ECU HONDA CIVIC HATCHBACK 2002 7.G User Guide

CONT INUED
To close the hood, lif t it up slightly to
remove the support rod f rom the
hole. Put the support rod back into
its holding clip. Lower the hood to
about a f oot (30 cm) above the
fender,thenletitdrop.
After closing the hood, make sure it
is securely latched.Lif t the hood up most of the way.
The hydraulic supports will lif t it
uptherestof thewayandholditup.
Pull the support rod out of its clip
and insert the end into the hole on
the f ront of the hood around the
center. 3.
3.
6-cylinder models
4-cylinder models
Bef ore Driving
Service Station Procedures
197
SSUUPPPPOORRTTRROODD

Store or secure all items that could
be thrown around and hurt
someone during a crash.
Be sure items placed on the f loor
behind the f ront seats cannot roll
under the seats and interf ere with
the driver’s ability to operate the
pedals, or with the proper
operation of the seats.
Keep the glove box closed while
driving. If the lid is open, a
passenger could injure their knees
during a crash or sudden stop.
This f igure includes the total weight
of all occupants, cargo, accessories,
and the tongue weight if you are
towing a trailer.
The f inal number is the total weight
of cargo you can carry.
If you are towing a trailer, add the
tongue weight to the number
above.
Add up the weight of all occupants.
To f igure out how much cargo you
can carry:
The maximum load for your car is
850 lbs (395 kg).
Do not put any items on top of the
rear shelf . They can block your
view and be thrown around the car
during a crash.
Subtract the total f rom 850 lbs
(395 kg). Carrying Items in the Passenger
Compartment
Load Limit
Carrying Cargo
Bef ore Driving205
Overloading or improper
loading can affect handling and
stability and cause a crash in
which you can be hurt or killed.
Follow all load limits and other
loading guidelines in thismanual.

Always use saf ety chains. Make sure
they are secured to both the trailer
and hitch, and that they cross under
the tongue so they can catch the
trailer if it becomes unhitched.
Leave enough slack to allow the
trailer to turn corners easily, but do
not let the chains drag on the ground.
Honda recommends that any trailer
having a total weight of 1,000 lbs
(450 kg) or more be equipped with
its own electric or surge-type brakes.
If you choose electric brakes, be
sure they are electronically actuated.
Do not attempt to tap into your
vehicle’s hydraulic system. No
matter how successf ul it may seem,
any attempt to attach trailer brakes
to your vehicle’s hydraulic system
will lower braking ef f ectiveness and
create a potential hazard.
Any hitch used on your vehicle must
be properly bolted to the underbody.
Discuss your needs with your trailer
sales or rental agency, and f ollow the
guidelines in the rest of this section.
Also make sure that all equipment is
properly installed and that it meets
f ederal, state, province, and local
regulations.
Towing can require a variety of
equipment, depending on the size of
your trailer, how it will be used, and
how much load you are towing.
The best way to conf irm that vehicle
and trailer weights are within limits
is to have them checked at a public
scale.
Using a suitable scale or a special
tongue load gauge, check the tongue
load the f irst time you set up a
towing combination (a f ully-loaded
vehicle and trailer), then recheck the
tongue load whenever the conditions
change.
Towing a Trailer
Driving
Saf et y Chains
Trailer Brakes
HitchesT owing Equipment and
A ccessories
Checking L oads
229

Many states and Canadian provinces
require special outside mirrors when
towing a trailer. Even if they don’t,
you should install special mirrors if
you cannot clearly see behind you, or
if the trailer creates a blind spot.
Askyourtrailersalesorrental
agency if any other items are
recommended or required f or your
towing situation.When preparing to tow, and bef ore
driving away, be sure to check the
f ollowing:
Your vehicle tires and spare are
properly inf lated (see page ),
and the trailer tires and spare are
inflated as recommended by the
trailer maker.
The vehicle has been properly
serviced, and the tires, brakes,
suspension, and cooling system
are in good operating condition.
All weights and loads are within
limits (see pages and ).
Thehitch,safetychains,andany
other attachments are secure.
Allitemsonandinthetrailerare
properly secured and cannot shif t
while you drive.
The lights and brakes on your
vehicle and the trailer are working
properly. 227 228
285
Additional Trailer EquipmentPre-T ow Checklist
Towing a Trailer
Driving231

