engine coolant HONDA S2000 2002 1.G Owner's Manual

Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (seeon page ). If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page
). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks. Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
If there was no coolant in the
reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the reading
reaches the middle of the
temperature gauge, or lower,
bef ore checking the radiator.
6.
7.9.
8.
247 126
Emergency
Towing
If Your Engine Overheats
T aking Care of t he Unexpect ed
232 Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

Start the engine and set the
temperature control dial to
maximum. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .) If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
10.
12.
11.
247Emergency
Towing
If Your Engine Overheats
T aking Care of t he Unexpect ed 233

Î ÎÎ Î
T echnical Inf ormation
Specif ications
252 Engine
Dimensions
Weights
Capacities
162.0 in (4,115 mm)
68.9 in (1,750 mm)
50.6 in (1,285 mm)
94.5 in (2,400 mm)
57.9 in (1,470 mm)
59.4 in (1,510 mm) 13.2 US gal (50
, 11.0 Imp gal)
Water cooled 4-stroke DOHC
VTEC 4-cylinder gasoline engine
Type
BorexStroke
Displacement
Compression ratio
Spark plugs 121.8 cu-in (1,997 cm
)
11.0 : 1 1.72 US gal (6.5
, 1.43 Imp gal)
2.01 US gal (7.6, 1.67 Imp gal)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb. Fuel tank
Engine coolant
Engine oil Manual
transmission
fluid
Differential
oil
Windshield
washer
reservoir5.1 US qt (4.8
, 4.2 Imp qt)
4.8 US qt (4.5, 4.0 Imp qt)
5.9 US qt (5.6, 4.9 Imp qt)
1.6 US qt (1.5, 1.3 Imp qt)
1.7 US qt (1.6, 1.4 Imp qt)
0.78 US qt (0.74
,0.65Impqt)
0.81 US qt (0.77,0.68Impqt)
2.7 US qt (2.6, 2.3 Imp qt)
4.4 US qt (4.2, 3.7 Imp qt)
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
0.16 US gal (0.6
, 0.13 Imp gal)
Excluding the oil remaining in the engine.
3.43 x 3.31 in (87.0 x 84.0 mm)
See the spark plug maintenance
section, page 181 .
FrontRear
1: 2:Change Total
Change Total
ChangeTotal
Change Total
U.S. Cars
Canadian Cars
1 2
Including filter
Without filter

Changing Oil........................................
How to . 165
......................................
When to . 152
....................
Changing a Flat Tire . 221
............
Changing Engine Coolant . 169
...
Charging System Indicator . 44, 235
...............
Check Engine Light . 45, 236
............
Checklist, Bef ore Driving . 136
.....................................
Child Saf ety . 19
.......................................
Child Seats . 22
...................................
Cleaner, Air . 178
.........................................
Cleaning . 209
....................
Aluminum Wheels . 212
...................................
Carpeting . 213
......................................
Exterior . 210
.................................
Floor Mats . 213
.......................................
Interior . 213
.......................................
Leather . 214
...................................
Seat Belts . 214
...........................................
Vinyl . 214
....................................
Windows . 215
...................................
Clutch Fluid . 177
........................
CO in the Exhaust . 258
............
Cold Weather, Starting in . 138
......................
Compact Spare Tire . 220
.............
Controls, Instruments and . 41 ................................
Covertible Top . 70
...............
Convertible Top Cover . 75
..
Lowering the Convertible Top . 70
................................
Maintenance . 76
........
Raising the Covertible Top . 73
Coolant ........................................
Adding . 167
....................................
Checking . 126
.........................
Proper Solution . 167
...................
Temperature Gauge . 47
....................
Corrosion Protection . 215
Crankcase Emission Control
........................................
System . 258
..............
Cruise Control Operation . 55
Customer Relations
................................
Inf ormation . 264
..............................
Economy, Fuel . 127
............
Emergencies on the Road . 219
.............
Battery, Jump Starting . 228
................
Changing a Flat Tire . 221
.....
Charging System Indicator . 235
..................
Checking the Fuses . 241
................
DANGER, Explanation of . ii
.......................................
Dashboard . 42
................
Daytime Running Lights . 52
............
Defects, Reporting Safety . 268
................
Defrosting the Windows . 89
....................................
Dimensions . 252
...............
Dimming the Headlights . 51 Dipstick
..................................
Engine Oil . 125
..........................
Directional Signals . 53
........
Disc Brake Wear Indicators . 142
.....................
Disposal of Used Oil . 166
...................
Do Not Tow a Trailer . 147
Doors
..............
Locking and Unlocking . 60
..............................
Monitor Light . 45
......................
Power Door Locks . 60
..........
DOT Tire Quality Grading . 254
Downshif ting, 6-speed Manual
.............................
Transmission . 140
...........................................
Driving . 135
....................................
Economy . 127
.........................
In Bad Weather . 146
................
In Foreign Countries . 257
Index
D
E
II

