols
......................................................... iv
Vehicle Identification
Number (VIN)
.............................................5-87
Service Parts Identification Label
...................5-88
Vehicle Personalization
Memory Seat
..............................................2-54
Vehicle Storage
..............................................5-42
Ventilation Adjustment
......................................3-19
15
2003 - Sonoma OM