ignition MITSUBISHI MONTERO 1998 Service Manual
Page 15 of 1501
Water Pump Bolt (Diamante)
8 mm Bolt .............................................. 18 (24)\
10 mm Bolt ............................................. 30 (41)\
INCH Lbs. (N.m)
Crankshaft & Drive Plate
Bell Housing ............................................ 79.7 (9)\
Oil Seal Case .......................................... 97.3 (11)\
Rear Plate (Montero) ................................... 97.3 (11\
)
Exhaust Manifold
Heat Shield ........................................... 123.9 (14)\
Oil Level Gauge Guide Bolt ............................ 123.9 (14)\
Generator & Drive Belt
Cooling Fan Bolt (Montero) ............................. 97.3 (11\
)
Cooling Fan Nut (Montero) .............................. 97.3 (11\
)
Timing Indicator Bolt (Montero) ........................ 97.3 (11\
)
Intake Manifold & Fuel
ECT Gauge Sender ....................................... 97.4 (11)\
Fuel Pressure Regulator Bolt ............................ 79.6 (9)\
Fuel Pipe Banjo Bolt .................................... 79.6 (9)\
Injector & Fuel Rail Bolt ............................. 106.2 (12)\
Water Outlet Pipe ..................................... 123.9 (14)\
Intake Plenum & Throttle Body
Ignition Coil Bolt (Montero) ............................ 115 (13\
)
Manifold Differential Pressure (MDP) Sensor ............. 44 (4.9\
)
Throttle Body Bolt ...................................... 106 (12)\
Vacuum Hose Assembly (Diamante) ......................... 88 (9.8\
)
Oil Pan & Oil Pump
Baffle Plate (Montero) ................................. 97.3 (11\
)
Baffle Plate (Diamante) ................................ 97.3 (11\
)
6 mm Bolt ............................................... 53.1 (6)\
8 mm Bolt ............................................... 79.6 (9)\
Oil Pump Cover Bolt (Diamante) ......................... 88.5 (10\
)
Oil Pump Cover Bolt (Montero)
6 mm x 10 mm Bolt .................................... 97.3 (11)\
6 mm x 18 mm Bolt ..................................... 53.1 (6)\
Oil Pressure Gauge Sender .............................. 88.5 (10)\
Oil Pan (Upper) ......................................... 53.1 (6\
)
Oil Pan (Lower) ........................................ 97.3 (11\
)
Oil Pump Case ......................................... 123.9 (14)\
Oil Screen (Montero)
6 mm Bolt ............................................. 53.1 (9)\
Rocker Arms & Camshafts
Rocker Cover Bolt ....................................... 31 (3.5)\
Thrust Case Bolt ...................................... 115.1 (13)\
Timing Belt
Camshaft Position (CMP) Sensor (Montero) ................ 79.6 (\
9)
Crankshaft Position (CKP) Sensor ........................ 79.6 (9\
)
( 1) - Tighten cylinder head bolts in 2 or 3 steps with engine cold.