CONT INUED
...
Closing the Convertible Top . 239
.....
Low Oil Pressure Indicator . 234
...
Malf unction Indicator Lamp . 236
..................
Overheated Engine . 231
...........................
Emergency Brake . 79
......................
Emergency Flashers . 78
............
Emergency Trunk Opener . 65
.......................
Emissions Controls . 258
.............
Emissions Testing, State . 261 Engine
...........
Check Engine Light . 45, 236
Compartment, Checking
......................................
in the . 124
.......................................
Coolant . 126
....
Coolant Temperature Gauge . 47
...................................
Drive Belt . 190
Malf unction Indicator
................................
Lamp . 45, 236
........
Oil Pressure Indicator . 44, 234
..............
Oil, What Kind to Use . 163
...............................
Overheating . 231
............................
Specif ications . 252
............................
Speed Limiter . 140
.......................................
Starting . 137
.........
Engine Cover, Opening the . 124
......................
Ethanol in Gasoline . 256 ...
Evaporative Emission Controls . 258
...............................
Exhaust Fumes . 39
Expectant Mothers, Use of Seat
........................................
Belts by . 17
..................
Exterior, Cleaning the . 210
..........................................
Gasohol . 256
.........................................
Gasoline . 122
...............
Fuel Reserve Indicator . 46
...........................................
Gauge . 48
................
Octane Requirement . 122
.....................
Oxygenated Fuels . 256
........................
Tank, Filling the . 123
............................
Fabric, Cleaning . 214
.....................................
Fan, Interior . 84
Features, Comfort and
................................
Convenience . 83
....................
Filling the Fuel Tank . 123
Filters
...............................................
Oil . 165
.............
Flashers, Hazard Warning . 78
...................
Flat Tire, Changing a . 221
Fluids
..........................................
Brake . 176
.........................................
Clutch . 177
..............
Manual Transmission . 174
..................
Windshield Washer . 173
........
FM Stereo Radio Reception . 101
.....
Foreign Countries, Driving in . 257
..........................
Four-way Flashers . 78 .................................................
Fuel . 122
......................
Fill Door and Cap . 123
...........................................
Gauge . 48
................
Octane Requirement . 122
...............................
Oxygenated . 256
........................
Reserve Indicator . 46
........................
Tank, Filling the . 123
..............
Fuel Mileage, Improving . 127
..............
Fuel Station Procedures . 123
.....................
Fuses, Checking the . 241
Index
F
G
III

