gearbox Peugeot 307 Break Dag 2002 User Guide

Only use products appro-
ved by Automobiles
PEUGEOT.
To ensure best perfor- mance from components
as important as the power stee-ring and the braking system, PEUGEOT selects and offersquite specific products.
CHECKS Battery
At the start of winter, have your bat-
tery checked by a PEUGEOT dealer. Air filter and pollen filter Have the filter elements replaced
regularly. If you drive in dusty
conditions, change them twice asoften. Brake pads Brake pad wear depends on the style of driving, in particular forvehicles which are used in town,over short distances. It may benecessary to check the thickness ofthe pads, even between services. Handbrake Where the handbrake travel is too great or there is a reduction in theperformance of the system, thehandbrake should be adjusted, evenbetween services. Have the system checked by a
PEUGEOT dealer. Manual gearbox This does not need an oil change. Check the level, according to themanufacturer's servicing schedule. Automatic gearbox* This does not need an oil change. Have the level checked by a
PEUGEOT dealer, according to themanufacturer's servicing schedule. Oil filter
Change the filter regularly, in accor- dance with the servicing schedule.
RUNNING OUT OF FUEL (DIESEL) If you should run out of fuel, it is necessary to re-prime* the circuit: 2 litre HDI engine
- fill the fuel tank with at least five
litres of diesel,
- operate the manual re-priming pump, until you feel resistance during the manoeuvre,
- operate the starter until the engine starts.
1.4 litre HDI engine
- fill the fuel tank with at least five litres of diesel,
- operate the manual re-priming pump, until fuel appears in the transparent pipe under the bonnet,
- operate the starter until the engine starts.
* According to specification.
PRACTICAL INFORMATION
100

CHANGING A WHEEL Parking the vehicle Park the vehicle on level, stable and non-slippery ground.
Apply the handbrake, engagefirst or reverse gear (position P
for the automatic gearbox) and
switch off the ignition.
Access to the spare wheeland the jack in the boot Lift the floor using the handle and secure it by hooking the cords tothe hooks of the parcel shelf. Tools The following tools are located in a polystyrene holder in the centre ofthe spare wheel: 1 -
Wheelbrace.
2 - Centralising tool.
3 - Removable chock.
4 - Jack with handle.
5 - Removable towing eye.
6 - Alloy wheel bolt trim remover*. Removing the wheel
Place the holder and the chock 3
(or chock 3on its own if neces-
sary) under the wheel diagonally opposite to the one to be changed.
Remove the trim*, using thewheelbrace 1, pulling at the valve
passage hole.
Loosen the wheel bolts (forvehicles fitted with alloy wheels,remove the chrome trim first. Seeparagraph on "Special featuresof alloy").
* According to specification
PRACTICAL INFORMATION 101

Place the jack 4in contact with
one of the four locating points A
on the sub-frame, (the one which is closest to the wheel to bechanged).
Extend the jack 4until its base is
in contact with the ground.Ensure that the centre line of thebase of the jack is straight abovethe locating point A.
Raise the vehicle.
Unscrew the bolts and removethe wheel.
Fitting a wheel Position the wheel using the cen- tralising tool to assist you.
Tighten the bolts by hand andremove the centralising tool.
Partly tighten the bolts using thewheelbrace 1.
Fold the jack and 4and remove it.
Fully tighten the bolts using thewheelbrace 1.
Replace the wheel trim*, startingby placing the wheel trim notchopposite the valve, and press iton using the palm of the hand.
Put the tools and the wheel backin the boot.
Note: a diagram on the holder indi-
cates the location of the tools.
Tighten the spare wheel securing strap to prevent noise and for yoursafety in the event of impact.
* According to specification
PRACTICAL INFORMATION
102
For your safety, always change the wheel:
- on level, stable, non-slippery ground,
- with the handbrake on and the ignition switched off,
- with first or reverse gear enga- ged (position Pfor the automatic
gearbox),
- with the vehicle chocked. Never go underneath a vehicle that is supported only by a jack(use a ramp) After changing the wheel:
- have the tightening of the bolts and the tyre pressure checked by a PEUGEOT dealer as soonas possible.
- have the punctured wheel repai- red and refit it to the vehicle assoon as possible.

