fuel pump HONDA ODYSSEY 2001 RA6-RA9 / 2.G Owners Manual

Because the f uel f ill cap is on the
driver’s side of the vehicle, park
with that side closest to the
service station pumps.
Open the f uel f ill door by pulling
onthehandletotheleftof the
driver’s seat.
In Canada, some gasolines contain
an octane-enhancing additive called
MMT. If you use such gasolines,
your emission control system
perf ormance may deteriorate and
the Malf unction Indicator Lamp on
your instrument panel may turn on.
If this happens, contact your
authorized Honda dealer f or service.
Bef ore ref ueling, make sure the rear
sliding door on the driver’s side is
closed.
1. 2.
CONT INUED
Bef ore Driving
Filling the Fuel Tank
Gasoline, Service Station Procedures
197
PPuullll
FFUUEELLFFIILLLLCCAAPP
Gasoline is highly flammable
and explosive. You can be
burned or seriously injured
when handling fuel.
Stop the engine and keep
heat, sparks, and flame away.
Handle fuel only outdoors.
Wipe up spills immediately.

Remove the f uel f ill cap slowly.
You may hear a hissing sound as
pressure inside the tank escapes.
Place the cap in the holder on the
fuel fill door.
Stop f illing the tank af ter the f uel
nozzle automatically clicks of f . Do
not try to ‘‘top off’’ the tank, leave
some room f or the f uel to expand
with temperature changes.Shift to Park or Neutral and set
the parking brake. Pull the hood
release handle located under the
lower lef t corner of the dashboard.
The hood will pop up slightly.
Screw the f uel f ill cap back on,
tighten it until it clicks several
times. If you do not properly
tighten the cap, the Malfunction
Indicator Lamp may come on (see
page ).
Push the f uel f ill door closed until
it latches.
Your vehicle has an on-board
ref ueling vapor recovery system to
help keep f uel vapors f rom going
into the atmosphere. If the fuel
pump keeps clicking of f even though
the tank is not full, there may be a
problem with this system. Consult
your dealer. 1.
3. 4.
5. 6.
320
Service Station Procedures
Bef ore Driving Opening the Hood
198
HHOOOODDRREELLEEAASSEEHHAANNDDLLEE

µ
ÌÌ
Ì
Ì Ì Follow the Normal Conditions
Maintenance Schedule if the
severe driving conditions
specif ied in the Severe
Conditions Maintenance
Schedule do not apply.
NOTE: If you only
drive under a
‘‘severe’’ condition, you should
f ollow the Normal Conditions
Maintenance Schedule.
Follow the Maintenance
Schedule f or Severe Conditions.
OCCASIONALLY
Maint enance U.S. Owners
Canadian Owners
240 Visually inspect the following items:Replace every 7,500 miles (12,000 km) or 12 months
Check oil and coolant at each fuel stop
Service at the indicated
distance or time whichever
comes first.
miles x 1,000
km x 1,000
months
120,000 miles (192,000 km) or 120 months, thereafter every60,000 miles (96,000 km) or 60 months
Replace engine oil
Replace engine oil filter
Check engine oil and coolant
Replace air cleaner element
Inspect valve clearance
Replace spark plugs
Replace timing belt , and inspect water pump
Inspect and adjust drive belts
Inspect idle speed
Replace engine coolant
Replace transmission fluid
Inspect front and rear brakes
Replace brake fluid
Check parking brake adjustment
Replace air conditioning filter
Rotate tires (Check tire inflation and condition
at least once per month)
Tie rod ends, steering gear box, and boots
Suspension components
Driveshaft boots
Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Cooling system hoses and connections
Exhaust system
Fuel lines and connections Rotate tires every 7,500 miles (12,000 km)
Every 36 months
152412
304824 457236609648 75
120 60 90
144
72 105168
84 120192
96
See information on maintenance and emissions warranty, last column, page . Adjust only if noisy
: 239
Maintenance Schedule for Normal Conditions

