Lexus GS300h 2013 Owner's Manual

737
6 6-3. Do-it-yourself maintenance
Maintenance and care
GS450h_300h_OM_OM30D53E_(EE)
CAUTION
When raising your vehicle
Make sure to observe the following precautions to reduce the possibility of
death or serious injury:
When using a floor jack, follow the instructions of the manual provided
with the jack.
Do not use the jack that was supplied with your vehicle.
Do not put any part of your body underneath the vehicle when it is sup-
ported only by the floor jack.
Always use floor jack and/or automotive jack stands on a solid, flat, level
surface.
Do not start the hybrid system while the vehicle is supported by the floor
jack.
Stop the vehicle on level, firm ground, firmly set the parking brake and
shift the shift lever to P.
Make sure to set the floor jack properly at the jack point.
Raising the vehicle with an improperly positioned floor jack will damage
the vehicle and may cause the vehicle to fall off the floor jack.
Do not raise the vehicle while someone is in the vehicle.
When raising the vehicle, do not place any object on top of or underneath
the floor jack.
Lift up the vehicle using a floor jack
such as the one shown in the illustra-
tion.

7386-3. Do-it-yourself maintenance
GS450h_300h_OM_OM30D53E_(EE)
Engine compartment
GS300h
12-volt battery
P. 7 4 9
Power control unit coolant
reservoir (P. 745)
Engine oil level dipstick
(P. 741)
Engine oil filler cap (P.
742)
Engine coolant reservoir
(P. 744)Fuse box (P. 782)
Washer fluid tank (P. 748)
Electric cooling fans
Condenser (P. 747)
Radiator (P. 747)1
2
3
4
5
6
7
8
9

739 6-3. Do-it-yourself maintenance
6
Maintenance and care
GS450h_300h_OM_OM30D53E_(EE)
GS450h
12-volt battery
P. 7 4 9
Engine oil level dipstick
(P. 741)
Engine coolant reservoir
(P. 744)
Engine oil filler cap (P.
742)
Power control unit coolant
reservoir (P. 745)Fuse box (P. 782)
Washer fluid tank (P. 748)
Electric cooling fans
Condenser (P. 747)
Radiator (P. 747)1
2
3
4
5
6
7
8
9

7406-3. Do-it-yourself maintenance
GS450h_300h_OM_OM30D53E_(EE)
Removing the engine compartment cover
Right-hand side
Center
Installing the clips
Push up center portion
Insert
Press
Engine compartment cover
1
2
3
NOTICE
Checking the engine compartment cover after installation
Make sure that the cover is securely installed in its original position.

741 6-3. Do-it-yourself maintenance
6
Maintenance and care
GS450h_300h_OM_OM30D53E_(EE)
With the engine at operating temperature and turned off, check the
oil level on the dipstick.
Checking the engine oil
Park the vehicle on level ground. After warming up the engine
and turning off the hybrid system, wait more than 5 minutes
for the oil to drain back into the bottom of the engine.
Holding a rag under the end, pull the dipstick out.
Wipe the dipstick clean.
Reinsert the dipstick fully.
Holding a rag under the end, pull the dipstick out and check
the oil level.
Low
Normal
Excessive
The shape of the dipstick
may differ depending on the
type of vehicle or engine.
Wipe the dipstick and reinsert it fully.
Engine oil
1
2
GS300hGS450h
3
4
5
1
2
3
6

7426-3. Do-it-yourself maintenance
GS450h_300h_OM_OM30D53E_(EE)
Adding engine oil
If the oil level is below or near the low level mark, add engine oil
of the same type as that already in the engine.
Make sure to check the oil type and prepare the items needed
before adding oil.
Remove the oil filler cap by turning it counterclockwise.
Add engine oil slowly, checking the dipstick.
Install the oil filler cap by turning it clockwise.
GS300hGS450h
Engine oil selectionP. 9 3 1
Oil quantity (Low  Full) 1.5 L (1.6 qt., 1.3 Imp.qt.)
Items Clean funnel
1
2
3

