radiator LAMBORGHINI GALLARDO 2009 Owner's Guide
Page 511 of 1659
1
L714 02 60 00
Fig.1
GF
BACD
E
® Automobili Lamborghini S.p.A.
7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Air conditioning system
7 K H D L U F R Q G L W L R Q L Q J V \ V W H P S U R Y L G H G Z L W K W K H Y H K L F O H K R O G V W K H W H P S H U D W X U H D Q G D L U À R Z L Q W K H S D V V H Q J H U F R P S D U W P H Q W
to the values set by the driver and the passenger. The air conditioning system has the following features:•
automatic temperature-ventilation-air distribution control
• recirculation
• D L U À R Z G L V W U L E X W L R Q
The system’s operation is controlled by a special electronic control unit set by the driver and passenger on the
control unit’s push-button panel.
The system has an air conditioning unit ( B-Fig.1 W K D W P R G L ¿ H V W K H W H P S H U D W X U H D Q G K X P L G L W \ R I W K H D L U H Q W H U L Q J W K H
vehicle by means of two radiators (driver and passenger side) connected to a heating system that receives heat from
the engine (green lines) and an evaporator, part of an air conditioning system (red and blue lines).
Air conditioner diagram (Fig.1)
A. Air conditioner control unit
B. Air conditioning unit
C. Engine coolant pump
D. Engine
E. Air conditioner compressor
F. Air conditioner pressure sensor
G. Condenser
Page 514 of 1659
4
L714 02 60 00
ABC
D
E
F
G
H
I
L
M
1O 3
Q
R
S
T
Fig.5
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
The heating, air conditioning and air distribution unit includes: • P R W R U L ] H G À D S V I R U Y H Q W L O D W L R Q D Q G G L V W U L E X W L R Q F R Q W U R O
• internal and outside temperature sensors for temperature control
• S R O O H Q ¿ O W H U V I R U D L U H Q W H U L Q J W K H S D V V H Q J H U F R P S D U W P H Q W
+ H D W L Q J D L U F R Q G L W L R Q L Q J D Q G D L U G L V W U L E X W L R Q X Q L W F R P S R Q H Q W V ) L J
A. 8 S S H U Y H Q W V À D S D F W X D W R U
B. 8 S S H U Y H Q W V À D S
C. ' H I U R V W L Q J Y H Q W V À D S D F W X D W R U
D. RH radiator temperature sensor
E. Evaporator temperature sensor (deicer)
F. & H Q W H U Y H Q W V À D S
G. Cold air actuator for center vents
H. & R O G D L U À D S I R U F H Q W H U Y H Q W V
I. 5 + O R Z H U Y H Q W À D S
L. / R Z H U À D S V D F W X D W R U
M. Evaporator expansion valve
1 RH radiator inlet
O. LH radiator inlet
3 Radiator outlet
R. Center vents actuator
S. / + O R Z H U Y H Q W À D S
T. ) O D S I R U / + S R O O H Q ¿ O W H U
U. LH radiator temperature sensor
Page 515 of 1659
5
L714 02 60 00
Fig.6
C
ED
B
F
A
® Automobili Lamborghini S.p.A.
7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Air conditioning system
The evaporator inside the air conditioning unit is powered by a compressor located next to the engine. The system’s
condenser is installed in front of the right front radiator of the engine’s cooling system.The coolant used by the air conditioning system is R134a.
Air conditioning system (Fig.6)
A.
Air conditioning unit
B. Compressor
C. Condenser
D. Receiver-drier
E. & R R O D Q W ¿ O O L Q J G U D L Q L Q J Y D O Y H
F. Coolant pressure sensor
Page 527 of 1659
6
L714 02 60 03
) L J
A
) L J
) L J
(
(
%
CC
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
' / H I W W H P S H U D W X U H V H Q V R U D Q G F H Q W H U D L U À D S D F W X D W R U G L V D V V H P E O \ To disassemble the following sensors on the driver side:
• LH radiator temperature sensor
• Center vents actuator
proceed as described: 1. Disassemble the driver side panel of the center console ( $ ) L J ) secured to the chassis using the pins.
2. Disassembling the instrument cluster dashboard cover
• Disassemble the Kombi ornament. The ornament is pressed in without screws.