\
\
\
\
\
\
\
ENGINE SPECIFICATIONS
GENERAL SPECIFICATIONS
GENERAL SPECIFICATIONS\
\
\
\
\
\
\
Application Specification
Displacement .................................. 213.4 Cu. In. (3.5L)\
Bore ............................................... 3.6614" (93 mm)\
Page 19 of 1501
A - INTRODUCTION
1998 Mitsubishi Montero
1998 ENGINE PERFORMANCE
Mitsubishi - Introduction
Diamante, Eclipse, Eclipse Spyder, Galant, Mirage, Montero,
Montero Sport, 3000GT
1997-98 MODEL COVERAGE
ENGINE/VIN IDENTIFICATION
ENGINE/VIN IDENTIFICATION TABLE \
\
\
\
\
\
\
BODY ENGINE FUEL IGNITION
MODEL CODE (1) ENGINE (2) ID (3)SYSTEM SYSTEM (5)
\b\
\b\
\
\
\b\b\
\b\
\
Diamante 7 3.5L V6 (6G74) SOHC P SFI Hall Effect
(
4) ( 6)
\b\
\b\
\
\
\b\b\
\b\
\
Eclipse 4 2.0L 4-Cyl. (420A) Y SFI DIS (
7)
DOHC (
4)
\
\
\b\
\b\b\
\
2.0L 4-Cyl. (4G63) F SFI DIS (
7)
DOHC Turbo (
4)
\b\
\b\
\
\
\b\b\
\b\
\
Eclipse 5 2.0L 4-Cyl. (4G63) F SFI DIS (
7)
Spyder DOHC Turbo (
4)
\
\
\b\
\b\b\
\
2.4L 4-Cyl. (4G64) G SFI DIS (
7)
SOHC (
4)
\b\
\b\
\
\
\b\b\
\b\
\
Galant 6 2.4L 4-Cyl. (4G64) G SFI Hall Effect
SOHC (
4) ( 6)
\b\
\b\
\
\
\b\b\
\b\
\
Mirage 1, 6 1.5L 4-Cyl. (4G15) A SFI Hall Effect
SOHC (
4) ( 6)
\
\
\b\
\b\b\
\
1.8L 4-Cyl. (4G93) C SFI DIS (
7)
SOHC (
4)
\b\
\b\
\
\
\b\b\
\b\
\
Montero 1 3.5L V6 (6G74) SOHC M SFI DIS (
7)
(
4)
\b\
\b\
\
\
\b\b\
\b\
\
Montero 1 2.4L 4-Cyl. (4G64) G SFI Hall Effect
Sport SOHC (
4) ( 6)
\
\
\b\
\b\b\
\
3.0L V6 (6G72) SOHC P SFI DIS (
7)
(
4)
\b\
\b\
\
\
\b\b\
\b\
\
3000GT 4, 5 3.0L V6 (6G72) SOHC H SFI Hall Effect
(
4) ( 6)
\
\
\b\
\b\b\
\
3.0L V6 (6G72) DOHC J SFI DIS (
7)
(
4)
\
\
\b\
\b\b\
\
3.0L V6 (6G72) DOHC K SFI DIS (
7)
Turbo (
4)
\
\
\
\
\
\
\
(
1) - Body code is seventh character of Vehicle Identification
Number (VIN). VIN is located on upper left corner of
Page 20 of 1501
instrument panel.
(
2) - See Figs. 1 and 2.
(
3) - Engine ID is eighth character of VIN.
(
4) - Fuel system is a Sequential Fuel Injection (SFI) system.
(
5) - Ignition timing is computer-controlled.
(
6) - This system may also be referred to as distributor ignition.
(
7) - This system may also be referred to as distributorless
ignition.
\
\
\
\
\
\
\
\f
VIN DEFINITION
J A 3 A Y 3 6 A 1 W U 0 0 0 0 0 1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
1 - Indicates Nation of Origin.
2 - Indicates Manufacturer.
3 - Indicates Vehicle Type.
4 - Indicates Restraint System. ( 1)
5 - Indicates Model.
6 - Indicates Vehicle Series.
7 - Indicates Body Type.
8 - Indicates Engine Type and Make.
9 - Indicates Check Digit.
10 - Indicates Model Year.
11 - Indicates Assembly Plant.
12-17 - Indicates Serial Number.
( 1) - On Montero & Montero Sport, fourth character of VIN indicates
GVWR.
VIN CODE/YEAR APPLICATIONS
VIN CODE/YEAR APPLICATION TABLE\
\
\
\
\
\
VIN Code Model Year
T ................................................... 1996
V ................................................... 1997
W ................................................... 1998
\
\
\
\
\
\
ENGINE CODE LOCATIONS
Fig. 1: Engine Code Locations (Diamante)
Courtesy of Chrysler Corp.
