engine coolant MERCEDES-BENZ CLS63AMG 2008 W219 Owner's Guide

452 Technical data
Fuels, coolants, lubricants etc.
Gasoline additives
A major concern among engine manufac-
turers is carbon build-up caused by gaso-
line. Mercedes-Benz recommends only the
use of quality gasoline containing additives
that prevent the build-up of carbon depos-
its.
After an extended period of using fuels
without such additives, carbon deposits
can build up especially on the intake valves
and in the combustion area, leading to
engine performance problems such as:

Warm-up hesitation

Unstable idle

Knocking/pinging

Misfire

Power lossIn areas where carbon deposits may be
encountered due to lack of availability of
gasolines which contain these additives,
Mercedes-Benz recommends the use of
additives approved by us for use on
Mercedes-Benz vehicles. Refer to Factory
Approved Service Products pamphlet (USA
only) or contact an authorized
Mercedes-Benz Center for a listing of ap-
proved product(s). Follow directions on
product label.
Do not blend other fuel additives with fuel.
This only results in unnecessary costs and
may be harmful to the engine operation.
Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which pro-
vides:

Corrosion protection

Freeze protection

Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -35°F (-37°C) and corro-
sion protection.
!Damage or malfunction resulting from poor
fuel quality or from blending additional fuel addi-
tives other than those tested and approved by us
for use on Mercedes-Benz vehicles listed in the
Factory Approved Service Products pamphlet
are not covered by the Mercedes-Benz Limited
Warranty.!Add premixed coolant solution only. Adding
water and MB 325.0 Anticorrosion/Antifreeze
separately from each other, could cause engine
damage not covered by the Mercedes-Benz Lim-
ited Warranty.

453 Technical data
Fuels, coolants, lubricants etc.
If the antifreeze mixture is effective to
-35°F (-37°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).
The coolant solution must be used year
round to provide the necessary corrosion
protection and increase boil-over protec-
tion. Refer to Maintenance Booklet for re-
placement interval.
Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 Anticorrosion/Antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products pam-
phlet) are used to renew the coolant con-
centration or bring it back up to the proper
level.For information on other Mercedes-Benz
approved products of equal specification,
refer to the Factory Approved Service
Products pamphlet (USA only) or contact
an authorized Mercedes-Benz Center.
To provide important corrosion protection,
the solution must be at least 50% anticor-
rosion/antifreeze (equivalent to freeze
protection to approximately -35°F
[-37°C]). If you use a solution that is more
than 55% anticorrosion/antifreeze (freeze
protection to approximately -49°F
[-45°C]), the engine temperature will in-
crease due to the lower heat transfer capa-
bility of the solution. Therefore, do not use
more than this amount of anticorro-
sion/antifreeze.If the coolant level is low, water and
MB 325.0 Anticorrosion/Antifreeze
should be used to bring it up to the proper
level (have cooling system checked for
signs of leakage). Please make sure the
mixture is in accordance with label instruc-
tions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult an authorized Mercedes-Benz Center.

454 Technical data
Fuels, coolants, lubricants etc.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum parts. Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.
Therefore, the following product is strongly
recommended for use in your vehicle:
MB 325.0 Anticorrosion/Antifreeze agent.Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to your authorized Mercedes-Benz
Center for service.
Anticorrosion/antifreeze quantity
ModelApproximate freeze protection
-35°F (-37°C)-49°F (-45°C)
CLS 5506.0 US qt (5.7 l)6.6 US qt (6.2 l)
CLS 63 AMG6.2 US qt (5.9 l)6.9 US qt (6.5 l)

455 Technical data
Fuels, coolants, lubricants etc.
Washer system and headlamp cleaning
system*
Both the washer system and headlamp
cleaning system* are supplied from the
washer reservoir.
The washer reservoir has a capacity of ap-
proximately 6.9 US qt. (6.5 l).
Refill the reservoir with MB Windshield
Washer Concentrate and water (or con-
centrate and commercially available
premixed washer solvent/antifreeze,
depending on ambient temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point, use
MB Windshield Washer Concentrate
“MB SummerFit” and water:

1 part “MB SummerFit” to 100 parts
water
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gal [4.0 l] water).
For temperatures below freezing point use
MB Windshield Washer Concentrate
“MB SummerFit” and commercially avail-
able premixed washer solvent/antifreeze:

1 part “MB SummerFit” to 100 parts
solvent
(1.34 fl oz [40 ml] “MB SummerFit” to
1 gal [4.0 l] solvent).
Warning!G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You can be seriously burned.

462 Index
Emergency, In case of
Batteries, Jump starting 423
First aid kit 393
Flat tire, changing 412
Fuses 428
Hazard warning flasher 132
Instrument cluster, Indicator
lamps 346
Instrument cluster, indicator
lamps 344
Roadside Assistance 12
Towing the vehicle 344
Emission control 281
Information label 435
System warranties 10
Engine 437
Belt layout 436
Block heater* (Canada only) 329
Break-in recommendations 270
Cleaning 335
Compartment 286
Malfunction indicator lamp 348, 349,
375
Maximum engine speed 437
Number 434, 435
Starting 51Starting with KEYLESS-GO* 52
Tachometer 27
Technical data 437
Turning off with KEYLESS-GO* 61
Turning off with the SmartKey 61
Engine compartment
Hood 286
Engine coolant see Coolant 290
Engine oil 287, 448
Adding 289
Additives 450
Changing 450
Checking level 288
Consumption 287
Filler neck 289
Messages in display 379
Oil dipstick 288
Recommended engine oils and oil
filters 450
ESP
®92
Messages in display 360, 374
Warning lamp 345, 346
ETD
Safety guidelines 68
Exterior lamp switch 126Exterior rear view mirrors 47
Parking position 184
Exterior view 22
F
Factory settings
Resetting 153
SmartKey with KEYLESS-GO* 106
Filler neck, Engine oil 289
First aid kit 393
Flat tire 412
Collapsible tire 415, 416
Jacking up the vehicle 414
Lowering the vehicle 418
Mounting the spare wheel 412, 415
Preparing the vehicle 412
Spare wheel 412
Floormats 252
Fluids
Automatic transmission fluid 448
Brake fluid 449
Capacities 448
Engine coolant 449
Engine oil 448
Power steering fluid 449
Washer and headlamp cleaning
system 449

