warning HONDA S2000 2004 2.G User Guide

µ
See pages f or important saf ety
inf ormation and warnings about how toproperly position seats and seat-backs. 10 11
Make all seat adjustments bef ore
you start driving.
To adjust the seat forward and
backward, pull up on the lever under
the seat cushion’s f ront edge. Then
trytomovetheseattomakesureit
is locked in position.To change the seat-back angle, pull
up on the lever on the outside of the
seat bottom.
Seats
Inst rument s and Cont rols58

µ
Check the condition of the battery
monthlybylookingatthetest
indicator window. The label on the
battery explains the test indicator’s
colors. Check the terminals f or corrosion (a
white or yellowish powder). To
remove it, cover the terminals with a
solution of baking soda and water. It
will bubble up and turn brown. When
this stops, wash it of f with plain
water. Dry off the battery with a
cloth or paper towel. Coat the
terminals with grease to help prevent
f uture corrosion.
If additional battery maintenance is
needed, see your Honda dealer or a
qualif ied technician.
Battery posts,
terminals, and related accessories
contain lead and lead compounds. If you need to connect the battery to
a charger, disconnect both cables to
prevent damaging your vehicle’s
electrical system. Always disconnect
the negative ( ) cable first, and
reconnect it last.
Checking the Battery
Maint enance
WARNING:
Wash your hands af ter handling.
151
TEST INDICATOR WINDOW
The battery gives off explosive
hydrogen gas during normal
operation.
A spark or flame can cause the
battery to explode with enough
force to kill or seriously hurt you.
Wear protective clothing and a
face shield, or have a skilled
mechanic do the battery
maintenance.

If you have a f lat tire while driving,
stop in a saf e place to change it.
Drive slowly along the shoulder until
you get to an exit or an area that is
far away from the traffic lanes.Thesizedifferencemayalsocause
damage to the rear dif f erential, so do
not mount the compact spare on the
rear. If either rear tire goes f lat,
remove the f ront tire on that same
side, mount the compact spare tire
on the f ront, then mount the f ront
tire on the rear.
Park the vehicle on f irm, level, and
non-slippery ground. Put the
transmission in Reverse. Apply the
parking brake.
Turn on the hazard warning lights,
and turn the ignition switch to
LOCK (0). Have your passenger
get out of the vehicle while you
change the tire. Open the trunk. Lif t up the tool
box lid, and take the jack, wheel
wrench, and extension out of the
tool box.
Thecompactsparetireissmaller
than a standard tire, which will affect
the vehicle’s handling. Drive
cautiously when this spare is
mounted on your vehicle. 3.
1.
2.
CONT INUED
Changing a Flat T ire
T aking Care of t he Unexpect ed155
NOTICE:
TOOL BOX LID
JACK
The vehicle can easily roll off
the jack, seriously injuring
anyone underneath.
Follow the directions for
changing a tire exactly, and
never get under the vehicle
when it is supported only by the
jack. Use the jack that came with
your vehicle. If you try to raise another
vehicle with this jack or use another
jack to raise your vehicle, the vehicle or
jack can be damaged.

Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (seeon page ).
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank. Add coolant
if the level is below the MIN mark. If the temperature gauge stays at
the red mark, turn of f the engine.
If you do not see steam or spray,
leave the engine running, and
watch the temperature gauge. If
the high heat is due to overloading,
the engine should start to cool
down almost immediately. If it
does, wait until the temperature
gauge comes down to the midpoint,
then continue driving. If you see steam and/or spray
coming f rom under the hood, turn
of f the engine. Wait until you see
no more signs of steam or spray,
then open the hood. Saf ely pull to the side of the road.
Put the transmission in Neutral,
and set the parking brake. Turn
of f the all accessories, and turn on
the hazard warning indicators.
2. 1.
3. 4.
5.
6.
176
T aking Care of t he Unexpect ed
Emergency
Towing
If theEngineOverheats
164
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.

