ECU HYUNDAI I20 2014 Owners Manual


*($'!#(%'*
N
N OTICE indicates a situation which,
if not avoided, could result in vehicle
damage.
Petrol engine
Unleaded
Your new vehicle is designed to use
only unleaded fuel having an Octane
Rating of RON (Research Octane
Number) 91 / AKI (Anti-Knock Index)
87 or higher.
Your new vehicle is designed to
obtain maximum performance with
UNLEADED FUEL, as well as mini-
mize exhaust emissions and spark
plug fouling.
Leaded (if equipped)
For some countries, your vehicle is
designed to use leaded petrol.
When you are going to use leaded
petrol, we recommend that you ask
an authorized HYUNDAI dealer
whether leaded petrol in your vehicle
is available or not.
Octane Rating of leaded petrol is
same with unleaded one.
NOTICE
NEVER USE LEADED FUEL. The
use of leaded fuel is detrimental to
the catalytic converter and will
damage the engine control sys-
tem’s oxygen sensor and affect
emission control.
Never add any fuel system clean-
ing agents to the fuel tank other
than what has been specified (We
recommend that you consult an
authorized HYUNDAI dealer for
details.)
CAUTION
CAUTION indicates a hazardous
situation which, if not avoided,
could result in minor or moderate
injury.
CAUTION
 

€Do not "top off" after the nozzle
automatically shuts off when
refueling.
€Always check that the fuel cap is
installed securely to prevent fuel
spillage in the event of an acci-
dent.
WARNING

lated above\b at no cost to the owner
of the Hyundai vehicle for parts or
labour.3. What is not covered
This warranty shall not apply to:
o Normal maintenance services of parts such as cleaning\b adjust
ment or replacement (i.e. spark
plugs that are oil fouled\b lead
fouled\b or which fail due to the use
of low grade fuel).
o Parts that fail due to abuse\b mis use\b neglect\b alteration or acci
dent or which have been improp
erly lubricated or repaired.
o Par ts used in applications for which they were not designed or
approved by HMIL.
o Failure due to normal wear of parts.
o Direct or indirect failures caused by misuse and improper mainte
nance of vehicle and installation
of nonHyundai parts on the vehi
cle.
o Any vehicle on which the odome ter reading has been altered so
that mileage cannot be accurate
ly determined. o Incidental or consequential dam
ages\b including without limitation\b
loss of time\b inconvenience\b loss
of use of vehicle or commercial
loss.
This warranty is the entire warranty
given by HMIL for Hyundai replace
ment parts and no dealer or its or his
agent or employee is authorized to
extend or enlarge this warranty and
no dealer or its or his agent or
employee is authorized to make any
oral warranty on HMIL's behalf.
HMIL reserves the right for the final
decision in all warranty matters.
Owner's Responsibilities
o Proper use\b maintenance and care of the vehicle in accordance
with the instructions contained in
the Owner's Manual and Service
Booklet.
o Retention of maintenance service records. It may be necessary for
the customer to show that the
required maintenance has been
performed\b as specified in this
Owner's Manual and Ser vice
Booklet. o Retention of the customer's copy
of the original repair order and its
invoice/bill against which the part
was replaced.
o Delivery of the vehicle during reg ular service business hours to the
same Hyundai Authorized Dealer
who had sold and installed the
replacement part.
o In order to maintain the validity of this Parts replacement Warranty\b
the vehicle must be serviced by
Hyundai Authorized workshop in
accordance to the Owner’s
Manual and Service Booklet.
   HMIL extends the Mass Emission
standards (BS
IV)
for its vehicle in
the following cities: (1)
Delhi/NCR\b (2) Mumbai\b (3)
Chennai\b (4) Chennai\b (5) Bangalore
(6)HyderabadincludingSecund
e-
rabad\b (7) Ahmedabad\b(8)Pune\b
(9) Surat\b (1\f) Kanpur\b (11)Agra.
(For the vehicles Manufactured
on or
after \f1/\f4/2\f1\f).
Hyundai Warran\fy Po\bicy
)%4


