Peugeot Expert 2005 Manual Online

78 -
15-01-2005
79
-
15-01-2005
Third brake light
(rear left door) (P 21 W)
F
Unscrew nut A on the inside. F
Take out the unit from the outside F Unscrew the faulty bulb and
change it.
To reit, proceed in the reverse
order.
Practical information

80 -
15-01-2005
81
-
15-01-2005
CHANGING A FUSE
The fuse boxes are located under
the fascia and in the engine compart-
ment.
Fascia fuse box
On the passenger side, open the
glove box.
To open it fully and thus gain access
to the fuses, press the springs lo-
cated on each side.
The spare fuses
A and the pliers B
are located inside the box. Removing and itting a fuse
Before changing a fuse, the cause
of the fault must be found and reme-
died. The fuse numbers are indicated
on the fuse box.
Use the pliers
B.
Always replace a faulty fuse with a
fuse of the same rating.
Correct Incorrect
Pliers B
Practical information

84 -
15-01-2005
85
-
15-01-2005
The electrical circuit of
your vehicle is designed
to operate with standard or
optional equipment.
Before installing other elec-
trical equipment or accessories in
your vehicle, consult a PEUGEOT
dealer.
Some electrical accessories or the
way in which they are itted may have
an adverse effect on the operation of
your vehicle (its electronic control cir-
cuits, the audio circuit and the electri-
cal charging circuit).
PEUGEOT declines any responsi-
bility for expenses incurred through
the repair of your vehicle or for any
malfunctions resulting from the in-
stallation of auxiliary accessories,
not supplied and not recommended
by PEUGEOT and not installed in ac-
cordance with PEUGEOT's instruc-
tions, in particular for any equipment
the power consumption of which ex-
ceeds 10 milliamps.
The maxi fuses provide additional
protection for the electrical systems.
Any work on these fuses must be
carried out by a PEUGEOT dealer.
Engine compartment fuse box
To gain access to the box in the en-
gine compartment (next to the bat-
tery), unclip the cover.
After carrying out work, close the
cover very carefully.
The spare fuses A and the pliers B
are located inside the box
Practical information

84 -
15-01-2005
85
-
15-01-2005
N° Rating
Functions
1 20 A Fuel pump.
2 10 A Right dipped headlamp.
3 10 A Left dipped headlamp.
4 25 A Headlamp wash.
5 - Shunt.
6 10 A Engine immobiliser.
7 10 A Catalytic converter sensor.
8 20 A Towbar.
9 25 A
1-120 W fan assembly.
30 A 1-180 W fan assembly.
10 15 A Fog lamps.
11 - Not used.
12 10 A Left main beam.
13 10 A Right main beam.
MF1 70 A Engine running relay.
MF2 70 A ABS control unit - Ignition switch.
MF3 30 A Air blower - Air conditioning.
MF4 30 A Fan assembly.
Practical information

80 -
15-01-2005
81
-
15-01-2005
CHANGING A FUSE
The fuse boxes are located under
the fascia and in the engine compart-
ment.
Fascia fuse box
On the passenger side, open the
glove box.
To open it fully and thus gain access
to the fuses, press the springs lo-
cated on each side.
The spare fuses
A and the pliers B
are located inside the box. Removing and itting a fuse
Before changing a fuse, the cause
of the fault must be found and reme-
died. The fuse numbers are indicated
on the fuse box.
Use the pliers
B.
Always replace a faulty fuse with a
fuse of the same rating.
Correct Incorrect
Pliers B
Practical information

80 -
15-01-2005
81
-
15-01-2005
N° Rating
Functions
1 - Not used.
2 10 A Diagnostic socket - ABS control unit - Reversing lights - Heated mirrors.
3 - Not used.
4 5 A Instrument panel - Overspeed buzzer - Speed sensor - Water in diesel ilter detector.
5 15 A Cruise control - Brake switch - Clutch switch - Automatic gearbox - Brake l ights.
6 5 A Courtesy light - Instrument panel - Audio equipment.
7 30 A Heated rear screen.
8 30 A Passenger compartment protection unit.
9 5 A Passenger compartment protection unit.
10 - Not used.
11 5 A Fan assembly relay - Compressor relay.
12 10 A Electric windows - Air blower relay - Heated seats relay - Heated rea
r screen switch -
Air conditioning - Pressostat.
13 15 A Hazard lights.
14 30 A Electric windows.
15 - Not used.
16 20 A Heated seats.
17 20 A Horn.
18 10 A Rear fog lamp.
Practical information