PRACTICAL INFORMATION109
Fuse N¡ Rating*
Functions*
1 10 A Automatic gearbox reversing lights switch - Automatic gearbox starting inhibitor relay control - Manual gearbox reversing
lights switch - Vehicle speed sensor - Pre-heating control unit -
Water in diesel sensor - DW air flow sensor.
2 15 A Canister solenoid valve - Fuel pump.
3 10 A Power steering control unit - ABS or ESP control unit.
4 10 A Injection control unit - Fan unit relay control - Additional heating relay control -
Automatic gearbox control unit - Automatic gearbox sequential control -
Automatic gearbox shiftlock relay.
5 15 A Particulate emission filter control unit.
6 15 A Front fog lamps.
7 20 A Headlamp wash pump.
8 20 A Fan unit relay control - Injection supply control unit.
9 15 A Left dipped beam
10 15 A Right dipped beam
11 10 A Left main beam
12 10 A Right main beam
13 15 A Horn
14 10 A Front and rear headlamps wash pump
15 30 A Oxygen sensors - Exhaust gas recirculation solenoid valve - Ignition coil - Diesel high pressure regulator - Injectors supply (petrol).
16 40 A Petrol engine air pump with automatic gearbox.
17 30 A Low/high speed front wiper.
18 40 A Air conditioning blower.
* According to specification.

PRACTICAL INFORMATION107
Fuse no. Rating*
Functions*
9 30 A Electric windows - Press operation windows (incompatible with non-press operation windows) - Sunroof.
10 15 A Diagnostic socket - 12 volts rear socket.
11 15 A Audio equipment - Multifunction display B - Steering whel controls - Automatic gearbox.
12 10 A Front right side lights, rear right side lights, number plate and trailer lighting -
Central locking switches/ alarm/ESP/hazard warning lights - Air conditioning/ash
tray light - Heated seats switches - Lighter - Automatic gearbox switches -
Headlamp beam corrector.
14 30 A Door opening/closing controls - Deadlocking controls.
15 30 A Rear windows.
16 5 A Engine fuse box - Alarm - Particulate emission filter - Steering wheel controls - Airbags.
17 10 A Rear right brake light, additional brake light Front electric window/sunroof.
18 10 A Diagnostic socket - Steering wheel controls - Brake pedal (stop) and clutch switches - Coolant level switch - Second brake switch.
19 30 A PARC shunt.
22 10 A Front left side light, rear left side light - Number plate and trailer lighting.
23 15 A Alarm siren - Interior alarm control unit.
24 15 A Instrument panel - Audio equipment - Multifunction display - Air conditioning.
26 30 A Heated rear screen.
* According to specification

TOWING YOUR VEHICLE
Without lifting (4 wheels on the road)
You should always use a tow bar. The towing eye is inside the spare wheel. From the front: Unclip the cover, by pressing the bottom part,
Screw in the towing eye as far as it will go.
From the rear: Unclip the top of the cover using a coin,
Screw in the towing eye as far as it will go.
Lifting (2 wheels only on the road) It is preferable to raise the vehicle with a professional lifting device. Special features of the automatic gearbox When towing with four wheels on the ground, the following rules must beobeyed:
- lever in position
N,
- tow the vehicle at less than 30 mph (50 km/h) over a maximum distan- ce of 30 miles (50 km).
- do not add oil to the gearbox.
PRACTICAL INFORMATION
112
When towing with the engine switched off, thereis no braking assistance.

TECHNICAL DATA
116
3CKFWB/T 3CNFUB 3CNFUE 3CRFNB 3CRFNE
3AKFWB/T 3ANFUB 3ANFUE 3ARFNB 3ARFNE
Manual Manual Automatic Manual Automatic
(5 speed) (5 speed) (4 speed) (5 speed) (4 speed) PETROL ENGINES / COMPANY
ENGINES 1,4 litre 1,6 litre 16V 2 litre 16V Cubic capacity (cm
3
) 1 360 1 587 1 997
Bore x stroke (mm) 75 x 77 78.5 x 82 85 x 88EU standard maximum
power (kW) 55 80 99 Maximum power at engine
speed (rpm) 5 500 5 500 6 000
EU standard maximum torque (Nm)120 150 190
Maximum torque at engine speed (rpm)3 000 4 500 4 100
Fuel Unleaded Unleaded Unleaded
Catalytic converter Yes Yes Yes
UNIT CAPACITIES (in litres)
Engine (with cartridge replacement)3.25 3 3 4.25 4.25
Gearbox-Final drive 2 2 - 1,9 -
Models Model codes GEARBOX