Page 26 of 1501
\
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
B/P Backpressure
BAC By-Pass Air Control
BAP Barometric Absolute Pressure Sensor
BARO Barometric
BBDC Before Bottom Dead Center
BCM Body Control Module
BDC Bottom Dead Center
BHP Brake Horsepower
BLK Black
BLU Blue
BMAP Barometric & Manifold Absolute Pressure Sensor
BOO Brake On-Off Switch
BP Barometric Pressure sensor
BPS Barometric Pressure Sensor
BPT Backpressure Transducer
BRN Brown
BTDC Before Top Dead Center
BTU British Thermal Unit
BVSV Bimetallic Vacuum Switching Valve
Baro. Barometric
Batt. Battery
Bbl. Barrel (Example: 4-Bbl.)
Blst. Ballast
Blwr. Blower
Brkr. Breaker
\
\
\
\
\
\
\
\f
"C" ABBREVIATION TABLE
"C" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
C Celsius (Degrees)
C(3) I Computer Controlled Coil Ignition
C(4) Computer Controlled Catalytic Converter
CANP Canister Purge solenoid
CARB California Air Resources Board
CAT Catalytic Converter
CB Circuit Breaker
CBD Closed Bowl Distributor
CBVV Carburetor Bowl Vent Valve
cc Cubic Centimeter
CCC Computer Command Control
CCD Computer Controlled Dwell
CCM Central Control Module
CCO Converter Clutch Override
CCOT Cycling Clutch Orifice Tube
CCW Counterclockwise
CDI Capacitor Discharge Ignition
CEC Computerized Engine Control
CFI Central Fuel Injection
CID Cubic Inch Displacement
CID Cylinder Identification sensor
CIS Continuous Injection System
CIS-E Continuous Injection System-Electronic
CKT Circuit
CLR Clear
CNG Compressed Natural Gas
Page 27 of 1501
CO Carbon Monoxide
CO2 Carbon Dioxide
CONV Convertible
CP Canister Purge
CPA Connector Position Assurance
CPS Crank Position Sensor
CTS Coolant Temperature Sensor
CV Check Valve or Constant Velocity
CVC Constant Vacuum Control
CW Clockwise
CYL or Cyl. Cylinder
Calif. California
Carb. Carburetor
Chrg. Charging
Circ. Circuit
Cntrl. Control
Comp. Compressor or Compartment
Conn. Connector
Cont. Continued
Conv. Convertible or Converter
Cu. In. Cubic Inch
Cyl. Cylinder
\
\
\
\
\
\
\
\f
"D" ABBREVIATION TABLE
"D" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
"D" Drive
DBC Dual Bed Catalyst
DC Direct Current or Discharge
DDD Dual Diaphragm Distributor
DERM Diagnostic Energy Reserve Module
DFI Digital Fuel Injection
DIC Driver Information Center
DIS Direct Ignition System
DIS Distributorless Ignition System
DIST Distribution
DISTR Distributor
DK BLU Dark Blue
DK GRN Dark Green
DME Digital Motor Electronics (Motronic System)
DOHC Double Overhead Cam
DOT Department of Transportation
DP Dashpot
DRB-II Diagnostic Readout Box
DVOM Digital Volt/Ohm Meter (see VOM)
Def. Defogger or Defroster
Def. Defrost
Defog. Defogger
Diag. Diagnostic
Dist. Distributor or Distribution
Dr. Door
\
\
\
\
\
\
\
\f
"E" ABBREVIATION TABLE
"E" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
Page 28 of 1501
\
\b\
\
\
\
\
\
EAC Electric Assist Choke
EACV Electric Air Control Valve
EBCM Electronic Brake Control Module
ECA Electronic Control Assembly
ECAT Electronically Controlled Automatic Transaxle
ECM Electronic Control Module
ECT Engine Coolant Temperature Sensor