• Disassemble the Kombi instrument cluster using the fasteners ( % ) L J ).
• Disassemble the dashboard cover by removing the two screws ( & ) L J ) on the sides of the dashboard
cover.
Page 528 of 1659
7
L714 02 60 03
( '
) L J
G
)
) L J
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
3. Disassemble the driver side lower dashboard assembly.
• Remove the dashboard side cover left cap ( ' ) L J ).
• ' L V D V V H P E O H W K H G U L Y H U V L G H O R Z H U G D V K E R D U G D V V H P E O \ ¿ Q L V K L Q J H O H P H Q W
• 2 screws ( ( ) L J ) are inside the dashboard cover
• 2 screws are near the side member cover
• one screw is near the center console
4. Disassembling the actuators of the center vents ( ) ) L J )
• Remove the connector from the actuator.
• Unscrew the three screws on the actuator. Remove the actuator.
5. Disassembling the LH radiator temperature sensor ( * ) L J )
• Disconnect the sensor connector by pressing on the sides.
• Turn the sensor 90° to extract it from the air conditioning unit.
Page 529 of 1659
8
L714 02 60 03
) L J ) L J
C '
A
) L J
%
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
( 5 L J K W W H P S H U D W X U H V H Q V R U D Q G F H Q W H U F R O G D L U À D S D F W X D W R U G L V D V V H P E O \
To disassemble the following sensors on the passenger side air conditioner: • RH radiator temperature sensor
• Cold air actuator for center vents
Proceed as follows: 1. Disassemble the passenger side panel of the center console secured to the chassis using the pins ( $ ) L J ).
2. Disassemble the passenger side footrest panel ( % ) L J ).
3. Disassemble the passenger side lower dashboard assembly (including the glove box):
• Open the glove box and remove the two screws ( & ) L J ) that secure it to the upper dashboard ( '
) L J ).
Page 531 of 1659
10
L714 02 60 03
) L J
M
1
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
4. Disassembling the cold air actuators of the center vents ( 0 ) L J )
• Remove the actuator’s connector.
• Unscrew the three screws on the actuator. Remove the actuator.
5. Disassembling the RH radiator temperature sensor ( 1 ) L J )
• Disconnect the sensor connector by pressing on the sides.
• Turn the sensor 90° to extract it from the air conditioning unit.
Page 537 of 1659
16
L714 02 60 03
) L J
C
C
'
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
2. Release the air conditioner radiator by loosening the 4 screws ( & ) L J ).
3. Disconnect the 2 air conditioner pipes by loosening the 2 screws ( ' ) L J ).
4. Remove the air conditioner radiator.
Page 540 of 1659
19
L714 02 60 03
) L J
A1
A
%
C
'
A2
® Automobili Lamborghini S.p.A.
7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
) 5 2 1 7 3 $ 5 7 3 U H O L P L Q D U \ R S H U D W L R Q V •
Empty the air conditioning system (026007).
• ' L V D V V H P E O H W K H I U R Q W D Q G F H Q W U H À D W À R R U V (082503).
• Disassemble the propeller shaft (030703).
• Disassemble the front differential (040903).
• Disassemble the luggage compartment tray (080603).
' L V D V V H P E O L Q J S L S H $ 1. Disconnect pipe A1 on the radiator and loosen the screw ( $ ) L J ).
2 8 Q I D V W H Q W K H V S H F L ¿ F V F U H Z & ) L J W R O R R V H Q W K H ¿ [ L Q J F O L S % ) L J ).
3 . Disconnect the union ( ' ) L J R Q S L S H $ V R W K H ¿ U V W S D U W R I W K H S L S H F D Q E H U H P R Y H G H [ W U D F W I U R P W K H I U R Q W
of the vehicle.
Page 542 of 1659
21
L714 02 60 03
) L J
%
C
A
A2
® Automobili Lamborghini S.p.A.
7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
' L V D V V H P E O L Q J S L S H $ 1.
Loosen the screw ( $ ) L J ) to disconnect pipe A2 from the radiator.
2. / R R V H Q W K H V S H F L ¿ F V F U H Z & ) L J W R O R R V H Q W K H ¿ [ L Q J F O L S % ) L J ).