TECHNICAL DATA117
3C8HZB/T 3CRHYB/T 3CRHSB
3ARHYB/T 3ARHYB/T 3ARHSB
Manual Manual Manual Automatic
(5 speed) (5 speed) (5 speed) (4 speed) DIESEL ENGINES / COMPANY
ENGINES1.4 LITRE TURBO HDI2 LITRE TURBO HDI 2 LITRE TURBO HDI
Cubic capacity (cm 3
) 1 398 1 998 1 997
Bore x stroke (mm) 73,7 x 82 85 x 88 85 x 88 EU standard maximum
power (kW) 50 66 80 Maximum power at engine
speed (rpm) 4 000 4 000 4 000 EU standard maximum
torque (Nm) - 205 250 Maximum torque at engine
speed (rpm) 2 000 2 000 1 750
Fuel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes
UNIT CAPACITIES (in litres)
Engine (with cartridge replacement) 4,3 4,5 4,5 4,5
Gearbox-Final drive - 1,9 1,85 -
Models Model codes GEARBOX

TECHNICAL DATA
118
Fuel consumption values correct at time of printing.
Consumption In accordance with directive 93/116 [In MPG (litres/100km)]
Engine Gearbox Model Circuit Circuit Circuit Emission of
codes Urban Inter-urban Mixed CO 2by
3C...3A... weight g/Km
1.4 litre Manual KFWB/T
32.5 (8.7) / 32.5 (8.7) 51.4 (5.5) / 51.4 (5.5) 42.2 (6.7) / 42.2 (6.7) 159 / 159
1.4 litre Turbo HDI Manual8HZB/T51.4 (5.5) / 51.4 (5.5) 4.0 / 4.0 4.5 / 4.5 120 / 120
1.6 litre 16V ManualNFUB29.7 (9.5) 48.7 (5.8) 39.2 (7.2) 169
1.6 litre 16V AutomaticNFUE25.9 (10.9) 45.6 (6.2) 35.8 (7.9) 189
2 litre 16 V ManualRFNB 25.9 (10.9) 45.6 (6.2) 35.8 (7.9) 188
2 litre 16V AutomaticRFNE22.8 (12.4) 42.1 (6.0) 32.5 (8.3) 198
2 litre Turbo HDI ManualRHYB/T40.9 (6.9)/40.9 (6.9) 65.7 (4.3)/65.7 (4.3) 54.3 (5.2)/54.3 (5.2) 138/138
2 l. Turbo HDI (120g)ManualRHSB7,0 4,2 5,2 138

3 and 5 DOOR PETROL / COMPANY
Engine
1,4 litre 1,6 litre 16V 2 litre 16V
GearboxManual Manual Automatic Manual Automatic
Model codes : 3CÉ 3AÉ KFWB/T NFUB NFUE RFNB RFNE
¥ Kerb weight 1 234 1 217 1 268 1 251 1 304 1 287 1 294 1 277 1 330 1 313
¥ Gross vehicle weight (GVW) 1 659 1 642 1 693 1 673 1729 1 712 1 719 1 702 1 755 1 738
¥ Gross train weight (GTW*) 2 659 2 642 2 893 2 876 2 929 2 912 3 019 3 002 3 055 3 038
¥ Unbraked trailer 590 605 610 625 630 643 625 638 640 656
¥ Braked trailer (within GTW) 1 200 1 200 1 200 1 200 1 200 1 200 1 300 1 300 1 300 1 300
TECHNICAL DATA 119
Weights and Towing loads (in kg)
The speed of a towing vehicle is limited to 60 mph (100 km/h). 3 and 5 DOOR DIESEL / COMPANY
Engine
1,4 litre HDI 2 litre HDI 2 litre HDI (120 g)
GearboxManual Manual Manual
Model codes : 3CÉ 3AÉ 8HZB/T RHYB/T RHSB
¥ Kerb weight 1 271 1 254 1 335 1 318 1 371 1 354
¥ Gross vehicle weight (GVW) 1 696 1 679 1 760 1 743 1 796 1 779
¥ Gross train weight (GTW*) 2 836 2 819 3 060 3 043 3 136 3 119
¥ Unbraked trailer 635 627 655 659 685 677
¥ Braked trailer (within GTW) 1 140 1 140 1 300 1 300 1 340 1 340