ECU Electronic Control Unit or Engine Control Unit
EDF Electric Drive Fan relay assembly
EDIS Electronic Distributorless Ignition System
EEC Electronic Engine Control
EECS Evaporative Emission Control System
EEPROM Electronically Erasable PROM
EFE Early Fuel Evaporation
EFI Electronic Fuel Injection
EGO Exhaust Gas Oxygen sensor (see HEGO)
EGR Exhaust Gas Recirculation system
EGRC EGR Control solenoid or system
EGRV EGR Vent solenoid or system
EMR Emission Maintenance Reminder Module
ESA Electronic Spark Advance
ESC Electronic Spark Control
EST Electronic Spark Timing
ETR Emergency Tensioning Retractor
EVAP Fuel Evaporative System
EVIC Electronic Vehicle Information Center
EVO Electronic Variable Orifice
EVP EGR Valve Position Sensor
EVR EGR Valve Regulator
EVRV Electronic Vacuum Regulator Valve
Elect. Electronic
Eng. Engine
Evap. Evaporative
Exc. Except
\
\
\
\
\
\
\
\f
"F" ABBREVIATION TABLE
"F" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
F Fahrenheit (Degrees)
F/B Fuse Block
FBC Feedback Carburetor
FI Fuel Injector or Fuel Injection
FICD Fast Idle Control Device
FIPL Fuel Injector Pump Lever
FP Fuel Pump
FPM Fuel Pump Monitor
FPR-VSV Fuel Pressure Regulator Vacuum Switching Valve
FWD Front Wheel Drive
Fed. Federal
Ft. Lbs. Foot Pounds
\
\
\
\
\
\
\
\f
"G" ABBREVIATION TABLE
"G" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
Page 29 of 1501
\
\b\
\
\
\
\
\
g grams
GND or GRND Ground
GRN Green
GRY Gray
Ga. Gauge
Gals. gallons
Gov. Governor
\
\
\
\
\
\
\
\f
"H" ABBREVIATION TABLE
"H" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
H/D Heavy Duty
HAC High Altitude Compensation
HC Hydrocarbons
HEDF High Speed Electro Drive Fan relay or circuit
HEGO Heated Exhaust Gas Oxygen Sensor
HEGOG HEGO Ground circuit
HEI High Energy Ignition
HLDT Headlight
HO High Output
HP High Performance
HSC High Swirl Combustion
HSO High Specific Output
HTR Heater
HVAC Heating
Headlt. Headlight
Hg Mercury
Hgt. Height
Htr. Heater
Hz Hertz (Cycles Per Second)
\
\
\
\
\
\
\
\f
"I" ABBREVIATION TABLE
"I" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
I.D. Inside Diameter
IAC Idle Air Control
IACV Idle Air Control Valve
IC Integrated Circuit
ID Identification
IDM Ignition Diagnostic Monitor
IGN Ignition system or circuit
ILC Idle Load Compensator
In. Hg Inches of Mercury
INCH Lbs. Inch Pounds
INFL REST Inflatable Restraint
INJ Injector or Injection
IP Instrument Panel
IPC Instrument Panel Cluster
ISA Idle Speed Actuator
ISC Idle Speed Control
ISS Idle Stop Solenoid
ITS Idle Tracking Switch
IVSV Idle Vacuum Switching Valve
Page 30 of 1501
Ign. Ignition
In. Inches
Inj. Injector
\
\
\
\
\
\
\
\f
"J" ABBREVIATION TABLE
"J" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
J/B Junction Block
\
\
\
\
\
\
\
\f
"K" ABBREVIATION TABLE
"K" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
k/ohms 1000 ohms (kilo as in k/ohms)
kg Kilograms (weight)
kg/cm Kilograms Per Square Centimeter
KAM Keep Alive Memory
KAPWR Keep Alive Power
KM/H Kilometers Per Hour
KOEO Key On Engine Off
KOER Key On Engine Running
KS Knock Sensor
\
\
\
\
\
\
\
\f
"L" ABBREVIATION TABLE