466 Index
Lamps, indicator and warning
ABS 27, 344
Air bag off 70
Battery (SmartKey) 102
Brakes 347
CHECK ENGINE 27, 348, 349
Coolant 350
Distance warning lamp* 220, 226
Engine diagnostics 348, 349
Engine malfunction 27, 348, 349
ESP
®27, 345, 346
Fog lamps 129
Front passenger front air bag off 29,
356, 357
Fuel reserve 27, 351
High beam headlamps 27
Instrument cluster 344, 346
Seat belt telltale 27, 351, 352
SRS 65
Turn signals 27
Language, Setting 155
LATCH type child seat anchors 86
Layout of poly-V-belt drive 436
License plate lamps 406
Messages in display 385
Replacing bulbs 409Light alloy wheels, cleaning 339
Lighter see Cigarette lighter
Lighting 126
Automatic headlamp mode 127
Combination switch 130
Daytime running lamp mode 128
Door entry lamps 135
Exterior lamp switch 126
Front fog lamps 129
High beams 130
Instrument cluster illumination 136
Interior 133
Locator lighting 129
Low beam 126
Manual headlamp mode 127
Night security illumination 129
Parking lamps 126
Rear fog lamp 129
Settings (control system) 159
Trunk lamp 135
Limp-home mode 182
Loading see Vehicle loading
Loading the vehicle 296
Locator lighting 129, 160
Lock button (KEYLESS-GO*)
Door handle 62Locking the vehicle 59
In an emergency 399
Locking/Unlocking, SmartKey 36, 102
Locking/Unlocking, SmartKey with
KEYLESS-GO* 37
Loss of
Key, Mechanical 108
Key, SmartKey 108
Key, SmartKey with
KEYLESS-GO* 108
Loss of Service and Warranty Information
Booklet 433
Low beam headlamps 55
Indicator lamp 27
Replacing bulbs 408
Switching on 55
Lubricants 448
Lumbar support 119

467 Index
M
Main Dimensions 447
Maintenance 12
Calling up service indicator 331
Clearing service indicator
message 331
Resetting service indicator 332
Service indicator message 330
Service term exceeded 331
Maintenance, Maintenance system 330
Manual headlamp mode 127
Manual shift program CLS 63 AMG 179
Deactivating 181
Maximum load rating, Tires 324
Maximum loaded vehicle weight 324
Maximum tire inflation pressure 325
Mechanical key 398
Memory functions 123
Menus see Control system menus
Microphone, Hands-free 31
Minispare wheel see Spare wheel 393Mirrors
Adjusting 47
Auto-dimming 183
Exterior rear view mirror 47
Exterior rear view mirror parking
positions 184
Interior rear view mirror 47
Storing exterior mirror parking
position 125
Mobile phone see Telephone*
MOE tires* see MOExtended system*
MOExtended system* 313, 419
MOExtended tires* 313, 444
MON 284
MP3
Selecting track 150
Multicontour seat* 120
Multifunction display 139
Changing settings see Control system
menus and Control system
submenus 139
Selecting language 155
Multifunction display messages
ABS 360, 374
Airmatic DC 391, 392
Brake fluid 374Brake pads 373
Check engine 348, 349
Coolant 375, 376, 377
Cruise control 361
Distronic* 361
Door 372
Engine oil 379
ESP
®360, 363, 374
Fog lamps 382–384, 386
Hood 372
Light sensor 385
Parking brake 374
Parking lamps 384
PRE-SAFE
®360, 368
Reserve fuel 380
SmartKey with KEYLESS-GO* 380,
381
SRS 388
Tail lamps 386, 387
Tele Aid 388
Telephone* 391
Tires 390
Trunk 372
Turn signals 387
Windshield washer fluid 391

472 Index
Storing
Positions into memory (Memory
function*) 124
Tires 295
Submenus see Control system submenus
Substitute bulbs see Auxiliary bulbs
Sun visors 184
Sunroof see Power tilt/sliding sunroof
Sunshade*, rear window 185
Suspension tuning
For comfortable driving style 230
For sporty driving style 230
Symbols used in this operator’s
manual 15
T
Tachometer 27, 138
Overspeed range 138
Tail lamps
Messages in display 386, 387
Replacing bulbs 409
Tar stains 334Technical data
Air conditioning refrigerant 450
Brake fluid 450
Capacities fuels, lubricants etc. 448
Coolant 452
Dimensions 447
Electrical system 446
Engine 437
Engine oil additives 450
Engine oils 450
Fuel requirements 451
Gasoline additives 452
Premium unleaded gasoline 451
Rims and tires 438
Washer and headlamp cleaning
system 449
Weights 447Tele Aid 256
Emergency calls 257
Information 260
Initiating an emergency call
manually 258
Messages in display 388
Remote door unlock 261
Roadside assistance 259
SOS button 258
Stolen vehicle Recovery services 262
System self-check 257
Telephone cradle
Changing 255
Telephone* 28, 253
Answering/ending a call 167
Changing mobile phone cradle 255
Compartment 243
Hands-free microphone 31
Inserting in cradle 254
Installing a different mobile phone
cradle 255
Messages in the display 391
Operation 166
Phone book 167
Redialing 168
Removing from cradle 255