82 -
15-01-2005
83
-
15-01-2005
N° Rating
Functions
19 5 A Cruise control - Lights on buzzer - Heated seats switch - Instrument
panel lighting - Audio
equipment - Heated rear screen switch - Automatic gearbox lever - Haza rd lights switch -
Air conditioning control panel.
20 5 A Headlamp height adjustment switch - Front left and front rig ht side lights.
21 5 A Rear left and rear right side lights - Headlamp wash timer - Nu mber plate lights.
22 - Not used.
23 20 A Lighter.
24 10 A Audio equipment.
25 10 A Lights on buzzer - Automatic gearbox buzzer - Electric mirrors - Direction in dicators.
26 30 A Windscreen wipers timer - Windscreen wipers - Wash-wipe pump.
27 - Not used.
28 5 A Instrument panel - Electric windows relay.
Practical information

86 -
15-01-2005
87
-
15-01-2005
- Never disconnect a ter-
minal when the engine is
running.
- Never charge a battery without irst disconnecting the terminals.
- After every reconnection of the bat- tery, switch on the ignition and wait
1 minute before starting to allow
the electronic systems to be initial-
ised. If slight dificulties are experi-
enced after this, please contact a
PEUGEOT dealer. BATTERY
To charge the battery using a
battery charger:
- Disconnect the battery,
- Follow the instructions for use given by the battery charger manu-
facturer,
- Reconnect starting with the nega- tive (-) terminal,
- Check that the terminals and con- nectors are clean. If they are cov-
ered with sulphate (white or greenish
deposit), disconnect them and clean
them.
To start the vehicle from a bat-
tery on another vehicle:
- Switch off the engine on the gener-ating vehicle,
- Connect the red cable to the posi- tive (+) terminals of the two batter-
ies,
- Connect one end of the green or black cable to the negative (-) ter-
minal of the slave battery,
- Connect the other end of the green or black cable to an earth point on
the broken down vehicle as far as
possible from the battery,
- Switch on the generating vehicle,
- Let it run at a slightly accelerated engine speed for approximately
one minute,
- Start the receiving vehicle,
- Operate the starter, let the engine run,
- Wait for the engine to return to idle, then disconnect the cables.
It is advisable to disconnect the
battery if the vehicle is not to be
used for a period of more than
one month.
Practical information

86 -
15-01-2005
87
-
15-01-2005
Contact a PEUGEOT dealer
before itting audio equip-
ment or speakers in your
vehicle.
FITTING AUDIO EQUIPMENT
Your vehicle is equipped with certain
factory-itted audio equipment:
- coaxial aerial cable,
- basic interference suppression,
- supply to front speakers,
- two 8-way connectors.
FITTING SPEAKERS
The factory-itted equipment allows the
itting of 165 mm diameter speakers in
the front doors. Making the connections
A1 : -
A2 : -
A3 : -
A4 : -
A5 : -
A6 : (+ve) Accessories
A7 : (+ve) Permanent
A8 : (-ve) Earth
B1 : (+) -
B2 : (-) -
B3 : (+) Front right speaker
B4 : (-) Front right speaker
B5 : (+) Front left speaker
B6 : (-) Front left speaker
B7 : (+) -
B8 : (-) -
Practical information

88 -
15-01-2005
89
-
15-01-2005
When towing with the en-
gine switched off, there
is no braking or steering
assistance.
TOWING YOUR VEHICLE
Without lifting
(4 wheels on the ground)
You must always use a tow bar.
The towing eyes are located at the
front and the rear under the vehicle's
bumpers.
Lifting (2 wheels only on the
ground)
It is preferable to raise the vehicle
with a professional lifting device.
Never use the radiator crossmember.
Practical information