maintenance schedule Lancia Musa 2007 Owner handbook (in English)

IMPORTANT - Battery
The charge in the battery should be checked at the
start of winter to limit the risk of electrolyte
freezing.This check should be carried out more frequently if
the car is used mainly for short trips, or if it is fitted
with accessories that permanently absorb electricity
even with the ignition key removed, especially in the
case of after market accessories. If the car is used in
hot climates or particularly harsh conditions it is
wise to check the level of the battery fluid
(electrolyte) more frequently than specified in the
“Service schedule” in this section.
296
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Car maintenance should be entrusted to Lancia Dealership. For routine and minor maintenance
operations you wish to carry out yourself, always make sure you have the proper equipment,
genuine Lancia spare parts and the necessary fluids; do not however carry out these operations if
you have no experience.

BRAKE FLUID
Unscrew cap: check that the fluid level in the reservoir is at
maximum.
Fluid level in the reservoir shall not exceed the MAX mark.
If fluid has to be added, it is suggested to use the brake fluid in table
"Fluids and lubricants" (see chapter "Technical characteristics").
NOTE Clean accurately the tank cap and the surrounding surface.
At plug opening, pay maximum attention in order to prevent any
impurities from entering the tank.
For topping up, always use a funnel with integrated filter with mesh
equal to or lower than 0.12 mm.
IMPORTANT Brake fluid absorbs moisture, for this reason, if the car
is mainly used in areas with a high degree of atmospheric humidity,
the fluid should be replaced at more frequent intervals than specified
in the “Service schedule”.
303
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0213m
Prevent brake fluid, which is highly corrosive, from coming into contact with painted parts.
Should it happen, immediately wash with water.
Symbolπon the container indicates synthetic brake fluid, distinguishing it
from the mineral kind. Using mineral fluids irreversibly damages the special
braking system rubber seals.
WARNING
Brake fluid is poisonous and highly corrosive. In the event of accidental contact,
wash the parts involved immediately with neutral soap and water, then rinse
thoroughly. Call the doctor immediately if the fluid is swallowed.
WARNING

If the battery is not fitted with electrolyte level
indicator, the relevant checks must only be carried
out by authorised personnel.
To check the battery charge, slacken the two
fastening screws and open the cover. Check the
battery charge and then reclose the cover, take care
to prevent pinching and short circuits.CHANGING THE BATTERY
If required, replace the battery with a genuine spare
part having the same specifications.
If a battery with different specifications is fitted, the
service intervals given in the “Service schedule” in
this section will no longer be valid. Refer to the
instructions provided by the battery manufacturer.
306
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WARNINGWhen working on the battery or near it, always wear the proper goggles. Batteries contain substances that are very harmful for the environment. You are advised to have
the battery changed at a Lancia Dealership, which is properly equipped for disposing of used
batteries respecting nature and the law.
Incorrect fitting of electrical and electronic accessories can seriously damage the car.
If after buying the car, you want to install electric accessories which require permanent electric
supply (alarm, free-hand phone kit, etc.) contact Lancia Dealership whose qualified personnel, in
addition to suggesting the most suitable devices, will evaluate the overall electric absorption,
checking whether the car’s electric system is capable of withstanding the load required, or whether
it should be integrated with a more powerful battery.
If the car is left inactive for long periods at cold, remove the battery and store it
in a warm place to prevent freezing.
WARNING

RUBBER HOSES
As far as the brake system and fuel rubber hoses are
concerned, carefully follow the “Service schedule”
in this section.
Indeed ozone, high temperatures and prolonged
lack of fluid in the system may cause hardening and
cracking of the hoses, with possible leaks. Careful
control is therefore necessary.
WINDSCREEN/
REAR WINDOW WIPERS
BLADES
Periodically clean the rubber part using special
products; TUTELA PROFESSIONAL SC 35 is
recommended.
If the rubber blades are bent or worn they should be
replaced. In any case they should be changed once a
year.
A few simple notions can reduce the possibility of
damage to the blades:
❒if the temperature fall below zero, make sure
that ice has not frozen the rubber against glass.
If necessary, thaw using an antifreeze product;
❒remove any snow from the glass: in addition to
protecting the blades, this prevents effort on the
motor and overheating;
❒do not operate the windscreen and rear window
wipers on dry glass.
311
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WARNINGDriving with worn wiper blades is a serious hazard, because visibility is reduced
in bad weather.

