ignition HONDA FIT 2008 1.G Workshop Manual

Î
Î
No.Amps. Circuits Protected No. Amps.
Amps. Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
80 A Battery 9
10
11
12
13
14
15
16 30 A
30 A
30 A
20 A
20 A
10 A
30 A
15 A
80 A
60 A
50 A
30 A
40 A
40 A
(30 A) 10 A Battery
EPS
Ignition
ABS
Blower Relay
Power Window
(HAC Option)
Back Up Small Light
Cooling Fan
Condenser Fan, MG Clutch
Right Headlight
Left Headlight
Hazard
ABS F/S
Horn, Stop
: If equipped
Fuse Locations
T aking Care of t he Unexpect ed
237
Primary Fuse Box
PRIMARY
Secondary Fuse Box (On the battery)
UNDER-HOOD FUSE BOXES
\f—\f—y\f\fy
(
\fy\fy
2008 Fit

µµ
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.
The operator
loads your vehicle on the back of a
truck.
Therearetwowaystotowyour
vehicle: If , due to damage, your vehicle must
be towed with the f ront wheels on
the ground, do this:
Release the parking brake.
Shif t the transmission to neutral.
The tow
truck uses two pivoting arms that go
under the tires (f ront) and lif t them
of f the ground. The other two tires
remain on the ground. Start the engine.
Release the parking brake.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.
With the f ront wheels on the ground,
do not tow the vehicle more than 50
miles (80 km), and keep the speed
below 35 mph (55 km/h).
Shif t to D position and hold f or 5
seconds, then to N. Let the engine
runfor3minutes,thenturnitoff.
Turn of f the engine.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.
Manual transmission:
Automatic transmission:
Flat -bed Equipment
Wheel-lif t Equipment
T his is the best way to
transport your vehicle.
T his is an
acceptable way to tow your
vehicle.
Emergency Towing
238
Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine (automatic transmission), your
vehicle must be transported with the
f ront wheels of f the ground.
\f—\f—y\f
y
(
\fy\fy
2008 Fit

If your vehicle gets stuck in sand,
mud, or snow, call a towing service
to pull it out (see page ).
For very short distances, such as
f reeing the vehicle, you can use the
detachable towing hook that mounts
on the anchor in the f ront bumper.To use the towing hook:Take the towing hook and the
extension out of the tool kit in the
cargo area.
Lift the upper part of the cover
f rom the bumper by pushing the
lower part with your f inger. Put a
cloth into the space behind the
upper part of the cover. Using the
extension, remove the cover f ully.
1.
2.
238
CONT INUED
Emergency Towing, If Your Vehicle Gets Stuck
If Your Vehicle Gets Stuck
T aking Care of t he Unexpect ed
239
Trying to lif t or tow your vehicle by the
bumpers will cause serious damage.
The bumpers are not designed to
support the vehicle’s weight.
The steering system can be damaged if
the steering wheel is locked. Leave the
ignition switch in the ACCESSORY (I)
position, and make sure the steering
wheel turns f reely bef ore you begin
towing.
\f—\f—y\fy
(
\fy\fy
2008 Fit

µ
Thediagramsinthissectiongive
you the dimensions and capacities of
your vehicle and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.
................
Identif ication Numbers .242
................................
Specif ications .244
DOT Tire Quality Grading
......................
(U.S. Vehicles) .246
Unif orm Tire Quality ..................................
Grading .246
.................................
Treadwear .246
......................................
Traction .246
.............................
Temperature .247
.................................
Tire Labeling .248
Tire Pressure Monitoring System
(TPMS) Required Federal ............................
Explanation .249 .......................
Emissions Controls .251
.....................
The Clean Air Act .251
Crankcase Emissions Control
....................................
System .251
Evaporative Emissions Control ....................................
System .251
Onboard Ref ueling Vapor ................................
Recovery .251
...
Exhaust Emissions Controls .252
....................
PGM-FI System .252
Ignition Timing Control
................................
System .252
Exhaust Gas Recirculation ...................
(EGR) System .252
Three Way Catalytic ...........................
Converter .252
....................
Replacement Parts .252
..
Three Way Catalytic Converter .253
........................
Emissions Testing .254
T echnical Inf ormation
Technical Inf ormation
241
\f—\f—y\fy
(
\fy\fy
2008 Fit