Ø ØØØØØØØØØ Ø ØØØØØØ
Ø ØØ ØØØØ Ø
Ì
Ì
Ì
Ì
Ì
Maint enance241
A, B, C
Canadian owners:
A B C D
Service at the indicated distance or time, whichever comes first. Do the items in as required for each distance/time interval. Follow this
schedule if the severe driving conditions described in the Severe Conditions Schedule on the next page do not apply.
Follow the schedule for Severe Conditions.
Replace engine oil.
Rotate tires (follow pattern on page 276 ).
Replace engine oil filter.
Inspect front and rear brakes.
Check parking brake adjustment.
Inspect tie rod ends, steering gearbox and boots.
Inspect suspension components.
Inspect driveshaft boots.
Inspect brake hoses and lines (including ABS).
Check all fluid levels, condition of fluids, and check
for leaks.
Inspect cooling system hoses and connections.
Inspect exhaust system .
Inspect fuel lines and connections .
Replace air cleaner element.
Inspect and adjust drive belts.
Replace air conditioning filter.
Replace brake fluid every 3 years (independent ofmileage).
Do items in A.
Do items in A, B.
Do items in A.
DoitemsinA,B,C.
Do items in A.
Replace transmission fluid. Do items in A, B, D.
Do items in A.
DoitemsinA,B,C.
Do items in A. Replace transmission fluid. Do items in A, B.
Do items in A.
DoitemsinA,B,C,D.
Do items in A. Replace timing belt , and inspect water pump.
Replace transmission fluid.
Inspect idle speed . Inspect valve clearance.
Replace spark plugs. Do items in A, B.
Do items in A.
DoitemsinA,B,C.
Replace engine coolant
7,500 mi/12,000 km/-
15,000 mi/24,000 km/1 yr
22,500 mi/36,000 km/-
30,000 mi/48,000 km/2 yrs
37,500 mi/60,000 km/-
45,000 mi/72,000 km/3 yrs
52,500 mi/84,000 km/-
60,000 mi/96,000 km/4 yrs
67,500 mi/108,000 km/-
75,000 mi/120,000 km/5 yrs
82,500 mi/132,000 km/-
90,000 mi/144,000 km/6 yrs
97,500 mi/156,000 km/-
105,000 mi/168,000 km/7 yrs
112,500 mi/180,000 km/-
120,000 mi/192,000 km/8 yrs
120,000 mi/192,000 km/10 yrs
thereafter every 60,000 mi/
96,000 km/5 yrs
 See information on maintenance and emissions warranty, last
column, page .
Check engine oil and coolant at each fuel stop.
Check and adjust valve clearance, cold engine, only if noisy.
NOTE: :
239
Maintenance Schedule for Normal Conditions (listed by distance/time)

µ
µ
Î ÎÌ
Ì
Ì
Ì
Î
ÌÎ
Follow the Severe Conditions
Maintenance Schedule if you
drive your vehicle
under one or more of the
f ollowing conditions:Driving less than 5 miles (8
km) per trip or, in f reezing
temperatures, driving less
than 10 miles (16 km) per trip.
Driving in extremely hot
[over 90°F (32°C)] conditions.
Extensive idling or long
periods of stop-and-go driving.
Trailer towing, driving with a
roof top carrier, or driving in
mountainous conditions.
Driving on muddy, dusty, or
de-iced roads.
Follow the Maintenance
Schedule f or Severe Conditions.
MAINLY
Maint enance U.S. Owners
Canadian Owners
242 Visually inspect the following items:
Refer to page for replacement
information under special driving
conditions.
Refer to page for replacement
information under special driving
conditions.
Replace every 3,750 miles (6,000 km) or 6 months
Check oil and coolant at each fuel stop
Service at the indicated
distance or time whichever
comes first.
miles x 1,000
km x 1,000
months
120,000 miles (192,000 km) or 120 months, thereafter every60,000 miles (96,000 km) or 60 months
Tie rod ends, steering gear box, and boots
Suspension components
Driveshaft boots
Brake hoses and lines (including ABS)
All fluid levels and conditions of fluids
Cooling system hoses and connections
Exhaust system
Fuel lines and connections
Lights and controls
Vehicle underbody Every 7,500 miles (12,000 km) or 6 months
Rotate tires every 7,500 miles (12,000 km) Every 36 months
Inspect every 7,500 miles (12,000 km) or 6 months
Replace engine oil and oil filter
Check engine oil and coolant
Clean ( ) or replace ( ) air cleaner element
Use normal schedule except in dusty
conditions
Inspect valve clearance
Replace spark plugs
Inspect and adjust drive belts
Inspect idle speed
Replace engine coolant
Replace transmission fluid
Inspect front and rear brakes
Replace brake fluid
Check parking brake adjustment
Replace air conditioning filter
Lubricate all hinges, locks and latches
Rotate tires (Check tire inflation and condition
at least once per month) 152412
304824457236 60964875
120 60 90
144 72 105168
84 120192
96
Adjust only if noisy
1: 2:: See page 239. 273272
Replace timing belt and inspect water pump,1
2
Maintenance Schedule for Severe Conditions