FLUIDS AND LUBRICANTS
RECOMMENDED PRODUCTS AND THEIR SPECIFICATIONS
Use
Lubricants
for petrol
engines
Lubricants for
diesel engines
For regular operation of Multijet versions with DPF, use only original oil. In an emergency (lacking the original product) only top up with
max. 0,5 l and then drive immediately to the nearest Lancia Dealership.
If using non original SAE 5W-40 products, oils with minimum ACEA A3 specifications for petrol engines and ACEA B4 specifications for
Diesel engines are admitted; in this event top engine performance is not guaranteed.
Use of products with low-quality properties than ACEA A3 and ACEA B4 could cause damages to the engine that are not covered by the
warranty.
For use with very cold temperatures, ask Lancia Dealership for proper Seleniagroup product. Fluid and lubricant specifications
for correct car operation
Synthetic-based oils, grade SAE 10W-40, ACEA A3, AP SL;
FIAT 9.55535-G2qualification
Synthetic-based oils, grade SAE 5W-40,
FIAT 9.55535-M2 qualificationOriginal fluids
and lubricants
SELENIA 20K
SELENIA WRChange
333
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARDAND CONTROLS
SAFETY
DEVICES
ACORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICALSPECIFICATIONS
According to
Service Schedule
According to
Service Schedule

337
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICALSPECIFICATIONS
DASHBOARDAND CONTROLS
INDEX
INDEX
ABS (system) ...................... 138
ASR (system) ...................... 142
Accessories purchased
by the user ........................ 149
Air bags (front) ................... 175
– driver's air bag ............... 176
– passenger's front air bag . 176
– passenger's front air bag
manual deactivation ...... 177
– side bags .......................... 178
Air vents ............................. 82
Ashtray (Smokers’ kit) ....... 123
At the filling station............. 154
Automatic two-zone climate
control system ..................... 88
Battery
– checking the charge ........ 305
– jump starting .................. 254
– recharging ...................... 286
– replacing ........................ 306
Bodywork
– maintenance .................. 314
– version codes .................. 321
Bonnet ................................ 134
Boot ................................... 129
– extension ........................ 134– light ................................ 279
Brake lights
– bulb replacement ............ 276
Brakes
– fluid level ...................... 303
– handbrake ..................... 187
– technical data ................. 324
Bulb (replacement).............. 268
Capacities ........................... 332
Car inactivity ..................... 208
Car maintenance............... 290
– additional checks ............ 294
– Annual Inspection
Schedule ......................... 294
– scheduled service ............ 291
– Service Schedule ............. 292
Carrying children safely ...... 165
Ceiling lights ....................... 112
– bulb replacement ............ 277
Cellular telephone
– presetting........................ 148
Checking fluid levels ......... 297
Child lock ........................... 14Cigar lighter (Smokers’ kit) ... 123
Clutch ................................ 323
CO
2emissions .................... 336
Correct use of the car ....... 183
Cruise Control .................... 109
Current sockets ................... 122
Dashboard and controls.. 7-23
Diesel fuel filter .................. 304
Dimensions.......................... 329
Dipped beam headlights
– bulb replacement ............ 272
– control ........................... 99
Direction indicators ............ 101
– bulb replacement ............ 273
– control ........................... 101
Door pockets ....................... 120
Doors .................................. 11
– emergency device for
locking doors from
outside ........................ 11-252
Dual FuNction System
gearbox ............................. 189
– oil level ........................... 301
Dualdrive
(electric power steering) ... 150