The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
quality parts may increase the
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The exhaust emissions controls
include f our systems: PGM-FI,
ignition timing control, exhaust gas
recirculation, and three way catalytic
converter. These f our systems work
together to control the engine’s
combustion and minimize the
amount of HC, CO, and NOx that
come out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It then controls how much f uel to inject
under all operating conditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
2
2
Exhaust Emissions Controls Replacement Parts
Emissions Cont rols
PGM-FI System Ignit ion T iming Cont rol Syst em
Exhaust Gas Recirculat ion (EGR)Syst em
Three Way Catalytic Converter
252
\f—\f—y\fy
(
\fy\fy
2008 Fit

CONT INUED
....................................
Accessories .144
ACCESSORY (Ignition Key
.......................................
Position) .78
...............
Accessory Power Socket .99
....................
Additives, Engine Oil .188
.......
Adjusting the Steering Wheel .75
...........................
Advanced Airbags .27
...............................
Airbag (SRS) .9,22
..............
Air Conditioning System .102
.........................................
Usage .103
.......................
Air Pressure, Tires .210
.......................
Alcohol in Gasoline .136
......................................
Antif reeze .190
Anti-lock Brakes (ABS)
...............................
Indicator .62,168
...................................
Operation .168
..............
Anti-thef t, Audio System .128
.
Anti-thef t Steering Column Lock .78
................................
Audio System .107
...
Automatic Seat Belt Tensioners .20
.............
Automatic Speed Control .131
..............
Automatic Transmission .157
..........................
Capacity, Fluid .244
...............
Checking Fluid Level .193 ..........................
Paddle Shif ters .162
.......................................
Shif ting .157
Shif t Lever Position
...............................
Indicators .157
................
Shif t Lever Positions .158
....................
Shif t Lock Release .161
......................
Auxiliary Input Jack .127
............................
Capacities Chart .244
.............
Carbon Monoxide Hazard .53
Battery
Charging System ...........................
Indicator .60,230
............................
Jump Starting .226
..............................
Maintenance .214
............................
Specif ications .245
..............................
Bef ore Driving .135
....................................
Belts,Seat.8,18
...........................
Beverage Holders .98
..................................
Booster Seats .50
Brakes
...........
Anti-lock System (ABS) .168
.............
Break-in, New Linings .136
....................
Bulb Replacement .201
...........................................
Fluid .195
.........................................
Parking .96 .................
System Indicator .60,232
..........................
System Design .167
........................
Wear Indicators .167
.............................
Braking System .167
.................
Break-in, New Vehicle .136
..
Brightness Control, Instruments .74
..................
Brights, Headlights .72,73
Bulb Replacement
..........................
Back-up Lights .201
..............................
Brake Lights .201
Front Parking Lights/
...
Front Side Marker Lights .198
.................................
Fog Lights .199
.................................
Headlights .196
.........
High-mount Brake Light .202
............................
Specif ications .245
....................................
Taillights .201
............
Turn Signal Lights .198,201
..............................
Bulbs, Halogen .196
Index
A
B
C
INDEX
I
\f—\f—y\f\fy
(
\fy\fy
2008 Fit