"&t%'s%st&'!"'%!'&&
Driver’s seat
•Never attempt to adjust seat
while the vehicle is moving. This
could result in loss of control, and
an accident causing death, seri
ous injury, or property damage.
•Do not allow anything to interfere
with the normal position of the
seatback. Storing items against a
seatback or in any other way
interfering with proper locking of
a seatback could result in serious
or fatal injury in a sudden stop or
co

llision.
•Always drive and ride with your
seatback upright and the lap por
tion of the seat belt snug and low
across the hips. This is the best
position to protect you in case of
an accident.
(Continued)
WARNING (Continued)
•In order to avoid unnecessary
and perhaps severe air bag
injuries, always sit as far back as
possible from the steering wheel
while maintaining comfortable
control of the vehicle.
Rear seatbacks
•The rear seatback must be
securely latched. If not, passen
gers and objects could be thrown
forward resulting in serious injury
or death in the event of a sudden
stop or collision.
•Luggage and other cargo should
be laid flat in the cargo area. If
objects are large, heavy, or must
be piled, they must be secured.
Under no circumstances should
cargo be piled higher than the
seatbacks. Failure to follow these
warnings could result in serious
injury or death in the event of a
sudden stop, collision or rollover.(Continued)
WARNING
(Continued)
•No passenger should ride in the
cargo area or sit or lie on folded
seatbacks while the vehicle is
moving. All passengers must be
properly seated in seats and
restrained properly while riding.
•When resetting the seatback to
the upright position, make sure it is
securely latched by pushing it for
ward and backwards.
•To avoid the possibility of burns,
do not remove the carpet in the
cargo area. Emission control
d

evices beneath this floor gener
ate high temperatures.
After adjusting the seat, always
check that it is securely locked into
place by attempting to move the
seat forward or backward without
using the lock release lever.
Sudden or unexpected movement
of the driver's seat could cause
you to lose control of the vehicle
resulting in an accident.
WARNING


"&t%'s%st&'!"'%!'&&

Front seats
Forward and rearward
To move the seat forward or rear
ward:
1. Pull the seat slide adjustmentlever up and hold it. 2. Slide the seat to the position you
desire.
3. Release the lever and make sure the seat is locked in place.
Adjust the seat before driving, and
make sure the seat is locked secure
ly by trying to move forward and rear
ward without using the lever. If the
seat moves, it is not locked properly.
•Do not adjust the seat while wear
ing seat belts. Moving the seat
cushion forward may cause
strong pressure on the abdomen.
•Use extreme caution so that
hands or other objects are not
caught in the seat mechanisms
while the seat is moving.
•Do not put a cigarette lighter on
the floor or seat. When you oper
ate the seat, gas may gush out of
the lighter and cause fire.
•If there are occupants in the rear
seats, be careful while adjusting
the front sea
t position.
WARNING
OIB034029
OIB034002
Type A
Type B

1
"&t%'s%st&'!"'%!'&&

• When returning the rear seatbacksto the upright position, remember
to return the rear shoulder belts to
their proper position.
• Routing the seat belt webbing through the rear seat belt guides
will help keep the seat belts from
being trapped behind or under the
seats.
Armrest (if equipped)
The armrest is located in the center
of the rear seat. Pull the armrest
down from the seatback to use it.
NOTICE
Cargo loading
Make sure the engine is off, the
Continuously Variable Transaxle
is in P (Park) or the Manual
Transaxle is in R (Reverse) or 1st,
and the parking brake is securely
applied whenever loading or
unloading cargo. Failure to take
these steps may allow the vehicle
to move if the shift lever is inad
vertently moved to another posi
tion.
WARNING
Cargo
Cargo should always be secured
to prevent it from being thrown
about the vehicle in a collision and
causing injury to the vehicle occu
pants. Do not place objects in the
rear seats, since they cannot be
properly secured and may hit the
front seat occupants in a collision.
WARNING OIB037043

