engine Peugeot 208 2012 Manual PDF

194
Checks






Checks
12 V battery

The battery does not require any maintenance.
However, check that the terminals are clean
and correctl
y tightened, particularly in summer and winter.
When carrying out work on the battery, refer to the
"Practical information" section for details of the precautions
to be taken before disconnecting the battery and following its reconnection.
The presence of this label, in particular with
the Stop & Star t system, indicates the use of a specific 12 V lead-acid battery with special
technology and specification. The involvement
of a PEUGEOT dealer or a qualified workshop
is essential when replacing or disconnecting
the battery.
Par ticle emissions filter (Diesel)

The start of saturation of thepar ticle filter is indicated by the
temporary illumination of this warning lamp
accompanied by a warning message in the screen.
As soon as the traffic conditions permit,
regenerate the filter by driving at a speed of at
least 40 mph (60 km/h) until the warning lamp
goes off.
If the warning lamp stays on, this indicates a
low additive level.

On a new vehicle, the first par ticlefilter regeneration operations may be accompanied by a "burning" smell,
which is perfectly normal.
Following prolonged operation of the vehicle at very low speed or at idle, you may, in exceptional circumstances,notice the emission of water vapour at the exhaust on acceleration. This does not affect the behaviour of the vehicle or the environment. Unless other wise indicated, check these components in accordance with the ser vicin
g booklet and according to your engine.Other wise, have them checked by a PEUGEOT dealer or a qualified workshop.
Air filter and passenger compartment filter

Refer to the ser vicing booklet for
details of the replacement inter vals
for these components.
Depending on the environment (e.g.
dusty atmosphere) and the use of the vehicle(e.g. city driving), replace them twice as oftenif necessary.y A clogged passenger compar tment filter may
have an adverse effect on the performance
of the air conditioning system and generateundesirable odours.
Oil filter
Replace the oil filter each time theengine oil is changed.
Refer to the servicing booklet for
details of the replacement inter val for
this component.

195
8
Checks
Manual gearbox
The gearbox does not require anymaintenance (no oil change).
Refer to the servicing booklet for the
details of the level checking interval
for this component.
Electronic gearbox
The gearbox does not require any maintenance (no oil change).
Refer to the servicing booklet for
details of the checking inter val for thiscomponent.
Automatic gearbox
The gearbox does not require anymaintenance (no oil change).
Refer to the ser vicing booklet for
details of the level checkin
g interval
for this component. Brake wear depends on the st
yleof driving, par ticularly in the caseof vehicles used in town, over shor t
distances. It may be necessary tohave the condition of the brakes checked, even between vehicle services. Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake pads are worn.
Brake pads

For information on checking brake
disc wear, contact a PEUGEOT
dealer or a qualified workshop.
Brake disc wear
Parking brake
If excessive travel or a loss of
effectiveness of this system isnoticed, the parking brake must be checked, even between two ser vices.
Checkin
g this system must be done by a
PEUGEOT dealer or a qualified workshop.

















Only use products recommended by PEUGEOT or products of equivalent quality and specification.
In order to optimise the operationof units as impor tant as the braking system, PEUGEOT selects and offers very specific products.
To avoid damaging the electrical units, the use of a high pressure washer in the engine compar tment is strictly prohibited.

196
Technical data
ENGINES AND GEARBOXES
Petrol engines1.1 l i t r e V T i68 hp1.2 litre VTi82 hp1.4 litre VTi95 hpVTi110 hp
GearboxesManual(5-speed)
Manual(5-speed)
Electronic(5-speed)


Manual(5-speed)


Automatic
(4-speed)


Model codes : CC... CA...

ZMZ0


HMZ0 - HMX0


HMZ0/PS
8FP0 - 8FN05FS9


Cubic capacity (cc) 999

1 199

1 397
1 598

Bore x stroke (mm)

71 x 84.1
75 x 90.5

77 x 75
77 x 85.8

Max power: EU standard
(kW) 506070
105

Max power engine speed (rpm)
6 000 6 000
6 000
6 000
Max torque: EU standard
(Nm) 95

118
136

160

Max torque engine speed (rpm) 3 000
2 750

4 000
3 560

F
uel Unleaded Unleaded Unleaded Unleaded

Catalytic conver ter yes yes
yes
yes
OIL CAPACITIES (in litres)

Engine (with filter replacement) -3.2
4.25-
.../S: model fitted with Stop & Star t.

9
197
Technical data
ENGINES AND GEARBOXES
Petrol engines1.6 litre VTi120 hp1.6 lite THP 155 hp
Gearboxes

Manual(5-speed)


Manual(6-speed)
Model codes: CC... CA...5FS05FV8
Cubic capacity (cc)
1 598

1 598

Bore x stroke (mm)
77 x 85.8
77 x 85.8

Max power: EU standard (kW) 88
115

Max power en
gine speed (rpm) 6 000
6 000
Max torque: EU standard
(Nm)

160240

Max torque en
gine speed (rpm) 4 250

1 750

F
uel Unleaded Unleaded

Catalytic converter yes
yes
OIL CAPACITIES (in litres)

Engine (with filter replacement)
4.25-

198
Technical data
Petrol engines1.1 litre VTi68hp1.2 litre VTi 82 hp
GearboxesManual (5-speed)


Manual(5-speed)


Electronic
(5-speed)

Model codes: CC... CA....ZMZ0


HMZ0 - HMX0
HMZ0/PS
Body3-door
5-door
3-door
5-door
3-door
5-door


- Unladen wei
ght 960
975960975 965 980



- Kerb weight *

1 0351 050
1 035
1 050 1 040
1 055


- Gross vehicle wei
ght (GV W)
1 4841 527 1 540



-
Gross train weight (GTW)

on a 12 % gradient1 934
2 347
2 040


- Braked trailer
(within GTW limit) on a 10 % or 12 % gradient450 820
500



- Braked trailer ** (with load transfer within the
GTW limit)
750
1 15 0
825



- Unbraked trailer
450
520
500



- Recommended nose weight 30

46

29

*
The kerb weight is equal to the unladen weight + driver (75 kg).
**
The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
The
GTW and towed load values indicated are valid up to a maximum altitude of 1000 metres; the towed load mentioned must be reduced by 10 % for
each additional 1000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the per formance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.