ÎÎ
...............
Gas Mileage, Improving .141
..........................................
Gasohol .136
.........................................
Gasoline .136
.....................
Low Fuel Indicator .62
...........................................
Gauge .68
................
Octane Requirement .136
........................
Tank, Ref ueling .137
................
Gas Station Procedures .137
Gauges
...............................................
Fuel .68
Gearshif t Lever Positions ..........
Automatic Transmission .158
..............
Manual Transmission .155 ........................................
Glove Box .98
Gross Vehicle Weight Rating
.....................................
(GVWR) .148
.................................................
Fuel .136
..........
Check Fuel Cap Indicator .68
......................
Fill Door and Cap .137
.....................
Low Fuel Indicator .62
...........................................
Gauge .68
................
Octane Requirement .136
...............................
Oxygenated .136
........................
Tank, Ref ueling .137
...............................
Fuel Economy .141
.....................
Fuses, Checking the .234 .............
Halogen Headlight Bulbs .196
..............
Hazard Warning Flashers .74
Headlights
........................................
Aiming .196
.......
Daytime Running Lights .73
..................
High Beam Indicator .65
.........................
Reminder Chime .73
........
Replacing Halogen Bulbs .196
...................................
Turning on .73
..............................
Head Restraints .87
.....................
Heating and Cooling .102
............................
High Beam Lever .73
.......................
Hood, Opening the .138
..............................................
Horn.4,70
...........................
Hydraulic Clutch .195
...
Identif ication Number, Vehicle .242 Ignition
..............................................
Keys .76
...........................................
Switch .78
............
Timing Control System .252
........................
Immobilizer System .77
.........
Important Safety Precautions .6
Index
G H
I
IV
\f—\f—y\f\fy
(
\fy\f
y
2008 Fit

ÎÎÎ Î
CONT INUED
..................................................
Keys .76
.................
Jacking up the Vehicle .221
.......................................
Jack, Tire .219
................................
Jump Starting .226 .......................
Label, Certif ication .242
.................
Lane Change, Signaling .72
..................
Lap/Shoulder Belts .14,19
...........
LATCH Anchorage System .43
Lights
....................
Bulb Replacement .196
.......................................
Indicator .59
.........................................
Parking .72
..................................
Turn Signal .72
....................................
Load Limits .147
......
LOCK (Ignition Key Position) .78
Locks
.......
Anti-thef t Steering Column .78
..........................
Childproof Door .80
.................................
Power Door .79
........................................
Tailgate .81
........................
Low Coolant Level .140
.........................
Low Fuel Indicator .62
Indicators
......
ABS (Anti-Lock Brake) .62,168
Brake (Parking and Brake
............................
System) .60,232
................
Charging System .60,230
...........................
Check Fuel Cap .68
.............................
Cruise Control .65
............
Door and Tailgate Open .62
DRL (Daytime Running
..................................
Lights) .65
.
EPS (Electric Power Steering) .62
.....................................
Fog Light .64
...................................
High Beam .65
......................
High Temperature .63
........
Key (Immobilizer System) .66
.....................................
Lights On .64
......................................
Low Fuel .62
................
Low Oil Pressure .60,230
.......................
Low Temperature .63
............
Low Tire Pressure .64,170
..........
Maintenance Minder .66,179
...
Malf unction Indicator Lamp .231
.................
Passenger Airbag Of f .31
..............
Seat Belt Reminder .18,60
..........................
Security System .66
.....................
Side Airbag Of f .31,61 .........................................
SRS .30,61
.................................
TPMS .64,171
Turn Signal and Hazard
...................................
Warning .63
..............................
Washer Level .65
.........
Indicators, Instrument Panel .59
...............................
Inf ant Restraint .39
......................................
Inf ant Seats .39
............
Tether Anchorage Point .47
...................
Inf lation, Proper Tire .209
........
Recommended Pressures .210
...................................
Inside Mirror .95
.............................
Inspection, Tire .210
....................
Installing a Child Seat .42
............................
Instrument Panel .59
........
Instrument Panel Brightness .74
..............
Instruments and Controls .57
.................................
Interior Lights .99
........................................
Introduction .i
Index
L K
J
INDEX
V
——yy
(
yy
2008 Fit