When the coolant stops draining,
tightenthedrainplugatthe
bottom of the radiator.
Put a new washer on the drain bolt,
then reinstall the drain bolt in the
engine block. Tighten it securely.
Tightening torque:Tighten the drain bolt at the rear
of the engine cylinder block
securely.
Tightening torque:
Loosen the bleeder bolt on top of
the engine.
Pour Honda All Season
Antif reeze/Coolant Type 2 into
the radiator. This coolant is a
mixture of 50 percent anti-f reeze
and 50 percent water. Pre-mixing
is not required.
Tighten the bleeder bolt when
coolant comes out in a steady
stream with no bubbles.
7.
6.
5.
4-cylinder models 6-cylinder models 4-cylinder models
Cooling Syst em
Maint enance260
FFIILLLLEERRNNEECCKK
44--ccyylliinnddeerrmmooddeellssFFiilllluuppttoohheerree
FFIILLLLEERRNNEECCKK
66--ccyylliinnddeerrmmooddeellssFFiilllluuppttoohheerree
RREESSEERRVVEETTAANNKKCCAAPPRREESSEERRVVEETTAANNKK
66--ccyylliinnddeerrmmooddeellssHHOOLLDDEERR
61 lbf·ft (83 N·m , 8.5 kgf·m)
7 lbf·ft (10 N·m , 1.0 kgf·m)

Insert the dipstick all the way into
the transmission securely as
shown in the illustration.
Remove the dipstick and check
the f luid level. It should be
between the upper and lower
marks.
Check the f luid level with the engine
at normal operating temperature.
Park the car on level ground. Shut
of f the engine.
Remove the dipstick (yellow loop)
f rom the transmission and wipe it
with a clean cloth.
Insert the dipstick all the way back
into the transmission securely as
shown in the illustration.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
1. 2.3. 4.
6.
6-cylinder models
T ransmission Fluid
Maint enance
Automatic Transmission
264
UUPPPPEERRMMAARRKK
DDIIPPSSTTIICCKKLLOOWWEERRMMAARRKK

´ µ
Torque the spark plug. (If you do
not have a torque wrench, tighten
the spark plug two-thirds of a turn
af ter it contacts the cylinder head.)
Tightening torque:
Put the new spark plug into the
socket; then screw it into the hole.
Screw it in by hand so you do not
crossthread it.
Install the ignition coil. Reinstall
the hexagon socket head cap bolt.Push the wire connector onto the
ignition coil. Make sure it locks in
place.
Spark Plug Gap: Reinstall the cover on the front
cylinder bank while putting its
mounting clip in the hole on the
passenger’s side. Secure the cover
by turning the heads of the two
holding clips one-quarter turn
clockwise with a f lat-tipped
screwdriver.
Repeat this procedure f or the
other f ive spark plugs.
NGK:
DENSO:
6. 7.
8.9.
10. 11.
Specif ications:
Spark Plugs (6-cylinder Models)
Maint enance275
13 lbf·ft (18 N·m , 1.8 kgf·m) 0.04 in (1.1 mm)PKJ16CR-L11
PZFR5F-11
0
0.1 mm
Tighten the spark plugs caref ully. A
spark plug that is too loose can
overheat and damage the engine.
Overtightening can cause damage to
the threads in the cylinder head.