1
"&t%'s%st&'!"'%!'&&

Seat belt warning (if equipped)
As a reminder to the driver (or front
passemgers)*, the driver’s (or front
passemger’s)* seat belt warning
lights will illuminate for approximate
ly 6 seconds each time you turn the
ignition switch ON regardless of belt
fastening.
If the driver’s (or front passemger’s)*
seat belt is not fastened when the
ignition switch is turned ON or if it is
disconnected after the ignition switch
is turned ON, the seat belt warning
light will illuminate until the belt is
fastened.
(Continued)
It is essential to replace the entire
assembly after it has been worn in
a severe impact even if damage to
the assembly is not obvious. Belts
should not be worn with straps
twisted. Each belt assembly must
only be used by one occupant; it is
dangerous to put a belt around a
child being carried on the occu
pant's lap.
•No modifications or additions
should be made by the user
which will either prevent the seat
belt adjusting devices from oper
ating to remove slack, or prevent
the seat belt assembly from being
adjusted to remove slack.(Continued)
WARNING
(Continued)
•When you fasten the seat belt, be
careful not to latch the seat belt in
buckles of other seat. It's very dan
gerous and you may not be pro
tected by the seat belt properly.
•Do not unfasten the seat belt and
do not fasten and unfasten the
seat belt repeatedly while driving.
This could result in loss of control,
and an accident causing death,
serious injury, or property dam
age.
•When fastening the seat belt,
make sure that the seat belt does
not pass
over objects that are
hard or can break easily.
•Make sure there is nothing in the
buckle. The seat belt may not be
fastened securely.
1GQA2083

2
"&t%'s%st&'!"'%!'&&

Infant or small child
You should be aware of the specific
requirements in your country. Child
and\for infant seats must be properly
placed and installed in the rear seat.
For more information about the use
of these restraints, refer to “Child
restraint system” in this section.Information
Small children are best protected
from injury in an accident when prop
erly restrained in the rear seat by a
child restraint system that meets the
requirements of the Safety Standards
of your country. \fefore buying any
child restraint system, make sure that
it has a label certifying that it meets
Safety Standards of your country. The
restraint must be appropriate for your
child's height and weight. Check the
label on the child restraint for this
information. Refer to “Child restraint
system” in this section.
Larger children
Children who are too large for child
restraint systems should always
occupy the rear seat and use the
available lap\fshoulder belts. The lap
por tion should be fastened and
snugged on the hips and as low as
possible. Check if the belt fits period
ically. A child's squirming could put
the belt out of position. Children are
given the most safety in the event of
an accident when they are restrained
by a proper restraint system in the
rear seat. If a larger child (over age
12) must be seated in the front seat,
the child should be securely
restrained by the available lap\fshoul
der belt and the seat should be
placed in the rearmost position.
Children age 12 and under should be
restrained securely in the rear seat.
NEVER place a child age 12 and
under in the front seat. NEVER place
a rear facing child seat in the front
seat of a vehicle.i
Every person in your vehicle
needs to be properly restrained at
all times, including infants and
children. Never hold a child in your
arms or lap when riding in a vehi
cle. The violent forces created
during a crash will tear the child
from your arms and throw the child
against the interior. Always use a
child restraint appropriate for your
child's height and weight.
WARNING

2
"&t%'s%st&'!"'%!'&&
Children riding in the car should sit in
the rear seat and must always be
properly restrained to minimize the
risk of injury in an accident, sudden
stop or sudden maneuver. According
to accident statistics, children are
safer when properly restrained in the
rear seats than in the front seat.
Larger children not in a child restraint
should use one of the seat belts pro
vided.
You should be aware of the specific
requirements in your country. Child
and\for infant safety seats must be
properly placed and installed in the
rear seat. You must use a commer
cially available child restraint system
that meets the requirements of the
Safety Standards of your country.
Child restraint systems are designed
to be secured in vehicle seats by the
lap belt portion of a lap\fshoulder belt.
Children could be injured or killed in
a crash if their restraints are not
properly secured. For small children
and babies, a child seat or infant seat
must be used. Before buying a par ticular child
restraint system, make sure it fits
your car seat and seat belts, and fits
your child. Follow all the instructions
provided by the manufacturer when
installing the child restraint system.
CH !D"$
%"# N%