743 6-3. Do-it-yourself maintenance
6
Maintenance and care
GS450h_300h_OM_OM30D53E_(EE)
Engine oil consumption
A certain amount of engine oil will be consumed while driving. In the fol-
lowing situations, oil consumption may increase, and engine oil may need to
be refilled in between oil maintenance intervals.
When the engine is new, for example directly after purchasing the vehicle
or after replacing the engine
If low quality oil or oil of an inappropriate viscosity is used
When driving at high engine speeds or with a heavy load, when towing, or
when driving while accelerating or decelerating frequently
When leaving the engine idling for a long time, or when driving frequently
through heavy traffic
CAUTION
Used engine oil
Used engine oil contains potentially harmful contaminants which may
cause skin disorders such as inflammation and skin cancer, so care should
be taken to avoid prolonged and repeated contact. To remove used engine
oil from your skin, wash thoroughly with soap and water.
Dispose of used oil and filters only in a safe and acceptable manner. Do
not dispose of used oil and filters in household trash, in sewers or onto the
ground.
Call any authorized Lexus dealer or repairer, or another duly qualified and
equipped professional, service station or auto parts store for information
concerning recycling or disposal.
Do not leave used engine oil within the reach of children.
NOTICE
To prevent serious engine damage
Check the oil level on a regular basis.
When replacing the engine oil
Be careful not to spill engine oil on the vehicle components.
Avoid overfilling, or the engine could be damaged.
Check the oil level on the dipstick every time you refill the vehicle.
Be sure the engine oil filler cap is properly tightened.

7446-3. Do-it-yourself maintenance
GS450h_300h_OM_OM30D53E_(EE)
The coolant level is satisfactory if it is between the “FULL” and
“LOW” lines on the reservoir when the hybrid system is cold.
Engine coolant reservoir
Reservoir cap
“FULL” line
“LOW” line
If the level is on or below the “LOW” line, add coolant up to the
“FULL” line. (P. 915)
Coolant
GS300hGS450h
1
2
3

745 6-3. Do-it-yourself maintenance
6
Maintenance and care
GS450h_300h_OM_OM30D53E_(EE)
Power control unit coolant reservoir
GS300hGS450h
Reservoir cap
“F” line
“L” lineReservoir cap
“FULL” line
“LOW” line
If the level is on or below the
“L” line, add coolant up to the
“F” line. (P. 9 1 5 )If the level is on or below the
“LOW” line, add coolant up to
the “FULL” line. (P. 915)
1
2
3
1
2
3

7466-3. Do-it-yourself maintenance
GS450h_300h_OM_OM30D53E_(EE)
Coolant selection
Only use “Toyota Super Long Life Coolant” or a similar high quality eth-
ylene glycol based non-silicate, non-amine, non-nitrite, and non-borate cool-
ant with long-life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a mixture of 50% coolant and 50%
deionized water. (Minimum temperature: -35C [-31F])
For more details about coolant, contact any authorized Lexus dealer or
repairer, or another duly qualified and equipped professional.
If the coolant level drops within a short time of replenishing
Visually check the radiator, hoses, engine/power control unit coolant reser-
voir caps, drain cock and water pump.
If you cannot find a leak, have any authorized Lexus dealer or repairer, or
another duly qualified and equipped professional, test the cap and check for
leaks in the cooling system.
CAUTION
When the hybrid system is hot
Do not remove the engine/power control unit coolant reservoir caps or the
coolant inlet cap. (P. 9 2 1 )
The cooling system may be under pressure and may spray hot coolant if the
cap is removed, causing serious injuries, such as burns.
NOTICE
When adding coolant
Coolant is neither plain water nor straight antifreeze. The correct mixture of
water and antifreeze must be used to provide proper lubrication, corrosion
protection and cooling. Be sure to read the antifreeze or coolant label.
If you spill coolant
Be sure to wash it off with water to prevent it from damaging parts or paint.