Saf ely pull of f the road, and shut
of f the engine. Turn on the hazard
warning indicators.
Let the vehicle sit f or a minute.
Open the hood, and check the oil
level (see page ). An engine
very low on oil can lose pressure
during cornering and other driving
maneuvers.
If necessary, add oil to bring the
level back to the full mark on the
dipstick (see page ).
Start the engine, and watch the oil
pressure indicator. If it does not go
out within 10 seconds, turn of f the
engine. There is a mechanical
problem that needs to be repaired
bef ore you can continue driving
(seeon page
). If the charging system
indicator comes on brightly
when the engine is running, the
battery is not being charged.
Immediately turn of f all electrical
accessories. Try not to use other
electrically operated controls such as
the power windows. Keep the engine
running; starting the engine will
discharge the battery rapidly.
Go to a service station or garage
where you can get technical
assistance.
This indicator should never
come on when the engine is
running. If it starts f lashing or stays
on, the oil pressure has dropped very
low or lost pressure. Serious engine
damage is possible and you should
take immediate action. 1.
2.
3.
4.103
129
176
L ow Oil Pressure Indicator, Charging System Indicator
T aking Care of t he Unexpect ed
L ow Oil Pressure Indicator
Emergency T owingCharging System Indicator
166
NOTICE:
Running the engine with low
oil pressure can cause serious
mechanical damage almost immediately.
Turn of f the engine as soon as you can
saf ely get the vehicle stopped.

µ
µ
µ
µ
µ
µ
µµ
µ
µ
µ
No. Amps. No. Amps. Circuits Protected
No. Amps. Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 40 A
20 A
30 A
20 A
40 A
20 A 14
15
16
17
18
19
20
21
22
23
24
2520 A
15 A
10 A
20 A
15 A
20 A
20 A
30 A
100 A 40 A Magnetic Clutch Relay
Right Headlight
ACG S
Hazard Warning Lights
Cooling Fan
Not used
Stop
Lef t Headlight
ABS F/S
ABS Motor
Battery
IG1 Main
1
2
3
4
5 20 A
70 A
60 A Rear Window Defogger
Not used
Not used
EPS
Air Pump Lighting 1 Relay
Lighting 2 Relay
Horn Relay
Power Window Motor
Right Roof Motor
Not used
Backup ACC
Lef t Roof Motor
Heater Motor
Condenser Fan
Not used
Condenser Fan Relay
Cooling Fan Relay
Fuse Locations
T aking Care of t he Unexpect ed173
(AUXILIARY FUSE BOX)
UNDER-HOOD FUSE BOXES
(PRIMARY FUSE BOX)

µ
Quality grades can be f ound where
applicable on the tire sidewall
between the tread shoulder and the
maximum section width. For
example:
All passenger car tires must conf orm
to Federal Saf ety Requirements in
addition to these grades. The treadwear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specif ied government
test course. For example, a tire
graded 150 would wear one and one-
half (1 1/2) times as well on the
government course as a tire graded
100. The relative perf ormance of
tires depends upon the actual condi-
tions of their use, however, and may
depart signif icantly f rom the norm
due to variations in driving habits,
service practices, and dif f erences in
road characteristics and climate.
The traction grades, f rom highest to
lowest, are AA, A, B, and C. Those
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on
specif ied government test surf aces
of asphalt and concrete. A tire
marked C may have poor traction
perf ormance.
Warning: The traction grade
assignedtothistireisbasedon
straight-ahead braking traction tests,
and does not include acceleration,
cornering, hydroplaning, or peak
traction characteristics.
The tires on your vehicle meet all
U.S. Federal Saf ety Requirements.
All tires are also graded f or
treadwear, traction, and temperature
perf ormance according to
Department of Transportation
(DOT) standards. The f ollowing
explains these gradings.
DOT T ire Quality Grading (U.S. Vehicles)
T echnical Inf ormation
Unif orm T ire Quality Grading
T readwear 200
Traction AA
Temperature A Treadwear
Traction AA, A, B, C
182

µ
The temperature grades are A (the
highest), B, and C, representing the
tire’s resistance to the generation of
heat and its ability to dissipate heat
when tested under controlled
conditions on a specif ied indoor
laboratory test wheel. Sustained high
temperature can cause the material
of the tire to degenerate and reduce
tire life, and excessive temperature
can lead to sudden tire f ailure. The
grade C corresponds to a level of
perf ormance which all passenger car
tires must meet under the Federal
Motor Vehicle Saf ety Standard No.
109. Grades B and A represent
higher levels of perf ormance on the
laboratory test wheel than the
minimum required by law. Warning: The temperature grade f or
this tire is established f or a tire that
is properly inf lated and not over-
loaded. Excessive speed, underinf la-
tion, or excessive loading, either
separately or in combination, can
cause heat buildup and possible tire
f ailure.
DOT T ire Quality Grading (U.S. Vehicles)
T echnical Inf ormation
Temperature A,B,C
183