Tighten the wheel nuts securely in
the same crisscross pattern. Have
the wheel nut torque checked at
the nearest automotive service
f acility.
Tighten the wheel nuts to:Remove the center cap before
storing the f lat tire in the trunk
well.
15.
16.
CONT INUED
LX with ABS, SE, EX, EX V-6 models
Changing a Flat T ire
T aking Care of t he Unexpect ed317
66--ccyylliinnddeerrmmooddeell44--ccyylliinnddeerrmmooddeell
80 lbf·ft (108 N·m , 11 kgf·m)

ÎÎ
Î
Î
On Canadian models
1 23456 7 89
10111213 15 A
10 A
7.5 A
7.5 A
7.5 A 15 A
7.5 A
7.5 A
7.5 A
7.5 A 15 A
30 A
7.5 A IG1 Fuel Pump
IG1 SRS
IG2 HAC
R/C Mirror
IG2 Day Light
ECU (ECM/PCM), Cruise
Control
IG1 Moonroof , Washer
ACC
Instrument Panel, Back-up
Lights
IG1 Turn Signals
IG1 Coil
IG1 Wiper
STS Moonroof
Driver Power Seat Recline
Assistant Power Seat
Recline
Driver Power Seat Slide
Assistant Power Seat Slide
Daytime Running Light
Rear Lef t Power Window
Front Right Power Window
Radio, Cigarette Lighter
Small Lights
Interior Light, Courtesy
Lights
Power Door Locks
Clock
ABS Motor Check
Front Left Power Window
Rear Right Power Window
On Canadian models
123 4 56789
1011 12 13141516 30 A
20 A
20 A
20 A
20 A
10 A
20 A
20 A
20 A
10 A
7.5 A
20 A
7.5 A
7.5 A 20 A
20 A
No. Amps. Circuits Protected Circuits Protected
No. Amps.
Fuses
T aking Care of t he Unexpect ed335
INTERIOR FUSE BOXES
:
DRIVER’S SIDE
PASSENGER’S SIDE
:

Î
Î.................................
Parking Brake . 95
.................................
Parking Lights . 64
..
Parking Over Things that Burn . 351
.............................
PGM-FI System . 350
..................
Polishing and Waxing . 305
...................................
Pollen Filter . 282
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 19
............................
Protecting Adults . 12
...
Additional Safety Precautions . 20
.....
Advice f or Pregnant Women . 19
........................
Protecting Children . 21
.......................
Protecting Inf ants . 30
.......
Protecting Larger Children . 36
.........
Protecting Small Children . 33
Using Child Seats with
.....................................
Tethers . 39
.................................
Using LATCH . 40
........................................
Saf ety Belts . 8 .........
Safety Defects, Reporting . 358
.................................
Saf ety Features . 7
...........................................
Airbags . 9
..................................
Door Locks . 10
..........................
Head Restraints . 10
.......................................
Seat Belts . 8
.....................
Seats & Seat-Backs . 10
.............
Saf ety Labels, Location of . 52
...............................
Saf ety Messages . ii
...........................................
Seat Belts . 8
...............
Additional Information . 42
Automatic Seat Belt
...............................
Tensioners . 43
.....................................
Cleaning . 307
......................
Lap/Shoulder Belt . 42
................................
Maintenance . 44
Reminder Light and
................................
Beeper . 42, 56
...................
System Components . 42
...............
Use During Pregnancy . 19
........................
Seats, Adjusting the . 82
............................
Security System . 184
...............................
Serial Number . 340
...........................
Service Intervals . 240
...........................
Service Manual . 359
.........
Service Station Procedures . 194
...................
Radiator Overheating . 323
...
Radio/Cassette Sound System . 119
..
Rear Lights, Bulb Replacement . 296
..........................
Rear Seat Armrest . 88
..........................
Rear Seat, Folding . 87 ............................
Rear View Mirror . 93
.................
Rear Window Def ogger . 68
.........
Reclining the Seat Backs . 82, 85
.......
Recommended Shif t Speeds . 212
.............................
Reminder Lights . 55
.......................
Remote Transmitter . 75
Replacement Inf ormation
.................
Air Cleaner Element . 269
.......................................
Coolant . 257
................
Engine Oil and Filter . 252
..........................................
Fuses . 332
................................
Light Bulbs . 292
....................................
Schedule . 240
.......................
Spark Plugs . 272, 274
...........................................
Tires . 287
.............................
Wiper Blades . 279
Replacing Seat Belts Af ter a ............................................
Crash . 44
.................
Reserve Tank, Coolant . 200
...............................
Restraint, Child . 21
..................
Reverse Gear Position . 214
................................
Rotation, Tire . 287
Index
R
S
VI