%$M
•A child restraint system must be
placed in the rear seat. Never
install a child or infant seat on
the front passenger's seat.
Should an accident occur and
cause the passengerside air
bag to deploy, it could severely
injure or kill an infant or child
seated in an infant or child seat.
Thus only use a child restraint in
the rear seat of your vehicle.
•A seat belt or child restraint sys
tem can become very hot if it is
left in a cl

osed vehicle on a
sunny day, even if the outside
temperature does not feel hot.
Be sure to check the seat cover
and buckles before placing a
child there.
(Continued)
WARNING
(Continued)
•When the child restraint system
is not in use, store it in the lug
gage area or fasten it with a seat
belt so that it will not be thrown
forward in the case of a sudden
stop or an accident.
•Children may be seriously
injured or killed by an inflating
air bag. All children, even those
too large for child restraints,
must ride in the rear seat.

2
"&t%'s%st&'!"'%!'&&

To reduce the chance of serious or
fatal injuries:
•Children of all ages are safer
when restrained in the rear seat.
A child riding in the front passen
ger seat can be forcefully struck
by an inflating air bag resulting in
serious or fatal injuries.
•Always follow the instructions for
installation and use of the child
restraint maker.
•Always make sure the child seat
is secured properly in the car and
your child is securely
restrained
in the child seat.
•Never hold a child in your arms or
lap when riding in a vehicle. The
violent forces created during a
crash will tear the child from your
arms and throw the child against
the car’s interior.
(Continued)
WARNING (Continued)
•Never put a seat belt over yourself
and a child. During a crash, the
belt could press deep into the
child causing serious internal
injuries.
•Never leave children unattended
in a vehicle – not even for a short
time. The car can heat up very
quickly, resulting in serious
injuries to children inside. Even
very young children may inadver
tently cause the vehicle to move,
entangle themselves in the win
dows, or lock themselves or oth
ers inside the vehicle.
•Never allow two children, or any
two persons, to use the same seat
belt.
•Children often squirm and reposi
tion themselves improperly.
Never let a child ride with the
shoulder belt under their arm or
behind their back. Always proper
ly position and secure children in
rear seat.(Continued)
(Continued)
•Never allow a child to standup or
kneel on the seat or floorboard of
a moving vehicle. During a colli
sion or sudden stop, the child can
be violently thrown against the
vehicles interior, resulting in seri
ous injury.
•Never use an infant carrier or a
child safety seat that "hooks"
over a seatback, it may not pro
vide adequate security in an acci
dent.
•Seat belts can become very hot,
especially when the ca
r is parked
in direct sunlight. Always check
seat belt buckles before fasten
ing them over a child.
•After an accident, we recom
mend that the system be
checked by an authorized
HYUNDAI dealer.
•If there is not enough space to
place the child restraint system
because of the driver's seat,
install the child restraint system
in the rear right seat.

29
"&t%'s%st&'!"'%!'&&

Installing a child restraint systemby lap\fshoulder belt
To install a child restraint system on
the outboard or center rear seats, do
the following:
1. Place the child restraint system in
the seat and route the lap\fshoul
der belt around or through the
restraint, following the restraintmanufacturer’s instructions. Be
sure the seat belt webbing is not
twisted. 2. Fasten the lap\fshoulder belt latch
into the buckle. Listen for the dis
tinct “click” sound.Position the release button so that it is easy to access in case of an emergency.
3. Buckle the seat belt and allow the seat belt to take up any slack. After
installation of the child restraint
system, try to move it in all direc
tions to be sure the child restraint
system is securely installed.
If you need to tighten the belt, pull
more webbing toward the retractor.
When you unbuckle the seat belt and
allow it to retract, the retractor will
automatically revert back to its nor
mal seated passenger emergency
locking usage condition.
MMSA3030E2BLD310
E2MS103005