..............................
Economy, Fuel .104
............
Emergencies on the Road . 153
.............
Battery, Jump Starting . 162
................
Changing a Flat Tire . 155
.....
Charging System Indicator . 166
..................
Checking the Fuses . 170
.........
Hazard Warning Flashers . 49
.....
Low Oil Pressure Indicator . 166
...
Malf unction Indicator Lamp . 167
..................
Overheated Engine . 163
...........................
Emergency Brake .67
......................
Emergency Flashers .49
............
Emergency Trunk Opener . 55
.......................
Emissions Controls .185
.....................................
Child Saf ety .22
..............................
Booster Seats .31
...................................
Child Seats .26
.....
Important Saf ety Reminders . 25
..........................
Larger Children .30
......................
Risk With Airbags .23
.............................
Small Children .26
.......................................
Child Seats .26
Cleaning .................................
Floor Mats .143
...................................
Seat Belts .143
...................................
Clutch Fluid .136
........................
CO in the Exhaust .185
.........................
Compact .154
.............
Controls, Instruments and . 70
..............................
Convertible Top .61
...............
Convertible Top Cover . 63
..
Lowering the Convertible Top . 61
................................
Maintenance .65
.....
Raising the Convertible Top . 64
Coolant ........................................
Adding .132
....................................
Checking .103
.........................
Proper Solution .132
...................
Temperature Gauge . 45Crankcase Emission Control
........................................
System .185
..............
Cruise Control Operation . 95
................
Cruise Control Indicator . 42
......................................
Cup Holder .70
Customer Relations ................................
Inf ormation .192
................
DANGER, Explanation of . ii
.......................................
Dashboard .38
................
Daytime Running Lights . 48
Daytime Running Lights .......................................
Indicator .42
.................................
Dead Battery .162
............
Def ects, Reporting Saf ety . 194
................
Def rosting the Windows . 77
....................................
Dimensions .180
...............
Dimming the Headlights . 48
Dipstick ..................................
Engine Oil .103
..........................
Directional Signals .48
........
Disc Brake Wear Indicators . 117
.....................
Disposal of Used Oil .132
...................
Do Not Tow a Trailer . 118Doors
..............
Locking and Unlocking . 54
..............................
Monitor Light .41
......................
Power Door Locks .54
..........
DOT Tire Quality Grading . 182
Downshif ting, 6-speed Manual
.............................
Transmission .114
...........................................
Driving .111
....................................
Economy .104
spare tire
Index
D
E
II

CONT INUED
.............
Halogen Headlight Bulbs . 137
..............
Hazard Warning Flashers . 49
Headlights ............
Daytime Running Lights . 48
..................
High Beam Indicator . 42
...........................
Reminder Tone .48
........
Replacing Halogen Bulbs . 137
...................................
Turning on .48
.........
Heating and Cooling System . 74
.................
High-Low Beam Switch . 48
................
High Speed, Shif ting at . 115
.............
Emissions Testing, State . 188
Engine .......................................
Coolant .132
....
Coolant Temperature Gauge . 45
Malf unction Indicator ................................
Lamp .41, 167
........
Oil Pressure Indicator . 40,166
..............
Oil, What Kind to Use . 129
...............................
Overheating .163
............................
Specif ications .180
............................
Speed Limiter .115
.......................................
Starting .113
...................
Engine, .160
......................
Ethanol in Gasoline .100
...
Evaporative Emission Controls . 185
...............................
Exhaust Fumes .34
Expectant Mothers, Use of Seat ........................................
Belts by .14
.....................................
Fan, Interior .75
Features, Comfort and ................................
Convenience .73
....................
Filling the Fuel Tank . 101Filters
...............................................
Oil .130
.............
Flashers, Hazard Warning . 49
...................
Flat Tire, Changing a . 155
Fluids ..........................................
Brake .136
.........................................
Clutch .136
..............
Manual Transmission . 134
..................
Windshield Washer . 134
..........
FM Stereo Radio Reception . 81
..........................
Four-way Flashers .49
.................................................
Fuel .100
......................
Fill Door and Cap .101
...........................................
Gauge .45
................
Octane Requirement . 100
........................
Reserve Indicator .42
........................
Tank, Filling the .101
..............
Fuel Mileage, Improving . 104
..............
Fuel Station Procedures . 101
.....................
Fuses, Checking the .170
.........................................
Gasoline .100
...............
Fuel Reserve Indicator . 42
...........................................
Gauge .45 ................
Octane Requirement . 100
........................
Tank, Filling the .101
.............................................
Gauges .44
...
Engine Coolant Temperature . 45
...............................................
Fuel .45
...............................
Speedometer .44
.................................
Tachometer .44
Gearshif t Lever Positions 6-speed Manual .........................
Transmission .114
if it won’t start
Index
F
GH
III