...
Low Oil Pressure Indicator .60,230
................................
Lower Anchors .43
...
Lubricant Specif ications Chart .244
...........
Luggage, Storing (Cargo) .146
...........
Luggage Net (Cargo Net) .150
..................................
Maintenance .177
......
Main Items and Sub Items .182
........................................
Minder .179
.........................
Minder Indicator .66
Owner’s Maintenance
...................................
Checks .184
..........................................
Saf ety .178
.......
Malf unction Indicator Lamp .231
...................
Manual Transmission .155
...............
Checking Fluid Level .194
.......................................
Shif ting .155
........
Manual Transmission Fluid .194
.........................
Meters, Gauges .59,67
...................
Methanol in Gasoline .136
..........................
Mirrors, Adjusting .95
...............
Modif ying Your Vehicle .144 ...................
Neutral Gear Position .159
..................
New Vehicle Break-in .136
.....................
Normal Shif t Speeds .156
...................
NOTICE, Explanation of .i
...............
Numbers, Identif ication .242
...
Octane Requirement, Gasoline .136
.........................................
Odometer .68
...............................
Odometer, Trip .67
Oil
........................
Change, How to .188
......................
Change, When to .179
......................
Checking Engine .139
..............
Pressure Indicator .60,230
Selecting Proper Viscosity
......................................
Chart .187
...........
ON (Ignition Key Position) .78
Onboard Ref ueling Vapor
....................................
Recovery .251
..............................
Outside Mirrors .95
....................
Overheating, Engine .228
....
Owner’s Maintenance Checks .184 .........................
Oxygenated Fuels .136
..............................
Paddle Shif ters .162
..............
Panel Brightness Control .74
........................
Park Gear Position .158
...........................................
Parking .166
.................................
Parking Brake .96
Parking Brake and Brake
.................
System Indicator .60,232
.................................
Parking Lights .72
..
Parking Over Things that Burn .166
....
Passenger Airbag Of f Indicator .31
.............................
PGM-FI System .252
...................................
Pollen Filter .205
..........................
Power Door Locks .79
..................
Power Socket Location .99
..............................
Power Windows .94
.........
Pregnancy, Using Seat Belts .16
........................
Preparing to Drive .153
.........
Protecting Adults and Teens .11
...
Additional Safety Precautions .17
.....
Advice f or Pregnant Women .16
Index
M N
P
O
VI
——yy
(
yy
2008 Fit

Î
µ
................................
Side Airbags .9,28
...
How Your Side Airbags Work .28
How the Side Airbag Of f
......................
Indicator Works .31
..................
Side Curtain Airbags .9,30
How Your Side Curtain Airbags .........................................
Work .30
Side Marker Lights, Bulb ..............................
Replacement .198
...............................
Signaling Turns .72
.....................................
Snow Tires .213
................................
Sound System .107
......................................
Spare Tire .218
....................................
Spark Plugs .244
........................
Specif ications .244,245
................................
Speed Control .131
........................
Speed Limiter .156,160
..........
SRS, Additional Inf ormation .22
...
Additional Safety Precautions .33
.............................
Airbag Service .32
......
Airbag System Components .22
How the Side Airbag Of f
......................
Indicator Works .31
..
How the SRS Indicator Works .30
How Your Front Airbags
.........................................
Work .25 ...
How Your Side Airbags Work .28
How Your Side Curtain Airbags
.........................................
Work .30
.............................
SRS Indicator .30,61
....
START (Ignition Key Position) .78
.......................
Starting the Engine .154
In Cold Weather at High ..................................
Altitude .154
................
With a Dead Battery .226
........
Steam Coming f rom Engine .228
Steering Wheel
..................................
Adjustment .75
.............
Anti-theft Column Lock .78
...............
Steering Wheel Buttons .131
...................
Stereo Sound System .107
....................
Storing Your Vehicle .216
..........................................
Sun Visor .99
Supplemental Restraint
..................................
System.9,22
......................................
Servicing .32
.........................
SRS Indicator .30,61
...................
System Components .22
..................................
Synthetic Oil .188 Tailgate
............................
Open Indicator .62
.................................
Opening the .81
..........
Taillights, Changing Bulbs .201
.
Taking Care of the Unexpected .217
Technical Descriptions
....
DOT Tire Quality Grading .246
.....
Emissions Control Systems .251
.....................
Oxygenated Fuels .136
Three Way Catalytic
...............................
Converter .253
Tire Pressure Monitoring System (TPMS) Required .........
Federal Explanation .249
...................
Temperature Indicator .63
..............
Tether Anchorage Points .47
................
Thef t Protection, Radio .128
..
Three Way Catalytic Converter .253
..................
Tilt the Steering Wheel .75
..........................
Time, Setting the .129
....................................
Tire Chains .214
.........
Tire, How to Change a Flat .219
...........................
Tire Inf ormation .248
Index
T
VIII
\f—\f—y\f
\fy
(
\fy\fy
2008 Fit