"L" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
L Liter(s)
L/D Light Duty
LCD Liquid Crystal Display
LED Light Emitting Diode
LH Left Hand
LOS Limited Operation Strategy
LT BLU Light Blue
LT GRN Light Green
LUS Lock-Up Solenoid
Lbs. Pounds
Lt(s). Light(s)
Lugg. Luggage
\
\
\
\
\
\
\
\f
"M" ABBREVIATION TABLE
"M" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
mA Milliamps
mV Millivolts
mfd. Microfarads
Page 32 of 1501
"P" ABBREVIATION TABLE
"P" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
"P" Park
P/C Printed Circuit
P/N Park/Neutral
P/S Power Steering
PAV Pulse Air Valve
PC-SOL Purge Control Solenoid
PCM Powertrain Control Module
PCS Purge Control Solenoid
PCSDM Passenger Compartment Sensor/Diagnostic Module
PCV Positive Crankcase Ventilation
PFE Pressure Feedback EGR sensor or circuit
PFI Port Fuel Injection (see MA SEFI)
PGM-CARB Programmed Carburetor
PGM-FI Programmed Fuel Injection
PIP Profile Ignition Pickup
PNK Pink
PPL Purple
PRNDL Park Reverse Neutral Drive Low
PROM Programmable Read-Only Memory
psi Pounds Per Square Inch
PSPS Power Steering Pressure Switch
PTC Positive Temperature Coefficient
PTO Power Take-Off
PWR GND Power Ground circuit
Pkg. Package
Press. Pressure
Prog. Programmed or Programmable
Pts. Pints
Pwr. Power
\
\
\
\
\
\
\
\f
"Q" ABBREVIATION TABLE
"Q" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
Qts. Quarts
\
\
\
\
\
\
\
\f
"R" ABBREVIATION TABLE
"R" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
RABS Rear Anti-Lock Brake System
RAC Remote Accessory Control
RAM Random Access Memory
RAP Retained Accessory Power
RECIRC Recirculation
RED Red
RH Right Hand
ROM Read Only Memory
RPM Revolutions Per Minute
Page 33 of 1501
RVB Rear Vacuum Break
RWAL Rear Wheel Anti-Lock Brake
RWD Rear Wheel Drive
Recirc. Recirculate or Recirculation
Reg. Regulator
Rly. Relay
\
\
\
\
\
\
\
\f
"S" ABBREVIATION TABLE
"S" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
SAW Spark Angle Word
SBC Single Bed Converter
SBEC Single Board Engine Controller
SC Super Charged
SCC Spark Control Computer
SCS Air Suction Control Solenoid
SDM Supplemental Restraint System Diagnostic Module
SDU SRS Diagnostic Unit
SEN Sensor
SES Service Engine Soon
SFI Sequential (Port) Fuel Injection
SIG RTN Signal Return circuit
SIL Shift Indicator Light
SIR Supplemental Inflatable Restraint
SMEC Single Module Engine Controller
SOHC Single Overhead Cam
SOL or Sol. Solenoid
SPFI Sequential Port Fuel Injection
SPK Spark Control
SPOUT Spark Output Signal
SRS Supplemental Restraint System (Air Bag)
SS 3/4-4/3 Shift Solenoid circuit
SSI Solid State Ignition
STAR Self-Test Automatic Readout
STI Self Test Input circuit
STO Self-Test Output
SUB-O2 Sub Oxygen Sensor
Sen. or Sens. Sensor
Sol. Solenoid
Sprchg. Supercharger
Strg. Steering
Susp. Suspension
Sw. Switch
Sys. System
\
\
\
\
\
\
\
\f
"T" ABBREVIATION TABLE
"T" ABBREVIATION TABLE \
\
\
\
\
\
\
ABBREVIATION DEFINITION
\
\b\
\
\
\
\
\
T.V. Throttle Valve
TAB Thermactor Air By-Pass
TAC Thermostatic Air Cleaner
TAD Thermactor Air Diverter
TAN Tan
TBI Throttle Body Injection