9
199
Technical data
*
The kerb weight is equal to the unladen weight + driver (75 kg). **

The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
WEIGHTS AND TOWED LOADS (in kg)
Petrol engine s 1.4 litre V Ti 95 hpVTi110 hp
Gearbox

Manual(5-speed)


Automatic
(4-speed)

Model codes: CC... CA...
8FP0 - 8FN0
5FS9
Body3-door
5-door

3-door 5-door


- Unladen wei
ght 1 055 1 070
1 1201 150



- Kerb weight *1 130
1 145
1 195
1 225


- Gross vehicle wei
ght (GV W)
1 590
1 605
1 632



- Gross train weight (GTW)
on a 12% gradient 2 530
2 565 2 582


- Braked trailer
(within GTW limit)
on a 10% or 12% gradient 940
960950



- Braked trailer ** (with load transfer within the
GTW limit) 1 15 0
1 15 0



-
Unbraked trailer 570
580



- Recommended nose wei
ght 46

46

The GTW and towed load values indicated are valid up to a maximum altitude of 1000 metres; the towed load mentioned must be reduced b
y 10 % for
each additional 1000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C, limit the towed load.

200
Technical data
The GTW and towed load values indicated are valid up to a maximum altitude of 1000 metres; the towed load mentioned must be reduced by 10 % for each additional 1000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit th
e towed load.
*
The kerb weight is equal to the unladen weight + driver (75 kg). **

The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
WEIGHTS AND TOWED LOADS (in kg)
Petrol engines1.6 litre VTi 120 hp1.6 litre THP 155 hp
GearboxesManual (5-speed)

Manual (6-speed)

Model codes: CC... CA...

5FS0

5FV8

Body
3-door
5-door
3-door


- Unladen wei
ght1 0801 090
1 090



- Kerb wei
ght *


1 155
1 165 1 165


- Gross vehicle wei
ght (GV W)
1 605
1 640



-
Gross train weight (GTW)
on a 12% gradient
2 565 2 570


- Braked trailer
(within GTW limit)
on a 10% or 12% gradient 960
930



- Braked trailer ** (with load transfer within the
GTW limit) 1 15 0
1 15 0



- Unbraked trailer
580
580



- Recommended nose weight
46
46

9
201
Technical data
ENGINES AND GEARBOXES
Diesel engine s 1.4 litre HDi68 hp1.4 litre e- HDi 68 hp1.6 litre e- HDi92 hp
GearboxesManual (5-speed)Electronic
(5-speed)
Manual (5-speed)
Model codes: CC... CA...
8HR0
8HP0/PS
9HP0/S
Cubic capacity (cc) 1 398

1 560

Bore x stroke (mm)
73.7 x 82 75 x 88.3

Max power: EU standard
(kW) 5068

Max power en
gine speed (rpm)
4 000 4 000
Max torque: EU standard
(Nm)

160230

Max torque en
gine speed (rpm)
1 750
1 750

Fuel Diesel
Diesel

Catalytic converter yesyes
P
article emission filter yesyes

OIL CAPACITIES
(in litres)




En
gine (with filter replacement) 3.753.75

.../S: e-HDi model fitted with Stop & Star t.

202
Technical data
ENGINES AND GEARBOXES
Diesel engines1.6 litree-HDi 92 hp1.6 litre e- HDi115 h p
GearboxesElectronic
(6-speed)Manual (6-speed)

Model codes: CC... CA...
9HPP - 9HP8/PS9HD8/S - 9HR8/S
Cubic capacity (cc) 1 560

1 560

Bore x stroke (mm)

75 x 88.3

75 x 88.3

Max power: EU standard
(kW) 6884
Max power en
gine speed (rpm)
4 000 3 600
Max torque: EU standard
(Nm)
230270

Max torque engine speed (rpm) 1 750

1 750

F
uel
Diesel Diesel

Catalytic conver ter yesyes

P
article emission filter yesyes

OIL CAPACITIES
(in litres)
Engine (with filter replacement) -3.75
...
/S: e-HDi model fitted with Stop & Start.

9
203
Technical data

The GTW and towed load values indicated are valid up to a maximum altitude of 1000 metres; the towed load mentioned must be reduced by 10 % for
each additional 1000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.


* The kerb wei
ght is equal to the unladen weight + driver (75 kg).

**
The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
WEIGHTS AND TOWED LOADS (in kg)
Diesel engines1.4 litre HDi68 hp1.4 litre e - HDi 68 hp
Gearboxes

Manual(5-speed)
Electronic(5-speed)

Model codes: CC... CA...8HR0

8HP0/PS
Body3-door
5-door

3-door 5-door


- Unladen wei
ght 1 035 1 0501 045 1 060



- Kerb wei
ght *

1 110
1 125
1 120
1 135


- Gross vehicle wei
ght (GV W)
1 580
1 580



- Gross train weight (GTW)
on a 12% gradient 1 980
2 080


- Braked trailer
(within GTW limit) on a 10% or 12% gradient
400500



- Braked trailer **
(with load transfer with the
GTW limit) 725 825



- Unbraked trailer
400500



- Recommended nose wei
ght
29
29