.............................................
Gauges . 47
...
Engine Coolant Temperature . 47
...............................................
Fuel . 48
...............................
Speedometer . 47
.................................
Tachometer . 47
Gearshif t Lever Positions 6-speed Manual
.........................
Transmission . 139
..............................
Glass Cleaning . 215
.............
Halogen Headlight Bulbs . 200
..............
Hazard Warning Flashers . 78
Headlights
............
Daytime Running Lights . 52
..................
High Beam Indicator . 46
...........................
Reminder Tone . 51
........
Replacing Halogen Bulbs . 200
...................................
Turning on . 51
.........
Heating and Cooling System . 84
.............
High Altitude, Starting at . 138
.................
High-Low Beam Switch . 51
................
High Speed, Shif ting at . 140
....................................
Hood Latch . 180
.......................
Hood, Opening the . 124 ...........................
Hydraulic Clutch . 177
.................................
Hydroplaning . 147
Identif ication Number,
.......................................
Vehicle . 250
Ignition
..............................................
Keys . 56
...........................................
Switch . 58
............
Timing Control System . 259
Indicator Lights, Instrument
.............................................
Panel . 43
...................
Inf lation, Proper Tire . 191
...................................
Inside Mirror . 78
.............................
Inspection, Tire . 193
............................
Instrument Panel . 42
........
Instrument Panel Brightness . 52
...........................
Interior Cleaning . 213
.................................
Interior Lights . 81
........................................
Introduction . i
.......................
Jacking Up the Car . 222
.......................................
Jack, Tire . 221 ................................
Jump Starting . 228
..................................................
Keys . 56
.......................
Label, Certif ication . 250
.................
Lane Change, Signaling . 53
........................
Lap/Shoulder Belts . 33
.........................
Leather, Cleaning . 214
Lights
....................
Bulb Replacement . 200
.......................................
Indicator . 43
................................
Turn Signal . 200
...............................
Loading Cargo . 130
......
LOCK (Ignition Key Position) . 58
Locks
.......
Anti-thef t Steering Column . 58
............................
Fuel Fill Door . 123
.................................
Power Door . 60
...........................................
Trunk . 64
........................
Low Coolant Level . 126
...
Lower Gear, Downshif ting to a . 140
.........................
Low Fuel Indicator . 46
Index
H I J K L
IV

Recovery Vehicle, Emergency.......................................
Towing . 247
.............................
Reminder Lights . 43
.......................
Remote Transmitter . 61
Replacement Inf ormation
................................
Air Cleaner . 178
..........................
Engine Coolant . 169
................
Engine Oil and Filter . 165
..........................................
Fuses . 241
................................
Light Bulbs . 200
....................................
Schedule . 152
................................
Spark Plugs . 180
...........................................
Tires . 195
.............................
Wiper Blades . 186
Replacing Seat Belts Af ter a
............................................
Crash . 34
...............................
Restraint, Child . 19
................................
Rotation, Tire . 194
........................................
Saf ety Belts . 8
............
Safety Defects, Reporting . 268
.............
Saf ety Labels, Location of . 40
...............................
Saf ety Messages . ii ...........................................
Seat Belts . 8
...............
Additional Information . 33
.....
Advice f or Pregnant Women . 17
.....................................
Cleaning . 214
......................
Lap/Shoulder Belt . 33
................................
Maintenance . 34
......
Reminder Light and Beeper . 44
...................
System Components . 33
...............
Use During Pregnancy . 17
........................
Seats, Adjusting the . 67
...............................
Serial Number . 250
...........................
Service Intervals . 152
.............................
Service Manual . 269
.........
Service Station Procedures . 123
Shif ting
The 6-speed Manual .........................
Transmission . 139
Side Marker Lights, Bulb .........................
Replacement in . 202
...............................
Signaling Turns . 53
6-speed Manual Transmission
...............
Checking Fluid Level . 174
................................
Shif ting the . 139
.....................................
Snow Tires . 197
...................
Solvent-type Cleaners . 210
..................................
Sound System . 92 Spare Tire
......................................
Inf lating . 220
............................
Specif ications . 253
................
Spark Plugs, Replacing . 180
....................
Specif ications Charts . 252
..................................
Speed Control . 55
...................................
Speedometer . 47
..........
SRS, Additional Inf ormation . 35
...
Additional Safety Precautions . 38
How the Automatic Seat Belt
....................
Tensioners Work . 37
How the SRS Indicator .......................................
Works . 37
...........
How Your Airbags Work . 35
........................
SRS Components . 35
..................................
SRS Service . 38
..................
SRS Indicator Light . 37, 45
.......................
Starting the Engine . 137
In Cold Weather at High ..................................
Altitude . 138
................
With a Dead Battery . 228
..............
State Emissions Testing . 261
........
Steam Coming f rom Engine . 231
Steering Wheel
.............
Anti-theft Column Lock . 58
.....................
Stereo Sound System . 92
Index
S
VI