Ø ØØØØ
Ø Ø Ø ØØØØ Ø Ø Î
ÎÌ ÎÌ
Ì
ÎÌ Ì Î Î
Maint enance
244 D E
Check engine oil and coolant at each fuel stop.
Check and adjust valve clearance, cold engine, only if noisy. See air conditioning filter on page for replacement information
under special driving conditions.
See timing belt on page to determine need for replacement.
See information on maintenance and emissions warranty, last
column, page .
: 1: 2:
NOTE: 239
273
272
Replace air cleaner element.
Inspect and adjust drive belts.
Replace transmission fluid.
Replace air conditioning filter.
Replace brake fluid every 3 years (independent ofmileage).
56,250 mi/90,000 km/-
60,000 mi/96,000 km/4 yrs
63,750 mi/102,000 km/-
67,500 mi/108,000 km/4½ yrs
71,250 mi/114,000 km/-
75,000 mi/120,000 km/5 yrs
78,750 mi/126,000 km/-
82,500 mi/132,000 km/5½ yrs
86,250 mi/138,000 km/-
90,000 mi/144,000 km/6 yrs
93,750 mi/150,000 km/-
97,500 mi/156,000 km/6½ yrs
101,250 mi/162,000 km/-
105,000 mi/168,000 km/7 yrs
108,750 mi/174,000 km/-
112,500 mi/180,000 km/7½ yrs
116,250 mi/186,000 km/-
120,000 mi/192,000 km/8 yrs
120,000 mi/192,000 km/10 yrs
thereafter every 60,000 mi/
96,000 km/5 yrs Do items in A.
Replace timing belt . Do items in A, B, C, D.
Do items in A.
Do items in A, B.
Do items in A. Clean air cleaner element. Do items in A, B, C.
Do items in A.
Do items in A, B.
Do items in A.
DoitemsinA,B,C,D,E.
Do items in A.
Do items in A, B.
Do items in A. Replace timing belt , and inspect water pump.
Inspect valve clearance.
Clean air cleaner element.
Replace spark plugs. Inspect idle speed .
DoitemsinA,B,C.
Do items in A.
Do items in A, B.
Do items in A. Replace timing belt . Do items in A, B, C, D.
Replace engine coolant 2
1, 1, 1,
Maintenance Schedule for Severe Conditions (listed by distance/time)

ÎÎ
Î Î
Î
Î Î Î
On Canadian models
123 4 56789
10111213 15 A
10 A
7.5 A
7.5 A
7.5 A 15 A
10 A
7.5 A 10 A
7.5 A 15 A
30 A
7.5 A Fuel Pump
SRS
Heater Control, A/C Clutch
Relay, Cooling Fan Relay
Power Mirror
Daytime Running Light
ECU(PCM),CruiseControl
Rear Wiper
ACC Relay
Back-up Lights, Instrument
Lights
Turn Signals
IG Coil
Front Wiper
Starter Signal 1 2 345 6 78 9
10 111213141516 20 A
20 A
10 A
20 A
20 A
10 A
7.5 A 20 A
15 A
15 A
15 A
20 A
7.5 A
7.5 A 20 A
7.5 A Driver’s Side Automatic
Sliding Door
Power Seat Reclining
BSC
Power Seat Sliding
Passenger’s Side Automatic
Sliding Door
Daytime Running Light
Left Power Vent
Front Passenger’s Power
Window
ACC Socket
Small Light, License Light
Interior Light, Radio
Power Door Locks
Clock, Back Up
ABS Motor Check
Driver’s Power Window
Right Power Vent
1:2: EX
Canadian models
No. Amps. Circuits Protected No. Amps. Circuits Protected
1
1 1
2
Fuses
T aking Care of t he Unexpect ed
328
Driver’s Side
INTERIOR FUSE BOX
Passenger’s Side
FFrroonnttFFrroonntt
:

Some conventional gasolines are
being blended with alcohol or an
ether compound. These gasolines
are collectively ref erred to as
oxygenated f uels. To meet clean air
standards, some areas of the United
States and Canada use oxygenated
f uels to help reduce emissions.
If you use an oxygenated f uel, be
sure it is unleaded and meets the
minimum octane rating requirement.
Bef ore using an oxygenated f uel, try
to conf irm the f uel’s contents. Some
states/provinces require this
informationtobepostedonthepump.The f ollowing are the U.S. EPA and
Canadian CGSB approved
percentages of oxygenates:
(Methyl Tertiary Butyl
Ether)
You may use gasoline containing up
to 15 percent MTBE by volume. (ethyl or grain alcohol)
You may use gasoline containing up
to 10 percent ethanol by volume.
Gasoline containing ethanol may be
marketed under the name ‘‘Gasohol.’’
(methyl or wood
alcohol)
Your vehicle was not designed to use
fuel that contains methanol.
Methanol can corrode metal parts in
the fuel system, and also damage
plastic and rubber components. This
damage would not be covered by
your warranties. If you notice any undesirable
operating symptoms, try another
service station or switch to another
brand of gasoline.
Fuel system damage or perf ormance
problems resulting f rom the use of
an oxygenated f uel containing more
than the percentages of oxygenates
given above are not covered under
warranty.
MT BE
ET HA NOL
MET HA NOL
T echnical Inf ormation
Oxygenated Fuels
338

Service Inf ormat ion Summary
Gasoline:
Fuel Tank Capacity:Tire Pressure (measured cold):
Power Steering Fluid:
Brake Fluid:
Recommended Engine Oil:
Automatic Transmission Fluid: 35 psi (240 kPa , 2.4 kgf/cm
)
60 psi (420 kPa , 4.2 kgf/cm
)
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ).
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
Unleaded gasoline, pump octane
number of 86 or higher.
Front/Rear:
Compact Spare Tire:
API Service SJ ‘‘Energy
Conserving’’ oil, SAE 5W-30
viscosity (see page ).
Oil change capacity (including
filter): 4.6 US qt (4.4
, 3.9 Imp qt)
Honda ATF-Z1 (Automatic
Transmission Fluid) preferred, or
aDEXRON
III ATF as a
temporary replacement (see page ). 249
261
260
259
20.00 US gal (75.7
, 16.65 Imp gal)